Uniflame GBC750W, Gbc750w Owner's Manual

Loading...

OWNER’S MANUAL

Outdoor LP Gas Barbecue Grill

Model No. GBC750W

WARNING

FOR YOUR SAFETY:

For Outdoor Use Only

(outside any enclosure)

WARNING

FOR YOUR SAFETY:

1.Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage.

2.Read the installation, operation, and maintenance instructions thoroughly before installing or servicing this equipment.

3.Failure to follow these instructions could result in fire or explosion, which could cause property damage, personal injury, or death.

California Proposition 65:

Chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm are created by the combustion of propane.

Save these instructions for future reference.

If you are assembling this unit for someone else, give this manual to him or her to read and save for future reference.

Table of Contents

Important Safeguards . . . . . . . . . . . . . . . . . . . . .

Page 2

Exploded View & Hardware . . . . . . . . . . . . . . . . . . .

.

.

3

Assembly Instructions . . . . . . . . . . . . . . . . . . . . .

.

.

4

Installling LP Gas Tank . . . . . . . . . . . . . . . . . . . . .

.

.

10

Insert LP Gas Tank . . . . . . . . . . . . . . . . . . . . . .

.

 

10

Secure LP Gas Tank . . . . . . . . . . . . . . . . . . . . .

.

.

10

Connect LP Gas Tank . . . . . . . . . . . . . . . . . . . . .

.

 

10

Operating Instructions . . . . . . . . . . . . . . . . . . . . .

.

.

10

Checking for Leaks . . . . . . . . . . . . . . . . . . . . . . . 10

Operating Main Burners . . . . . . . . . . . . . . . . . . . . .

10

Operating Side Burner . . . . . . . . . . . . . . . . . . . . . . 11

Cleaning and Care . . . . . . . . . . . . . . . . . . . . . . . .

11

Product Registration . . . . . . . . . . . . . . . . . . . . . . .

12

Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . 12

Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . .

13

The use and installation of this product must conform to local codes. In absence of local codes, use the National Fuel Gas Code, ANSI Z223.1/NFPA 54, CAN/CGA-B149.1, Natural Gas and Propane Installation Code.

Manufactured in China for: Blue Rhino Global Sourcing, LLC Winston-Salem, NC USA

1.800.762.1142, www.bluerhino.com

© 2006 Blue Rhino Global Sourcing, LLC. All Rights Reserved

 

UniFlame® is a Registered Trademark of Blue Rhino Global Sourcing, LLC.. All Rights Reserved.

GBC750W-OM-108 ES

Outdoor LP Gas Barbecue Grill Model No. GBC750W

DANGER

If you smell gas -

1.Shut off gas to appliance.

2.Extinguish any open flame.

3.Open lid.

4.If odor continues, keep away from the appliance immediately call your gas supplier or your fire department.

WARNING

FOR YOUR SAFETY

1.Do not store or use gasoline or other flammable liquids or vapors in the vincinity of this or any other appliance.

2.An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.

Safety First

DANGERS and Cautions

1.This grill is for outdoor use only, and shall not be used in a building, garage, or any other enclosed area.

2.Do NOT operate, light or use this appliance within 8 feet of walls, structures or buildings.

3.This grill is NOT for commercial use.

4.This grill is for use with liquid propane (LP) gas only. The conversion to or attempted use of natural gas in this LP gas grill is dangerous and will void your warranty.

5.LP gas Characteristics:

a.LP gas is flammable and hazardous if handled improperly. Become aware of the characteristics before using any LP gas product.

b.LP gas is explosive under pressure, heavier than air, and settles and pools in low areas.

c.LP gas in its natural state has no odor. For your safety, an odorant is added that smells like rotten cabbage.

d.Contact with LP gas can cause freeze burns to skin.

6.LP gas tank needed to operate. Only tanks marked “propane” may be used.

a.The LP gas supply tank must be constructed and marked in accordance with the Specifications for LP gas Cylinders of the U.S. Department of Transportation (DOT) or the National Standard of Canada, CAN/CSA-B339, Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods; and Commission.

b.LP gas tank must be arranged for vapor withdrawal.

c.The LP gas tank must have a listed overfilling prevention device (OPD).

d.Only use 20-pound cylinders equipped with a cylinder connection device compatible with the connection for outdoor cooking appliances.

e.The LP gas tank must have a tank collar to protect the tank valve.

f.Never use an LP gas tank with a damaged body, valve, collar, or footing.

g.Dented or rusted LP gas tanks may be hazardous and should be checked by your LP gas supplier prior to use.

h.The LP gas tank should not be dropped or handled roughly.

i.Tanks must be stored outdoors out of the reach of children and must not be stored in a building, garage, or any other enclosed area. Your tank must never be stored where temperatures can reach over 125°F.

j.Never keep a filled LP gas tank in a hot car or car trunk. Heat will cause the gas pressure to increase, which may open the relief valve and allow gas to escape.

k.Place dust cap on cylinder valve outlet whenever the cylinder is not in use. Only install the type of dust cap on the cylinder valve outlet that is provided with the cylinder valve. Other types of caps or plugs may result in leakage of propane.

l.Do not store a spare LP gas tank under or near this appliance.

m.Never fill the tank beyond 80 percent full.

n.A fire causing, serious injury or damage to property may occur if the above is not followed exactly.

7.Never attempt to attach this grill to the self-contained LP gas system of a camper trailer, motor home, or house.

8.The use of alcohol, or prescription or non-prescription drugs may impair the consumer’s ability to properly assemble or safely operate the appliance.

9.Never use charcoal, lighter fluid, lava rocks, gasoline, kerosene, or alcohol with this product.

10.Your grill has been checked at all factory connections for leaks. Recheck all connections, as movement in shipping can loosen connections.

11.Check for leaks even if your unit was assembled for you by someone else.

12.Do not operate if gas leak is present. Gas leaks may cause a fire or explosion.

13.You must follow all leak-checking procedures before operating. To prevent fire or explosion hazard when testing for a leak:

a.Always perform leak test before lighting the grill and each time the tank is connected for use.

b.No smoking. Do not use or permit sources of ignition in the area while conducting a leak test.

c.Conduct the leak test outdoors in a well-ventilated area.

d.Do not use matches, lighters, or a flame to check for leaks.

e.Do not use grill until any and all leaks are corrected.

If you are unable to stop a leak, disconnect the LP gas supply. Call a gas appliance serviceman or your local LP gas supplier.

14.Do not store or use gasoline or other flammable liquids or vapors within 25 feet (7.62 m) of this appliance.

15.Do not use in an explosive atmosphere. Keep grill area clear and free from combustible materials, gasoline and other flammable vapors and liquids.

16.Minimum clearance from sides and back of unit to combustible construction, 21 inches from side and 21 inches from back. Do not use this appliance under overhead combustible surfaces.

17.It is essential to keep the grill’s valve compartment, burners, and circulating air passages clean. Inspect grill before each use.

18.Do not alter grill in any manner.

19.Do not use the grill unless it is COMPLETELY assembled and all parts are securely fastened and tightened.

20.This grill should be thoroughly cleaned and inspected on a regular basis. Clean and inspect the hose before each use of the appliance. If there is evidence of abrasion, wear, cuts, or leaks, the hose must be replaced prior to the appliance being put into operation.

21.Use only the regulator and hose assembly provided. The replacement regulator and hose assembly shall be that specified by the manufacturer.

22.Use only Blue Rhino Global Sourcing, LLC. factory authorized parts. The use of any part that is not factory authorized can be dangerous. This will also void your warranty.

23.Do not use this appliance without reading “Operating Instructions” in this manual.

24.Do not touch metal parts of grill until it has completely cooled (about 45 min.) to avoid burns, unless you are wearing protective gear (pot holders, gloves, BBQ mittens, etc.).

25.When cooking, fire extinguishing materials shall be readily accessible. In the event of an oil grease fire, do not attempt to extinguish with water. Use type BC dry chemical fire extinguisher or smother with dirt, sand or baking soda.

26.Do not install or use in or on boats or recreational vehicles.

27.Do not use grill in high winds.

28.Never lean over the grill when lighting.

29.Do not leave a lit grill unattended, especially keep children and pets away from grill at all times.

30.Do not attempt to move grill when in use. Allow the grill to cool before moving or storing.

31.Storage of grill indoors is permissible only if the tank is disconnected, removed from the grill and properly stored outdoors.

32.Always open grill lid carefully and slowly as heat and steam trapped within grill can severely burn you.

33.Do not attempt to disconnect the gas regulator from the tank or any gas fitting while the grill is in use.

34.Always place your grill on a hard non-combustible, level surface. An asphalt or blacktop surface may not be acceptable for this purpose.

35.Move gas hoses as far away as possible from hot surfaces and dripping hot grease.

36.Keep all electrical cords away from a hot grill.

37.Do not use grill for indoor cooking or heating. TOXIC fumes can accumulate and cause asphyxiation.

38.After a period of storage and/or nonuse, check for leaks, burner obstructions and inspect for any abrasion, wear, cuts to the hose.

39.Failure to open lid while igniting the grill’s burners, or not waiting 5 minutes to allow the gas to clear if the grill does not light, may result in an explosive flame-up.

40.If grill is not in use, the gas must be turned off at the supply tank.

41.Never operate grill without heat plates installed.

42.Always use a meat thermometer to ensure food is cooked to a safe temperature.

43.Please use protective gloves when assembling this product.

44.Do not force parts together as this can result in personal injury or damage to the product.

45.Deaths, serious injury or damage to property may occur if the above is not followed exactly.

page no.

Contact 1.800.762.1142 for assistance. Do not return to place of purchase.

Parts List

1Warming Rack

2Cooking Grid (2)

3Temperature Gauge

4Lid

5Heat Plate (4)

6Grease Tray

7Tool Holder

8Left SIde Shelf

9Grill Body

10Right Side Shelf

11Left Side Shelf Panel

12Side Burner

13Right Side Shelf Panel

14Ignitor Button

15Grease Cup Support

16Grease Cup

17Regulator/Hose Assembly

18Control Knob Support

19Control Knob

20QCC Clip

21Cart Assembly

22LP Gas Tank Shield

23Front Frame Support

24Tank Retainer Wire

25Lighting Hook

26Tank Guard

27Bottom Shelf

28Left Door

29Right Door

30Wheel Assembly (4)

31Condiment Basket

32Hose Clip

Exploded View

 

 

 

 

 

 

 

 

 

1

 

 

 

4

3

 

 

 

2

 

 

 

 

 

 

 

 

 

2

 

 

 

 

 

 

 

 

 

 

6

 

 

 

 

5

5

5

5

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

7

8

 

9

 

 

 

 

 

 

 

 

 

 

 

 

 

10

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

11

 

 

 

 

13

 

 

12

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

14

 

15

20

17

 

18

 

 

 

 

 

16

 

 

 

 

 

 

 

21

 

 

19

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

22

 

 

 

 

 

 

 

 

 

23

 

32

 

 

 

 

 

 

26

24

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

27

28

 

30

29

30

 

 

25

31

 

Hardware

A

Screw

M4x8 Nickel Plated Phillips Truss Head

5 pcs

 

 

 

 

 

 

 

B

Screw

M5x10 Nickel Plated Phillips Truss Head

9 pcs

 

 

 

 

 

 

 

C

Screw

M6x15 Nickel Plated Phillips Truss Head

7 pcs

 

 

 

 

 

 

 

D

Screw

M6x20 Nickel Plated Phillips Truss Head

4 pcs

 

 

 

 

 

 

 

E

Screw

M6x65 Nickel Plated Phillips Truss Head

2 pcs

 

 

 

 

 

 

 

F

Bolt

M6x20 Nickel Plated Hex Head

8 pcs

 

 

 

 

 

 

 

G

Nut

M6 Zinc Plated

1 pc

 

 

 

 

 

 

 

H

Washer

ø4.3 Nickel Plated

1 pc

 

 

 

 

 

 

 

I

Washer

ø5.2 Nickel Plated

1 pc

 

 

 

 

 

 

 

J

Washer

ø6.4 Nickel Plated

8 pcs

 

 

 

 

 

 

 

K

Lock Washer

ø6.5 Nickel Plated

8 pcs

 

 

 

 

 

 

 

L

AA Battery

 

1 pc

Tools Required for Assembly (Included)

#2 Phillips Head Screwdriver

M6 Wrench

Assembly Instructions

DO NOT RETURN PRODUCT TO STORE.

For assistance call 1.800.762.1142 toll free. Please have your owner’s manual and serial number available for reference.

1 Install Casters

5 Attach LP Gas Tank Shield

A

x 4

Outdoor LP Gas Barbecue Grill Model No. GBC750W

For Easiest Assembly:

To avoid losing any small components or hardware, assemble your product on a hard level surface that does not have cracks or openings.

2 Attach Front Frame Support

E

 

x 2

 

K

x 2

J

x 2

 

6 Attach Grill Body

D

x 4

 

K

J

x 4

x 4

 

Uniflame GBC750W, Gbc750w Owner's Manual

page no.

Contact 1.800.762.1142 for assistance. Do not return to place of purchase.

Clear an area large enough to layout all components and hardware.

When applicable, tighten all hardware connections by hand first. Once the step is completed, go back and fully tighten all hardware.

• Follow all steps in order to properly assemble your product.

 

 

 

3 Attach Tank Guard

 

4 Attach Doors and Condiment Basket

C

x 2

G

x 1

 

 

 

7

Attach Bolt

8

Attach QCC Clip

Note: Leave 0.3” (8 mm) of bolt threads exposed. Do not fully tighen until step 9.

 

F

x 4

C

x 1

 

 

Outdoor LP Gas Barbecue Grill Model No. GBC750W

Assembly Instructions (continued)

 

 

 

9 Install Grease Tray

10 Attach Tool Holder

C

J

x 2

K

x 2

x 2

 

 

 

13 Assemble Right Side Shelf

14 Attach Side Shelves

B

x 3

page no.

Contact 1.800.762.1142 for assistance. Do not return to place of purchase.

 

 

 

 

 

 

 

 

 

 

11 Attach Left Side Shelf Panel

12 Assemble Right Side Shelf Panel

 

A

x 1

 

B

x1

 

 

 

 

 

B

H

 

x 1

I

x 1

 

 

 

 

x 3

 

 

 

 

 

 

 

15 Secure Left Side Shelf Assembly

16 Secure Right Side Shelf Assembly

B

x 1

F

x 2

B

x 1

F

x 2

 

 

 

 

 

Outdoor LP Gas Barbecue Grill Model No. GBC750W

Assembly Instructions (continued)

 

 

 

17 Attach Hose Clip

18 Secure Left Side Shelf Assembly 2

C

x 1

C

x 1

 

 

 

 

 

21

Insert Cooking Grid and Warming Rack

22

Attach Grease Cup and Grease Cup Support

 

 

 

 

 

 

 

 

 

 

page no.

Contact 1.800.762.1142 for assistance. Do not return to place of purchase.

 

 

 

 

 

 

 

 

 

 

 

 

19

Attach Side Burner Ignitor Wire

20

Insert Heat Plates

 

 

 

 

 

 

23 Insert Battery

L

 

 

x 1

 

 

 

 

 

 

 

 

+ 19 hidden pages