Viking VBI7360WLPG, VBI7360WRKA, VBI7360WLKA, VBI7360WRFW, VBI7360WLFW Installation Manual

...

0 (0)

Installation

Guide

Integrated Refrigerator / Freezer

7 SERIES

VBI7360 / CVBI7360

FBI7360 / CFBI7360

MVBI7360 / CMVBI7360

MFBI7360 / CMFBI7360

Table of Contents

Warnings and Important Information _______________________________________________________ 3

Professional Bottom-Freezer

Dimensions _______________________________________________________________________ 5

Speci cations ______________________________________________________________________ 6

Cutout Dimensions__________________________________________________________________ 7

Anti-Tip Dimensions (36”) ____________________________________________________________ 9

General Information

Electrical Requirements _____________________________________________________________ 10

Water Requirements ________________________________________________________________ 11

Unpacking & Moving ___________________________________________________________________ 12

Installation

Door/Drawer Panel Adjustments ______________________________________________________ 12

Custom Front Panel Dimensions ______________________________________________________ 13

Custom Front Panel Install ___________________________________________________________ 14

Water Line Installation ______________________________________________________________ 15

Leveling Unit ______________________________________________________________________ 17

Kickplate Installation _______________________________________________________________ 17

Flush Mount Side Trim ______________________________________________________________ 18

Door Stop Adjustment ______________________________________________________________ 19

System Speci cations and Data _______________________________________________________ 21

Performance Checklist __________________________________________________________________ 21

Control Panels _________________________________________________________________________ 21

Service & Registration __________________________________________________________________ 22

IMPORTANT – Please Read and Follow!

• Make sure that incoming voltage is the

same as unit rating. An electric rating

plate specifying voltage, frequency,

wattage, amperage, and phase is

attached to the product.

• To reduce the risk of  re, electrical shock,

or injury to persons, installation work

and electrical wiring must be done by

a quali ed technician in accordance

with all applicable codes and standards,

including  re-rated construction.

• The installer should leave these

instructions with the consumer who

should retain them for local inspector’s

use and for future reference.

For additional information or installation

videos, visit our website at www.

vikingrange.com

DANGER

WARNING

You will be killed or seriously injured if you

don't follow instructions.

You can be killed or seriously injured if you

don't follow instructions.

All safety messages will identify the

hazard, tell you how to reduce the chance

of injury, and tell you what can happen if

the instructions are not followed.

Your safety and the safety of others is very

important.

We have provided many important safety

messages in this manual and on your appliance.

ALWAYS read and obey all safety messages.

This is the safety alert symbol. This

symbol alerts you to hazards that

can kill or hurt you and others.

All safety messages will be preceded by the

safety alert symbol and the word “DANGER” or

“WARNING.” These words mean:

It is your responsibility to:

• comply with installation speci cations and dimensions.

• properly install unit.

• remove any moldings or decorative panels that prevent the unit from being serviced.

• make sure that you have these materials (not provided with your unit), which are necessary

for proper installation:

• 1/4” (6 mm) copper tubing with shuto valve

• 1– Saddle valve (do not use self-piercing feature of the valve)

• assure that  oor will support unit, door panels and contents (approximately

1200 pounds [540 kg]).

• provide a properly grounded electrical outlet.

• assure that location will permit appliance doors to open 90º minimum.

Required tools

• Drill

• Drill bits - 3" Phillips (Ph2), Torx (T15 & T20), 1/4" and 5/16" hex drive

• Rubber mallet

• 3/8" wrench

WARNING

TIP OVER HAZARD

Appliance is top heavy and tips

easily when not completely

installed. Keep doors closed until

appliance is completely installed

and secured per installation instructions.

Use two or more people to move and install

appliance. Failure to do so can result in death or

serious injury.

WARNING

ELECTRICAL SHOCK HAZARD

Disconnect power or turn

power disconnect switch to

OFF position before removing

top grille. Failure to do so can result in death or

electrical shock.

A GFI shall be used if required by NFPA-70 (National Electric Code), federal/state/local laws, or local

ordinances.

• The required use of a GFI is normally related to the location of a receptacle with respect to

any signi cant sources of water or moisture.

• Viking Range, LLC will

NOT warranty any problems resulting from GFI outlets which are not

installed properly or do not meet the requirements below.

If the use of a GFI is required, it should be:

• Of the receptacle type (breaker type or portable type

NOT recommended)

• Used with permanent wiring only (temporary or portable wiring

NOT recommended)

• On a dedicated circuit (no other receptacles, switches or loads in the circuit)

• Connected to a standard breaker of appropriate size (GFI breaker of the same size

NOT

recommended)

• Rated for Class A (5 mA +/- 1 mA trip current) as per UL 943 standard)

• In good condition and free from any loose- tting gaskets (if applicable in outdoor situations)

• Protected from moisture (water, steam, high humidity) as much as reasonably possible

Power On/O Switch

Your unit is shipped with the power switch on. When  rst plugged in, the

display will  ash. Push any button to initiate display.

The power on/o switch is located to the left of the center behind the

access panel. It is used to turn the power o when cleaning or servicing

the refrigerator.

To turn power o , remove the access panel. Press the power on/o switch

to the o position.

To turn power on, press power on/o switch to the on position. Replace

access panel.

access panel

IMPORTANT – Please Read and Follow!

50-1/2”

(128.3 cm)

12-1/8”

(30.8 cm)

17-1/16”

(43.3 cm)

83-15/16”

(213.2 cm)

36”

(91.4 cm)

22-1/2”

(57.2 cm)

4-1/16” (10.3 cm)

Dimensions (Integrated Bottom-Freezer)

Model Dimension A Dimension B*

VBI7360/CVBI7360

27-3/8" (69.5 cm) 24-3/4" (62.9 cm)

FBI7360/CFBI7360

N/A 24" (61.0 cm)

MVBI7360/CMVBI7360

27" (68.5 cm) 24-3/4" (62.9 cm)

*To outside of door panel

Speci cations (Integrated Bottom-Freezer)

36” Integrated Refrigerator/Freezer

Description VBI7360 / CVBI7360 MVBI7360 / CMVBI7360

Overall width 36" (91.4 cm)

Overall height (from bottom) 83-15/16" (213.2 cm) min to 84-3/4" (215.7 cm) max

Overall depth from rear To front edge kickplate: 22-1/2” (57.2 cm)

To front of door panel: 24-3/4” (62.9 cm)

To front of handle endcap:

27-3/8" (69.5 cm)

To front of handle endcap:

27" (68.5 cm)

Cutout width 36" (91.4 cm)

Cutout height 84" (213.4 cm) min to 85-3/16" (216.3 cm) max

Cutout depth 25” (63.5 cm) min.

Electrical requirements 115 volt, 60 Hz, 15 amp dedicated circuit; 3-wire cord with

grounded 3-prong plug attached to product

Maximum amp usage 9.9 amps

Inlet water requirements 1/4” copper tubing inlet waterline; minimum 20 psi;

maximum 120 psi

Overall interior dimensions

Refrigerator

Freezer

Total capacity

13.6 cu. ft. (385.8 liters)

6.35 cu. ft. (180.1 liters)

19.95 cu. ft. (565.9 liters)

Approximate shipping weight 565 lbs. (254.3 kg)

36” Integrated Refrigerator/Freezer w/Custom Panels

Description FBI7360 / CFBI7360

Overall width 36" (91.4 cm)

Overall height (from bottom) 83-15/16" (213.2 cm) min to 84-3/4" (215.7 cm) max

Overall depth from rear To front edge kickplate: 22-1/2” (57.2 cm)

To front of door panel: 24” (61.0 cm)

Cutout width 36" (91.4 cm)

Cutout height 84" (213.4 cm) min to 85-3/16" (216.3 cm) max

Cutout depth 25” (63.5 cm) min.

Electrical requirements 115 volt, 60 Hz, 15 amp dedicated circuit; 3-wire cord with

grounded 3-prong plug attached to product

Maximum amp usage 9.9 amps

Inlet water requirements 1/4” copper tubing inlet waterline; minimum 20 psi;

maximum 120 psi

Overall interior dimensions

Refrigerator

Freezer

Total capacity

13.6 cu. ft. (385.8 liters)

6.35 cu. ft. (180.1 liters)

19.95 cu. ft. (565.9 liters)

Approximate shipping weight 565 lbs. (254.3 kg)

Cutout Dimensions (Bottom-Freezer)

Can be located on either side

84”

(213.4 cm) min.

opening height

85-3/16”

(216.3cm) max.

opening height

36”

(91.5 cm)

25”

(63.5 cm)

Electric Outlet Location

Water Line Entry Area

3”

(7.6 cm)

6”

(15.2 cm)

5/8”

(1.6 cm)

36”

(91.5 cm)

1/2”

(1.3 cm)

15-1/2”

(39.4 cm)

4-1/4”

(10.8 cm)

leveling

dimension

*Note: For all models, 3” back from the

front of the cabinet on both sides needs to

 nished like the outside of the cabinets

Tipping Radius

37-1/4"

(94.6 cm)

39-5/16"

(99.8 cm)

90

105

9-1/2"

(24.1 cm)

127-3/16" (323.1 cm)

36" (94.4 cm)

83-15/16"

(213.2 cm)

91-7/16"

(232.3 cm)

83-15/16"

(213.2 cm)

87-3/4"

(222.9 cm)

111-3/16" (323.1 cm)

24-5/8"

(62.5 cm)

17-1/4"

(43.8 cm)

+ 16 hidden pages