Volvo FH12 with engine D12A - fault codes
https://pdfmanual4trucks.jimdo.com/volvo/
|
|
|
|
|
|
|
Code |
|
Description |
|
Cause and reaction. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Accelerator pedal |
|
Accelerator pedal sensor is defective or damaged wiring between the |
|
11 |
|
|
motor control unit and foot pedal. Incomplete pressing the accelerator |
|
|
|
sensor. |
|
||
|
|
|
|
pedal may have a sharp increase in engine speed. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Idling speed |
|
Accelerator pedal sensor is defective or damaged wiring between the |
|
12 |
|
|
motor control unit and foot pedal. The accelerator pedal is not |
|
|
|
switch pedal. |
|
||
|
|
|
|
responding to pressing. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
13 |
|
Vehicle speed |
|
Damaged wiring, faulty dash, faulty Tachograph. Cruise control does not |
|
|
signal. |
|
work until the fault code is active. |
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Power relay |
|
|
|
14 |
|
engine control |
|
The relay is defective or damaged wiring. |
|
|
|
unit. |
|
|
|
|
|
|
|
|
|
|
|
Internal |
|
|
|
21 |
|
malfunction of the |
|
Defective engine control unit. Cruise control does not work. |
|
|
engine control |
|
||
|
|
|
|
|
|
|
|
|
unit. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
A programming |
|
Not programmed or programmed with a buggy engine control |
|
22 |
|
error in the engine |
|
|
|
|
|
unit. Engine will not start. |
||
|
|
|
control unit. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Coolant |
|
The sensor may be faulty, damaged wiring, water pump works with |
|
23 |
|
temperature |
|
incomplete effectiveness, crammed with honeycomb radiator or |
|
|
|
sensor. |
|
defective thermostat. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
The sensor may be faulty, damaged wiring, clogged honeycomb |
|
|
|
|
|
intercooler (an intercooler), mechanical failure of the engine. At |
|
24 |
|
Charge air |
|
temperatures above 91° air discharge with "Check Engine" lamp will |
|
|
temperature. |
|
light up continuously when the engine power will be reduced. In the |
|
|
|
|
|
||
|
|
|
|
|
event of a fault in the wiring harness or defective sensor "Check Engine" |
|
|
|
|
|
lamp will blink. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Charge air |
|
The sensor may be faulty, damaged wiring, defective, damaged or |
|
25 |
|
|
clogged the turbocharger intercooler cooler, mechanical failure of the |
|
|
|
pressure. |
|
||
|
|
|
|
engine.Reduced engine power increased the toxicity of exhaust gases. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Faulty speed sensor camshaft, damaged wiring, broken synchronization |
|
|
|
Speed sensor |
|
between signals from speed sensor camshaft and crankshaft sensor. In |
|
26 |
|
|
case of violation of synchronization will be active codes 26 and 27 at |
|
|
|
camshaft. |
|
||
|
|
|
|
the same time.Engine runs for a long time or may not start for the first |
|
|
|
|
|
|
|
|
|
|
|
|
time. |
|
|
|
|
|
|
|
|
|
|
|
Faulty speed sensor, crankshaft damaged wiring, broken synchronization |
|
|
|
Speed sensor the |
|
between signals from speed sensor camshaft and crankshaft sensor. In |
|
27 |
|
|
case of violation of synchronization will be active codes 26 and 27 at |
|
|
|
crankshaft. |
|
||
|
|
|
|
the same time.Engine runs for a long time or may not start for the first |
|
|
|
|
|
|
|
|
|
|
|
|
time. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Pump-injector |
|
Defective pump-injector, damaged wiring between the motor and the |
|
31 |
|
|
control unit pump-injector, mechanical failure in the engine. Engine is |
|
|
|
cylinder No. 1. |
|
||
|
|
|
|
not exactly possible increased exhaust gas smokiness. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Pump-injector |
|
Defective pump-injector, damaged wiring between the motor and the |
|
32 |
|
|
control unit pump-injector, mechanical failure in the engine. Engine is |
|
|
|
cylinder No. 2. |
|
||
|
|
|
|
not exactly possible increased exhaust gas smokiness. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
https://pdfmanual4trucks.jimdo.com/volvo/