Uniflame GBC850WNG-C, Gbc850wng-c Owner's Manual

Loading...

OWNER’S MANUAL

Outdoor Natural Gas Barbecue Grill

Model No. GBC850WNG-C

WARNING

FOR YOUR SAFETY:

For Outdoor Use Only

(outside any enclosure)

WARNING

FOR YOUR SAFETY:

1.Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage.

2.Read the installation, operation, and maintenance instructions thoroughly before installing or servicing this equipment.

3.Fuel system must be installed by a qualified and licensed personnel. Improper installations present hazards, which can lead to personal injury or property damage. Please contact your local Natural Gas supplier for these services.

4.Failure to follow these instructions could result in fire or explosion, which could cause property damage, personal injury, or death.

Save these instructions for future reference.

If you are assembling this unit for someone else, give this manual to him or her to read and save for future reference.

Made from 70% Bagasse

(Environmentally Friendly Sugar

Cane Pulp By-product)

Table of Contents

Important Safeguards . . . . . . . . . . . . . . . . . . . . .

Page 2

Exploded View & Hardware . . . . . . . . . . . . . . . . . . .

. .

3

Assembly Instructions . . . . . . . . . . . . . . . . . . . . .

. .

4

Connecting to Natural Gas Line . . . . . . . . . . . . . . . . . .

.

. 9

Operating Instructions . . . . . . . . . . . . . . . . . . . . .

. .

9

Checking for Leaks . . . . . . . . . . . . . . . . . . . . .

. .

9

Operating Main Burners . . . . . . . . . . . . . . . . . . . .

.

10

Operating Side Burner . . . . . . . . . . . . . . . . . . . . . . 10

Cleaning and Care . . . . . . . . . . . . . . . . . . . . . . .

.

10

Product Registration . . . . . . . . . . . . . . . . . . . . . .

.

11

Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . 11

Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . .

.

12

The use and installation of this product must conform to local codes. In absence of local codes, use the National Fuel Gas Code, ANSI Z223.1/NFPA 54, CAN/CGA-B149.1, Natural Gas and Propane Installation Code.

Prior to installation, contact your municipality for local building codes and your local fire department for installation verification.

Manufactured in China for: Blue Rhino Global Sourcing, Inc Winston-Salem, NC USA

1.800.762.1142, www.bluerhino.com

© 2007 Blue Rhino Global Sourcing, Inc. All Rights Reserved

 

UniFlame® is a Registered Trademark of Blue Rhino Global Sourcing, Inc.. All Rights Reserved.

GBC850WNG-C-OM-102 EF

Outdoor Natural Gas Barbecue Grill Model No. GBC850WNG-C

DANGER

If you smell gas -

1.Shut off gas to appliance.

2.Extinguish any open flame.

3.Open lid.

4.If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department.

WARNING

FOR YOUR SAFETY

Do not store or use gasoline or other flammable liquids or vapors in the vincinity of this or any other appliance.

DANGER: Failure to follow the dangers, warning and cautions in this manual may result in serious bodily injury or death, or in a fire or an explosion causing damage to property.

WARNING:

This grill is for outdoor use only, and shall not be used in a building, garage, or any other enclosed area.

Do NOT operate, light or use this appliance within 8 feet of walls, structures or buildings.

This grill is NOT for commercial use.

This grill is for use with Natural Gas (NG) gas only. The conversion to or attempted use of liquid propane gas (LP) in this NG gas grill is dangerous and will void your warranty.

Installation and repairs should be done by a qualified service person. NG Characteristics:

a.NG is flammable and hazardous if handled improperly. Become aware of the characteristics before using any NG product.

b.NG is explosive under pressure, heavier than air, and settles and pools in low areas.

c.NG in its natural state has no odor. For your safety, an odorant is added that smells like rotten cabbage.

d.Contact with NG can cause freeze burns to skin.

e.A fire causing, serious injury or damage to property may occur if the above is not followed exactly.

Never attempt to attach this grill to the NG system of a camper trailer, or motor home.

The use of alcohol, or prescription or non-prescription drugs may impair the consumer’s ability to properly assemble or safely operate the appliance.

Never use LP gas, charcoal, lighter fluid, lava rocks, gasoline, kerosene, or alcohol with this product.

Your grill has been checked at all factory connections for leaks. Recheck all connections, as movement in shipping can loosen connections.

Check for leaks even if your unit was assembled for you by someone else.

Do not operate if gas leak is present. Gas leaks may cause a fire or explosion.

You must follow all leak-checking procedures before operating. To prevent fire or explosion hazard when testing for a leak:

a.Always perform leak test before lighting the grill and each time the grill is connected for use.

b.No smoking. Do not use or permit sources of ignition in the area while conducting a leak test.

c.Conduct the leak test outdoors in a well-ventilated area.

d.Do not use matches, lighters, or a flame to check for leaks.

e.Do not use grill until any and all leaks are corrected.

If you are unable to stop a leak, turn off the main valve on the NG supply line. Call a gas appliance serviceman or your local NG supplier.

The appliance and its individual shutoff valve must be disconnected from the gas supply piping system during any pressure testing of that system at a pressures in excess of 1/2 psig (3.5 kpa).

The appliance must be isolated from the gas supply piping system by closing its individual manual shutoff valve during any pressure testing of the gas supply piping system at test pressures equal to or less than 1/2 psig (3.5 kpa).

Always perform a leak test on gas connections whenever this grill is serviced. Never use a flame to test for leaks. Do not smoke while performing leak check.

Do not store or use gasoline or other flammable liquids or vapors within 25 feet (7.62 m) of this appliance.

Do not use in an explosive atmosphere. Keep grill area clear and free from combustible materials, gasoline and other flammable vapors and liquids.

Minimum clearance from sides and back of unit to combustible construction, 21 inches from side and 21 inches from back. Do not use this appliance under overhead combustible surfaces.

It is essential to keep the grill’s valve compartment, burners, and circulating air passages clean. Inspect grill before each use.

Do NOT alter grill in any manner.

Do not use the grill unless it is COMPLETELY assembled and all parts are securely fastened and tightened.

This grill should be thoroughly cleaned and inspected on a regular basis. Clean and inspect the hose before each use of the appliance. If there is evidence of abrasion, wear, cuts, or leaks, the hose must be replaced prior to the appliance being put into operation.

Use only the regulator and hose assembly provided. The replacement regulator and hose assembly shall be that specified by the manufacturer.

Use only Blue Rhino Global Sourcing, Inc factory authorized parts. The use of any part that is not factory authorized can be dangerous. This will also void your warranty.

Do not use this appliance without reading “Operating Instructions” in this manual.

Do not touch metal parts of grill until it has completely cooled (about 45 min.) to avoid burns, unless you are wearing protective gear (pot holders, gloves, BBQ mittens, etc.).

When cooking, fire extinguishing materials shall be readily accessible. In the event of an oil grease fire, do not attempt to extinguish with water. Use type BC dry chemical fire extinguisher or smother with dirt, sand or baking soda.

Do not install or use in or on boats or recreational vehicles.

Do not use grill in high winds.

Never lean over the grill when lighting.

Do not leave a lit grill unattended, especially keep children and pets away from grill at all times.

Do not attempt to move grill when in use. Allow the grill to cool before moving or storing.

Always open grill lid carefully and slowly as heat and steam trapped within grill can severely burn you.

Always place your grill on a hard non-combustible, level surface. An asphalt or blacktop surface may not be acceptable for this purpose.

Move gas hoses as far away as possible from hot surfaces and dripping hot grease.

Keep all electrical cords away from a hot grill.

Do not use grill for indoor cooking or heating. TOXIC fumes can accumulate and cause asphyxiation.

After a period of storage and/or nonuse, check for leaks, burner obstructions and inspect for any abrasion, wear, cuts to the hose.

Failure to open lid while igniting the grill’s burners, or not waiting 5 minutes to allow the gas to clear if the grill does not light, may result in an explosive flame-up.

If grill is not in use, the gas must be turned off at the main supply line.

Never operate grill without heat plates installed.

Always use a meat thermometer to ensure food is cooked to a safe temperature.

This grill is designed with to operate at an inlet pressure of 7 inches water column.

Please use protective gloves when assembling this product.

Do not force parts together as this can result in personal injury or damage to the product.

Never cover entire cooking area with aluminum foil.

Deaths, serious injury or damage to property may occur if the above is not followed exactly.

page no.

Contact 1.800.762.1142 for assistance. Do not return to place of purchase.

Parts List

1

Lid Handle Assembly

55-08-196

 

 

 

2

Thermometer Gauge

55-08-164

 

 

 

3

Lid

55-08-195

 

 

 

4

Warming Rack

55-08-166

 

 

 

5

Heat Plate (4)

55-08-168

 

 

 

6

Cooking Grid (2)

55-08-167

 

 

 

7

Side Burner Grid

55-07-479

 

 

 

8

Grill Body

55-08-165

 

 

 

9

Tool Holder Rod

55-07-485

 

 

 

10

Tool Holder Hooks

55-07-729

 

 

 

11

Left Side Shelf

55-08-169

 

 

 

12

Main Burner (4)

55-08-170

 

 

 

13

Side Burner

55-08-171

 

 

 

14

Right Side Shelf

55-08-172

 

 

 

15

Igniter Button

55-07-448

 

 

 

16

Control Knob (5)

55-08-173

 

 

 

17

Control Knob Bezel

55-08-174

 

 

 

18

Hose Assembly

55-08-177

 

 

 

19

Igniter Assembly

55-08-111

 

 

 

20

Left Side Shelf Panel

55-08-175

 

 

 

21

Grease Tray

55-08-176

 

 

 

22

Right Side Shelf Panel

55-08-178

 

 

 

23

Front Frame Support

55-08-179

 

 

 

24

Grease Cup

55-08-182

 

 

 

25

Cart Assembly

55-08-211

 

 

 

26

Grease Cup Support

55-08-182

 

 

 

27

Left Door

55-07-451

 

 

 

28

Door Handle (2)

55-08-185

 

 

 

29

Right Door

55-07-470

 

 

 

30

Condiment Basket

55-08-186

 

 

 

31

Lighting Rod

55-07-459

 

 

 

32

Bottom Wire Rack

55-08-214

 

 

 

33

Wheel (4)

55-07-491

Exploded View

1

3

 

 

4

 

6

6

 

 

9

 

12

 

 

11

15

10

20

19

21

 

 

 

23

25

28 27

30

32

33

2

5

7

8

13

14

18

22

 

24

 

16

17

26

 

29

31

28

33

Hardware

 

 

Tools Required for Assembly (Included)

A

Screw

M4x8 Nickel Plated Phillips Truss Head

4 pcs

#2 Phillips Head Screwdriver

 

B

 

 

 

Screw

M5x10 Nickel Plated Phillips Truss Head

10 pcs

 

C

Screw

M6x20 Nickel Plated Phillips Truss Head

7 pcs

 

D

Screw

M6x65 Nickel Plated Phillips Truss Head

2 pcs

M6 Wrench

 

 

 

E

Bolt

 

8 pcs

M6x16 Nickel Plated Hex Head

 

 

 

 

 

F

AA Battery

 

1 pc

 

Outdoor Natural Gas Barbecue Grill Model No. GBC850WNG-C

Assembly Instructions

1

DO NOT RETURN PRODUCT TO STORE.

2

Install Wheels

For assistance call 1.800.762.1142 toll free. Please have

 

your owner’s manual and serial number available for

 

reference.

Note: The serial number can be found on the back of the cart assembly.

For Easiest Assembly:

To avoid losing any small components or hardware, assemble your product on a hard level surface that does not have cracks or openings.

Clear an area large enough to layout all components and hardware.

When applicable, tighten all hardware connections by hand first. Once the step is completed go back and fully tighten all hardware.

Follow all steps in order to properly assemble your product.

To complete assembly you will need:

(1) Leak Detection Solution (Instructions on how to make solution are included in the “Operating Instructions” section of this manual)

Note: You must follow all steps to properly assemble the grill.

Typical assembly: approximately 1 (one) hour.

 

 

 

3 Attach Front Frame Support

4 Attach Doors and Condiment Basket

D

x 2

page no.

Contact 1.800.762.1142 for assistance. Do not return to place of purchase.

 

 

 

 

 

 

 

 

 

 

 

 

5

Attach Grill Body

6

Attach Bolt

 

Note: Leave 0.3” (8 mm) of bolt threads exposed. Do not fully tighen until step 12.

C

x 4

E

x 4

 

 

 

7 Install Grease Tray

8 Attach Tool Holder

C

x 2

Outdoor Natural Gas Barbecue Grill Model No. GBC850WNG-C

Assembly Instructions (continued)

 

 

 

9 Attach Left Side Shelf Panel

10 Attach Right Side Shelf Panel

B

x 4

B

x 4

 

 

 

11 Attach Side Shelves

12 Secure Left Side Shelf

B

x 1

E

x 2

 

 

 

Uniflame GBC850WNG-C, Gbc850wng-c Owner's Manual

page no.

Contact 1.800.762.1142 for assistance. Do not return to place of purchase.

 

 

 

 

 

 

 

 

 

 

 

13 Secure Right Side Shelf

14 Secure Left Side Shelf Assembly 2

B

x 1

E

x 2

C

x 1

 

 

 

 

Attach Regulator/Hose Assembly, Control Knob Support

16

Secure Side Burner and Attach Igniter Wire

15 and Control Knob

 

A

x 2

A

x 2

Outdoor Natural Gas Barbecue Grill Model No. GBC850WNG-C

Assembly Instructions (continued)

 

 

 

 

 

17

Insert Side Burner Grid

18

Insert Heat Plates

 

 

 

 

 

 

 

 

 

 

19

Insert Cooking Grid and Warming Rack

20

Attach Grease Cup and Grease Cup Support

 

 

 

 

 

+ 16 hidden pages