Uniflame BC1912G, Bc1912g Owner's Manual

Loading...
Uniflame BC1912G, Bc1912g Owner's Manual

WARNING

Improper installation, adjustment, alteration, service or maintenance can cause injury or property damage. Read the installation, operation and

maintenance instructions thoroughly before installing or servicing this equipment.

Failure to follow these instructions could result in fire or explosion, which could cause property damage, personal injury, or death.

DANGER!

DO NOT use gas grill for indoor cooking or heating. TOXIC fumes can accumulate and cause asphyxiation. NOT to be used in or on boats or recreational vehicles.

WARNING

Chemicals known to the state of California to cause cancer, birth defects, or other reproductive harm are created by the combustion of propane.

By UniFlame

Model BC1912G

Deluxe Portable LP

Gas grill

SAVE THESE

INSTRUCTIONS FOR

FUTURE REFERENCE. IF

YOU ARE ASSEMBLING

THIS UNIT FOR SOMEONE

ELSE, GIVE THIS MANUAL

TO HIM OR HER TO SAVE

FOR FUTURE REFERENCE.

NOTE: The use and installation of this product must conform to local codes. In absence of local codes, use the National Fuel and Gas Code, ANSI Z223.1, Storage and Handling of Liquefied Petroleum Gasses, NFPA / ANSI 58 of CAN/CGA-B149.1, Natural Gas Installation Code of CAN/CGA-B149.2, Propane Installation Code.

Owner’s Manual,

Model BC1912G Portable Gas Grill

Dear Valued Customer,

Congratulations on your new barbecue Grill: You’ve made the right choice! In this manual, you will find assembly instructions, suggestions for grilling, and helpful hints, as well as guidelines for the safe operation, and proper care of, and use of your grill. Our expert staff strives to provide you with an easy to assemble product. However, in the unlikely event that a part is missing or defective, please call our customer satisfaction department seven days a week at (800) 762-1142 from 8 a.m. to 5 p.m. central standard time. You also can fax your request to (847) 731-6032. When faxing, please include your name, address, model number, part needed, name of the store and where you purchased your grill. We then will ship your request as soon as possible. We appreciate and encourage customer feedback. Please contact us if you have any suggestions or comments regarding this product.

Best Regards,

UniFlame Corporation

Customer Satisfaction Department

BC1912G owner’s manual

1

Owner’s Manual,

Model BC1912G Portable Gas Grill

IMPORTANT NOTICE: READ ALL INSTRUCTIONS PRIOR TO ASSEMBLY AND USE!

WARNING

FOR YOUR SAFETY

If you smell gas:

. Shut off gas to the appliance.

. Extinguish any open flame.

. Open Lid.

. If odor continues, immediately call your gas supplier or fire department.

WARNING

FOR YOUR SAFETY

. DO NOT store or use gasoline or other lammable vapors and iquids in the vicinity of his or any other ppliance.

. When cooking with oil/grease, do not allow he oil/grease to exceed 50° F (177°C). Do not tore or use extra ooking oil in the icinity of this or any other appliance.

. An LP Cylinder not onnected for use shall NOT be stored in the icinity of this or any other appliance.

Safety First!

Read and understand all warnings and precautions prior to operating your grill.

DANGER

To prevent fire or explosion hazard when testing for a leak:

1.Always perform “leak test” before lighting the grill, each time the cylinder is connected for use.

2.No smoking. Do not use or permit sources of ignition in the area while conducting a leak test.

3.Conduct the leak test outdoors in a wellventilated area.

4.Do not use matches, lighters, or a flame to check for leaks.

5.Do not use grill until any and all leaks are corrected. If you are unable to stop a leak, disconnect the propane supply. Call a gas appliance serviceman or your local propane gas supplier.

WARNING

1.This grill is for outside use only, and shall not be used in a building, garage, or any other enclosed area.

2.This grill is for use with propane gas only (propane gas cylinder not included).

3.Never attempt to attach this grill to the self-contained propane system of a camper trailer, motor home, or house.

4.Never use charcoal or lighter fluid.

5.The use of alcohol, or prescription or non-prescription drugs may impair the consumer's ability to properly assemble or safely operate the appliance.

6.Do not use gasoline, kerosene, or alcohol for lighting! The LP-gas supply cylinder must be constructed and marked in accordance with the specifications for LP-gas cylinders of the U.S. Department of Transportation (DOT) CFR 49 or the National Standard of Canada, CAN/CSA-B339, Cylinders, Spheres and Tubes for the Transportation of Dangerous Goods.

7.Always open grill lid carefully and slowly as heat and steam trapped within grill can severely burn you.

8.Always place your grill on a hard, level surface far away from combustibles. An asphalt or blacktop surface may not be acceptable for this purpose.

9.Do not attempt to move the grill while it is lit.

10 Do not leave a lit grill unattended, especially keep children and pets away from grill at all times.

11.This is not a tabletop grill. Therefore, do not place this grill on any type of tabletop surface.

12.Do not use grill in high winds.

BC1912G owner’s manual

2

Warning

. Do not store spare LP cylinder within 10 eet (3m) of this ppliance

. Do not store or use gasoline or other lammable liquids or apors within 25 feet 8m) of this appliance

. When cooking with oil/grease, do not allow he oil/grease to exceed 50°

F (177°C).

. Do not leave oil/grease unattended

Owner’s Manual,

Model BC1912G Portable Gas Grill

13Do not use the grill unless it is COMPLETELY assembled and all parts are securely fastened and tightened.

14Keep all combustible items and surfaces at least 12 inches (30 cm) away from the grill at all times. DO NOT use this gas grill or any gas product under any overhead or near any unprotected combustible constructions.

CAUTION

1.To prevent liquid propane from entering the regulator valve and causing a possible safety hazard, make sure that during installation and use, the propane cylinder is lower than the regulator valve / regulator.

2.Do not touch metal parts of grill until it has completely cooled (about 45 min.) to avoid burns, unless you are wearing protective gear (potholders, gloves, BBQ mittens, etc.).

3.Do not use in an explosive atmosphere. Keep grill area clear and free from combustible materials, gasoline and other flammable vapors and liquids.

4.Do not alter grill in any manner

CAUTION: Liquid propane (LP) gas is flammable and hazardous if handled improperly. Become aware of the characteristics before using any LP product.

LP Characteristics: Flammable, explosive under pressure, heavier than air, and settles and pools in low areas.

In its natural state propane has no odor. for your safety, an odorant is added that smells like rotten cabbage.

Contact with LP can cause freeze burns to skin.

This grill is shipped from the factory for LP gas use Only.

Never use an LP cylinder with a damaged body.

Dented or rusted LP cylinders may be hazardous and should be checked by your LP gas supplier

CAUTION: It is essential to keep the grill’s valve compartment, burners, and circulating air passages clean. Inspect grill before each use.

GENERAL INFORMATION:

1.PROPANE GAS CYLINDER NEEDED TO OPERATE:

2.This Gas Grill is NOT for commercial use!

BC1912G owner’s manual

3

Owner’s Manual,

Model BC1912G Portable Gas Grill

Illustrated parts list

1.Lid & Base-----------------------------

1set 2.Cooking Grid ----------------------------

1pc

3. Heat Plate ----------------------------

1pc

4.Burner-------------------------------------

 

1pc

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

5.Gas Regulator Valve

-----------------1pc 6.Handle -----------------------------------

3sets

7.Warming Grid (Pre-assembly)

-----1pc

Hardware: (Some hardware already assembled to parts above)

A. Long Bolts For Handles ----------

6pcs B. Short Bolt For Burner------------------

1pc

C. Lock Washers For Handles ------

7pcs D. Flat washers------------------------------

7pcs

E. Phillips screwdriver ---------------

1pc

 

BC1912G owner’s manual

4

+ 9 hidden pages