Loading...
Toshiba Personal Computer
Satellite L650
(PSK1x)
Maintenance Manual
TOSHIBA CORPORATION
S/ No
Satellite/Satellite Pro/L650/L655 Maintenance Manual
Copyright
© 2010 by Toshiba Corporation. All rights reserved. Under the copyright laws, this manual cannot be reproduced in any form without the prior written permission of Toshiba. No patent liability is assumed with respect to the use of the information contained herein.
Toshiba Satellite/Satellite Pro/L650/L655 Maintenance Manual
First Edition April 2010
Disclaimer
The information presented in this manual has been reviewed and validated for accuracy. The included set of instructions and descriptions are accurate for the Toshiba Satellite/Satellite Pro/L650/L655 at the time of this manual's production. However, succeeding computers and manuals are subject to change without notice. Therefore, Toshiba assumes no liability for damages incurred directly or indirectly from errors, omissions, or discrepancies between any succeeding product and this manual.
Trademarks
Intel and Pentium are registered trademarks of Intel Corporation.
IBM, IBM PC/XT, PC/AT, PS/2 and OS/2 are registered trademarks of IBM Corporation. Windows Vista home edition are registered trademarks of Microsoft Corporation.
Sound Blaster and Pro are trademarks of Creative Technology Ltd. UNIX is a registered trademark of X/Open Company Ltd. NetWare are registered trademarks of Novell, Inc.
All other properties are trademarks or registered trademarks of their respective holders.
ii |
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
Preface
This maintenance manual describes how to perform hardware service maintenance for the Toshiba Personal Computer Satellite/Satellite Pro/L650/L655, referred to as Satellite/Satellite Pro/L650/L655 in this manual.
The procedures described in this manual are intended to help service technicians isolate faulty Field Replaceable Units (FRUs) and replace them in the field.
SAFETY PRECAUTIONS
Four types of messages are used in this manual to bring important information to your attention. Each of these messages will be italicized and identified as shown below.
DANGER: “Danger” indicates the existence of a hazard that could result in death or serious bodily injury, if the safety instruction is not observed.
WARNING: “Warning” indicates the existence of a hazard that could result in bodily injury, if the safety instruction is not observed.
CAUTION: “Caution” indicates the existence of a hazard that could result in property damage, if the safety instruction is not observed.
NOTE: “Note” contains general information that relates to your safe maintenance service.
Improper repair of the computer may result in safety hazards. Toshiba requires service technicians and authorized dealers or service providers to ensure the following safety precautions are adhered to strictly.
Be sure to fasten screws securely with the right screwdriver. If a screw is not fully fastened, it could come loose, creating a danger of a short circuit, which could cause overheating, smoke or fire.
If you replace the battery pack, RTC battery or backup battery, be sure to use only the same model battery or an equivalent battery recommended by Toshiba. Installation of the wrong battery can cause the battery to explode.
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
iii |
The manual is divided into the following parts:
Chapter 1 Hardware Overview describes the Satellite / Satellite Pro / L650 / L655 system unit and each FRU.
Chapter 2 Troubleshooting Procedures explains how to diagnose and resolve FRU problems.
Chapter 3 Test and Diagnostics describes how to perform test and diagnostic operations for maintenance service.
Chapter 4 Replacement Procedures describes the removal and replacement of the FRUs.
Appendices The appendices describe the following:
Handling the LCD module
Board layout
Keyboard scan/character codes
Key layout
iv |
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
Conventions
This manual uses the following formats to describe, identify, and highlight terms and operating procedures.
Acronyms
On the first appearance and whenever necessary for clarification acronyms are enclosed in parentheses following their definition. For example:
Read Only Memory (ROM)
Keys
Keys are used in the text to describe many operations. The key top symbol as it appears on the keyboard is printed in boldface type.
Key operation
Some operations require you to simultaneously use two or more keys. We identify such operations by the key top symbols separated by a plus (+) sign. For example, Ctrl + Pause (Break) means you must hold down Ctrl and at the same time press Pause (Break). If three keys are used, hold down the first two and at the same time press the third.
User input
Text that you are instructed to type in is shown in the boldface type below:
DISKCOPY A: B:
The display
Text generated by the XXXXX that appears on its display is presented in the type face below:
Format complete
System transferred
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
v |
Table of Contents
Chapter 1 |
Hardware Overview |
|
|
1.1 |
Features................................................................................................................................ |
|
5 |
1.2 |
System Unit Components .................................................................................................. |
12 |
|
1.3 |
2.5-inch HDD..................................................................................................................... |
17 |
|
1.4 |
DVD Super Multi (+-R Double Layer).............................................................................. |
18 |
|
1.5 |
Blu-Ray Writer................................................................................................................... |
19 |
|
1.6 |
Power Supply..................................................................................................................... |
20 |
|
1.7 |
Batteries ............................................................................................................................. |
|
21 |
|
1.7.1 |
Main Battery.................................................................................................. |
21 |
|
1.7.2 |
Battery Charging Control.............................................................................. |
21 |
|
1.7.3 |
RTC Battery .................................................................................................. |
22 |
Chapter 2 |
Troubleshooting |
|
|
2.1 |
Outline............................................................... |
Fehler! Textmarke nicht definiert. |
|
2.2 |
Basic Flowchart................................................. |
Fehler! Textmarke nicht definiert. |
|
2.3 |
Power Supply .................................................... |
Fehler! Textmarke nicht definiert. |
|
|
Procedure 1 Power Icon Check...................... |
Fehler! Textmarke nicht definiert. |
|
|
Procedure 2 Connection Check...................... |
Fehler! Textmarke nicht definiert. |
|
|
Procedure 3 Replacement Check ................... |
Fehler! Textmarke nicht definiert. |
|
2.4 |
System Board .................................................... |
Fehler! Textmarke nicht definiert. |
|
|
Procedure 1 Message Check .......................... |
Fehler! Textmarke nicht definiert. |
|
|
Procedure 2 Test Program Check .................. |
Fehler! Textmarke nicht definiert. |
|
|
Procedure 3 Replacement Check ................... |
Fehler! Textmarke nicht definiert. |
|
2.5 |
HDD .................................................................. |
|
Fehler! Textmarke nicht definiert. |
|
Procedure 1 Message Check .......................... |
Fehler! Textmarke nicht definiert. |
|
|
Procedure 2 Partition Check .......................... |
Fehler! Textmarke nicht definiert. |
|
|
Procedure 3 Format Check............................. |
Fehler! Textmarke nicht definiert. |
|
|
|
|
|
vi |
|
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
|
|
Procedure 4 Test Program Check .................. |
Fehler! Textmarke nicht definiert. |
|
Procedure 5 Connector Check and Replacement Check Fehler! Textmarke nicht |
|
|
definiert. |
|
2.6 |
SSD.................................................................... |
Fehler! Textmarke nicht definiert. |
|
Procedure 1 Test Program Check .................. |
Fehler! Textmarke nicht definiert. |
|
Procedure 2 Connector Check and Replacement Check Fehler! Textmarke nicht |
|
|
definiert. |
|
2.7 |
Keyboard ........................................................... |
Fehler! Textmarke nicht definiert. |
|
Procedure 1 Test Program Check .................. |
Fehler! Textmarke nicht definiert. |
|
Procedure 2 Connector Check and Replacement Check Fehler! Textmarke nicht |
|
|
definiert. |
|
2.8 |
Display .............................................................. |
Fehler! Textmarke nicht definiert. |
|
Procedure 1 External Monitor Check ............ |
Fehler! Textmarke nicht definiert. |
|
Procedure 2 Test Program Check .................. |
Fehler! Textmarke nicht definiert. |
|
Procedure 3 Connector Check and Replacement Check Fehler! Textmarke nicht |
|
|
definiert. |
|
2.9 |
ODD (Optical Disk Drive) ................................ |
Fehler! Textmarke nicht definiert. |
|
Procedure 1 ODD Cleaning Check ................ |
Fehler! Textmarke nicht definiert. |
|
Procedure 2 Test Program Check .................. |
Fehler! Textmarke nicht definiert. |
|
Procedure 3 Connector Check and Replacement Check Fehler! Textmarke nicht |
|
|
definiert. |
|
2.10 |
LAN................................................................... |
Fehler! Textmarke nicht definiert. |
|
Procedure 1 Test Program Check .................. |
Fehler! Textmarke nicht definiert. |
|
Procedure 2 Connector Check and Replacement Check Fehler! Textmarke nicht |
|
|
definiert. |
|
2.11 |
Audio Test ......................................................... |
Fehler! Textmarke nicht definiert. |
|
Procedure 1 Test Program Check .................. |
Fehler! Textmarke nicht definiert. |
|
Procedure 2 Connector Check and Replacement Check Fehler! Textmarke nicht |
|
|
definiert. |
|
2.12 |
Cooling Module................................................. |
Fehler! Textmarke nicht definiert. |
|
Procedure 1 Test Program Check .................. |
Fehler! Textmarke nicht definiert. |
|
Procedure 2 Connector Check and Replacement Check Fehler! Textmarke nicht |
|
|
definiert. |
|
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
vii |
Chapter 3 |
Diagnostic Programs |
|
|
|
3.1 |
General |
.............................................................. |
Fehler! Textmarke nicht definiert. |
|
3.2 |
Quick Start......................................................... |
Fehler! Textmarke nicht definiert. |
||
|
3.2.1 ....................................... |
Quick Test |
Fehler! Textmarke nicht definiert. |
|
|
3.2.2 .......................... |
Customization Test |
Fehler! Textmarke nicht definiert. |
|
|
3.2.3 ...................... |
Keyboard Layout test |
Fehler! Textmarke nicht definiert. |
|
|
3.2.4 ............................... |
Audio Play Test |
Fehler! Textmarke nicht definiert. |
|
|
3.2.5 .......................... |
Audio Record Test |
Fehler! Textmarke nicht definiert. |
|
|
3.2.6 ........................................ |
DMI Read |
Fehler! Textmarke nicht definiert. |
|
|
3.2.7 ....................................... |
DMI Write |
Fehler! Textmarke nicht definiert. |
|
|
3.2.8 ......................... |
System Information |
Fehler! Textmarke nicht definiert. |
|
|
3.2.9 ....................................... |
View Logs |
Fehler! Textmarke nicht definiert. |
|
|
3.2.10 ............................ |
Exit to Free DOS |
Fehler! Textmarke nicht definiert. |
|
|
3.2.11 |
The Diagnostics Screen Explanation............... |
Fehler! Textmarke nicht |
|
|
|
definiert. |
|
|
3.3 |
Options .............................................................. |
|
Fehler! Textmarke nicht definiert. |
|
|
3.3.1 ......................................... |
Overview |
Fehler! Textmarke nicht definiert. |
|
3.3.2Batch Parameters Configuration .....Fehler! Textmarke nicht definiert.
3.3.3Item’s Parameters Configuration ....Fehler! Textmarke nicht definiert.
|
3.3.4 |
Load Batch Parameters .................... |
Fehler! Textmarke nicht definiert. |
|
3.3.5 |
Save Batch Parameters .................... |
Fehler! Textmarke nicht definiert. |
|
3.3.6 |
LOG Parameters Setting .................. |
Fehler! Textmarke nicht definiert. |
|
3.3.7 |
Specify LOG Viewer ....................... |
Fehler! Textmarke nicht definiert. |
|
3.3.8 |
Display LOG File ............................ |
Fehler! Textmarke nicht definiert. |
|
3.3.9 |
LOG Viewer .................................... |
Fehler! Textmarke nicht definiert. |
|
3.3.10 |
LOG File Sample ............................ |
Fehler! Textmarke nicht definiert. |
3.4 |
Subtests |
.............................................................. |
Fehler! Textmarke nicht definiert. |
3.5 |
System Test ....................................................... |
Fehler! Textmarke nicht definiert. |
|
3.6 |
Memory .....................................................Test |
Fehler! Textmarke nicht definiert. |
|
3.7 |
Storage............................................................... |
|
Fehler! Textmarke nicht definiert. |
3.8 |
Video ................................................................. |
|
Fehler! Textmarke nicht definiert. |
viii |
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
3.9 |
Communication (COMM)................................. |
Fehler! Textmarke nicht definiert. |
|
3.10 |
Peripheral .......................................................... |
Fehler! Textmarke nicht definiert. |
|
3.11 |
Error Codes and description.............................. |
Fehler! Textmarke nicht definiert. |
|
3.12 |
Quick Test Item List...................................... |
61Fehler! Textmarke nicht definiert. |
|
Chapter 4 |
Replacement Procedures |
|
|
4.1 |
General |
.............................................................. |
Fehler! Textmarke nicht definiert. |
|
Safety ...........................................Precautions |
Fehler! Textmarke nicht definiert. |
|
|
Before ...........................................You Begin |
Fehler! Textmarke nicht definiert. |
|
|
Disassembly .................................Procedures |
Fehler! Textmarke nicht definiert. |
|
|
Assembly ......................................Procedures |
Fehler! Textmarke nicht definiert. |
|
|
Tools and ......................................Equipment |
Fehler! Textmarke nicht definiert. |
|
|
Screw ...............................Tightening Torque |
Fehler! Textmarke nicht definiert. |
|
|
Colors ..................................of Screw Shanks |
Fehler! Textmarke nicht definiert. |
|
|
Symbols ....of Screws on the Computer Body |
Fehler! Textmarke nicht definiert. |
|
|
Symbol ............................................examples |
Fehler! Textmarke nicht definiert. |
|
4.2 |
Battery ..............................Pack/ Bridge Media |
Fehler! Textmarke nicht definiert. |
|
|
4.2.1 .................................... |
Battery Pack |
Fehler! Textmarke nicht definiert. |
|
Removing ............................the Battery Pack |
Fehler! Textmarke nicht definiert. |
|
|
Installing ..............................the Battery Pack |
Fehler! Textmarke nicht definiert. |
|
|
4.2.2 ................................... |
Bridge Media |
Fehler! Textmarke nicht definiert. |
|
Removing ...........................the Bridge Media |
Fehler! Textmarke nicht definiert. |
|
|
Installing ............................the Bridge Media |
Fehler! Textmarke nicht definiert. |
|
4.3 |
Memory ................................................Module |
Fehler! Textmarke nicht definiert. |
|
|
Removing ......................the Memory Module |
Fehler! Textmarke nicht definiert. |
|
|
Installing .......................the Memory Module |
Fehler! Textmarke nicht definiert. |
|
4.4 |
MDC Module .................................................... |
Fehler! Textmarke nicht definiert. |
|
|
Removing ..........................the MDC Module |
Fehler! Textmarke nicht definiert. |
|
|
Installing ............................the MDC Module |
Fehler! Textmarke nicht definiert. |
|
4.5 |
HDD .................................................................. |
|
Fehler! Textmarke nicht definiert. |
|
Removing ........................................the HDD |
Fehler! Textmarke nicht definiert. |
|
|
|
||
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
ix |
||
|
Installing the HDD.......................................... |
Fehler! Textmarke nicht definiert. |
|
4.6 |
ODD Bay Module ............................................. |
Fehler! Textmarke nicht definiert. |
|
|
Removing the ODD Bay Module ................... |
Fehler! Textmarke nicht definiert. |
|
|
Installing the ODD Bay Module..................... |
Fehler! Textmarke nicht definiert. |
|
|
Disassembling the ODD Drive ....................... |
Fehler! Textmarke nicht definiert. |
|
|
Assembling the ODD Drive............................ |
Fehler! Textmarke nicht definiert. |
|
4.7 |
Keyboard ........................................................... |
|
Fehler! Textmarke nicht definiert. |
|
Removing Keyboard ....................................... |
Fehler! Textmarke nicht definiert. |
|
|
Installing the Keyboard................................... |
Fehler! Textmarke nicht definiert. |
|
4.8 |
Wireless LAN Card........................................... |
Fehler! Textmarke nicht definiert. |
|
|
Removing the Wireless LAN Card ................. |
Fehler! Textmarke nicht definiert. |
|
|
Installing the Wireless LAN Card .................. |
Fehler! Textmarke nicht definiert. |
|
4.9 |
Top Cover.......................................................... |
|
Fehler! Textmarke nicht definiert. |
|
Removing the Top Cover................................ |
Fehler! Textmarke nicht definiert. |
|
|
Installing the Top Cover ................................. |
Fehler! Textmarke nicht definiert. |
|
4.10 |
Bluetooth module .............................................. |
Fehler! Textmarke nicht definiert. |
|
|
Removing the Bluetooth module .................... |
Fehler! Textmarke nicht definiert. |
|
|
Installing the Bluetooth Module ..................... |
Fehler! Textmarke nicht definiert. |
|
4.11 |
Display Assembly ............................................. |
Fehler! Textmarke nicht definiert. |
|
|
Removing the Display Assembly.................... |
Fehler! Textmarke nicht definiert. |
|
|
Installing the Display Assembly ..................... |
Fehler! Textmarke nicht definiert. |
|
4.12 |
System Board .................................................... |
Fehler! Textmarke nicht definiert. |
|
|
Removing the System Board .......................... |
Fehler! Textmarke nicht definiert. |
|
|
Installing the System Board............................ |
Fehler! Textmarke nicht definiert. |
|
4.13 |
CPU Cooling Module and Fan .......................... |
Fehler! Textmarke nicht definiert. |
|
|
4.13.1 |
For non-VGA model ....................... |
Fehler! Textmarke nicht definiert. |
|
Remove the CPU cooling module and Fan..... |
Fehler! Textmarke nicht definiert. |
|
|
Installing the CPU Cooling Module and Fan.. |
Fehler! Textmarke nicht definiert. |
|
|
4.13.2 |
For VGA model............................... |
Fehler! Textmarke nicht definiert. |
|
Remove the CPU cooling module and Fan..... |
Fehler! Textmarke nicht definiert. |
|
|
Installing the CPU Cooling Module and Fan.. |
Fehler! Textmarke nicht definiert. |
|
4.14 |
CPU ................................................................... |
|
Fehler! Textmarke nicht definiert. |
|
|
|
|
x |
|
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
|
|
Removing the CPU ......................................... |
Fehler! Textmarke nicht definiert. |
|
|
Installing the CPU........................................... |
Fehler! Textmarke nicht definiert. |
|
4.15 |
Display Mask..................................................... |
Fehler! Textmarke nicht definiert. |
|
|
Removing the Display Mask........................... |
Fehler! Textmarke nicht definiert. |
|
|
Installing the Display Mask ............................ |
Fehler! Textmarke nicht definiert. |
|
4.16 |
FL Inverter Board.............................................. |
Fehler! Textmarke nicht definiert. |
|
|
Removing the FL Inverter Board.................... |
Fehler! Textmarke nicht definiert. |
|
|
Installing the FL Inverter Board ..................... |
Fehler! Textmarke nicht definiert. |
|
4.17 |
LCD Module and CCD Board........................... |
Fehler! Textmarke nicht definiert. |
|
|
Removing the LCD Module and CCD Board.Fehler! Textmarke nicht definiert. |
||
|
Installing the LCD Module and CCD Board .. |
Fehler! Textmarke nicht definiert. |
|
4.18 |
Card Reader Board and MDC cable.................. |
Fehler! Textmarke nicht definiert. |
|
|
Removing the Card Reader Board and MDC cable........ |
Fehler! Textmarke nicht |
|
|
definiert. |
|
|
|
Installing the Card Reader Board and MDC cable ......... |
Fehler! Textmarke nicht |
|
|
definiert. |
|
|
4.19 |
Speakers ............................................................ |
Fehler! Textmarke nicht definiert. |
|
|
Removing the Speakers................................... |
Fehler! Textmarke nicht definiert. |
|
|
Installing the Speakers .................................... |
Fehler! Textmarke nicht definiert. |
|
4.20 |
Power Board and Switch Board ........................ |
Fehler! Textmarke nicht definiert. |
|
|
Removing the Power Board and Switch Board .............. |
Fehler! Textmarke nicht |
|
|
definiert. |
|
|
|
Installing the Power Board and Switch Board Fehler! Textmarke nicht definiert. |
||
4.21 |
Button Board ..................................................... |
Fehler! Textmarke nicht definiert. |
|
|
Removing the Button Board ........................... |
Fehler! Textmarke nicht definiert. |
|
|
Installing the Button Board............................. |
Fehler! Textmarke nicht definiert. |
|
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
xi |
Appendices |
|
|
Appendix A Handling the LCD Module ........................................................................... |
A-1 |
|
Appendix B |
Board Layout ................................................................................................. |
B-1 |
Appendix C |
Keyboard Scan/Character Codes ................................................................... |
C-1 |
Appendix D |
Key Layout.................................................................................................... |
D-1 |
xii |
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
Chapter 1
Hardware Overview
1 Hardware Overview
ii |
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
1 Hardware Overview
Chapter 1 |
Contents |
|
|
1.1 |
Features ............................................................................................................................... |
|
5 |
1.2 |
System Unit Components ................................................................................................. |
12 |
|
1.3 |
2.5-inch HDD.................................................................................................................... |
|
17 |
1.4 |
DVD Super Multi (+-R Double Layer)............................................................................. |
18 |
|
1.5 |
Blu-Ray Writer.................................................................................................................. |
|
19 |
1.6 |
Power Supply .................................................................................................................... |
|
20 |
1.7 |
Batteries ............................................................................................................................ |
|
21 |
|
1.7.1 |
Main Battery.......................................................................................... |
21 |
|
1.7.2 |
Battery Charging Control ...................................................................... |
21 |
|
1.7.3 |
RTC Battery .......................................................................................... |
22 |
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
iii |
1 Hardware Overview
Figures |
|
|
Figure 1-1 ID Parts Description Placement |
...............................................................................9 |
|
Figure 1-2 Computer Block Diagram...................................................................................... |
10 |
|
Figure 1-3 System Board Configurations................................................................................ |
11 |
|
Figure 1-4 |
System Unit Block Diagram.................................................................................. |
12 |
Figure 1-5 SATA HDD ........................................................................................................... |
17 |
|
Figure 1-6 |
DVD Super Multi Drive ........................................................................................ |
18 |
Figure 1-7 |
Blu-Ray Writer Drive ............................................................................................ |
19 |
Tables |
|
|
Table 1-1 HDD Specifications ................................................................................................ |
17 |
|
Table 1-2 DVD Super Multi Drive Specifications .................................................................. |
18 |
|
Table 1-3 |
Blu-Ray Writer Drive Specifications...................................................................... |
19 |
Table 1-4 |
Battery Specifications ............................................................................................. |
21 |
Table 1-5 |
Quick/Normal Charging Time ................................................................................ |
22 |
iv |
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
1.1 Features |
1 Hardware Overview |
1.1 Features
Toshiba Satellite L650/L655/Satellite Pro L650 is a full size notebook PC based on the mobile Intel Arrandale Processor, providing high-speed processing capabilities and advanced features. The computer employs a Lithium Ion battery that allows it to be battery-operated for a longer period of time. The display uses 15.6-inch WXGA HD LCD panel, at a resolution of 1366x768. The Micro-PGA Socket supports BTO/CTO for the CPU so that the system can be designed to suit your needs.
The computer has the following features:
Processor
CPU is mobile Intel Arrandale Processor:
Intel Core i5 CPU (1066MHz FSB)
Core i5-430M(2.26G, Turbo Boost to 2.53G) Hz
Core i5-520M(2.40G, Turbo Boost to 2.93G) Hz
Intel Core i3 CPU (1066MHz FSB)
Core i3-330M(2.13G) Hz
Core i3-350M(2.26G) Hz
Host Bridge System Controller
System Controller: Intel 5 Series Chipset HM55.
Graphics
Intel integrated graphics or AMD Madison, M92XTX, ParkXT discrete graphics.
Memory
The computer has two SO-DIMM slots, which come standard with DDR3-1066MHz (PC3-8500) memory module. DDR3 is driven at 1.5V. It accepts BTO/CTO for your memory requirements. It can incorporate up to 8.0GB of main memory.
Using the following sizes of memory modules: y 1024 MB (128M×64) / DDR3-1066MHz
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
5 |
1 Hardware Overview |
1.1 Features |
y2048 MB (256M×64) / DDR3-1066MHz
y4096 MB (512M×64) / DDR3-1066MHz
Hard Disk Drive (HDD)
The computer accommodates 2.5-inch 9.5mm height Serial ATA HDD with following storage capacities:
y250 GB (9.5mm thick) SATA (5,400rpm)
y320 GB (9.5mm thick) SATA (5,400rpm)
y500 GB (9.5mm thick) SATA (5,400rpm)
y640 GB (9.5mm thick) SATA (5,400rpm)
ODD
The computer accommodates a fixed 12.7mm ODD with one of following types:
yTray Type DVD Super Multi +-R Double Layer drive
yTray Type DVD Super Multi +-R Double Layer with Label Flash™ drive
yTray Type Blue-Ray Combo BD-ROM with Label Flash™ drive
yTray Type Blue-Ray Writer BD-RE with Label Flash™ drive
Display
LCD displays come in the following types at resolution 1366x768:
y15.6” WXGA HD 1366x768 CSV 1-Lamp display
y15.6” WXGA HD 1366x768 CSV LED display
y15.6” WXGA HD 1366x768 Non-CSV LED display
Internal Modem (BTO)
The computer contains a MDC, enabling data and fax communication. It supports ITU- T V.90 (for rest countries) / V.92 (America, Canada, UK, Germany & France). The transfer rates are 56Kbps for data reception, 33.6Kbps for data transmission and 14,400bps for fax transmission. Note, however, that the actual speed depends on the line quality. The RJ11 modem jack is used to accommodate a telephone line.
6 |
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
1.1 Features |
1 Hardware Overview |
On-Board LAN (BTO)
The internal LAN supports 10/100Mbit or 1Gbit Ethernet, enabling connection to a LAN at up to 1Gbps. It supports Wake-up on LAN from S3/S4/S5 and PXE boot support. This internal LAN has RJ45 jack to directly accommodate a LAN cable.
Wireless LAN (BTO)
The internal Mini Card slot supports IEEE802.11agn (MOW) / IEEE802.11agn (JPN) / IEEE802.11bg (WW) / IEEE802.11bgn (WW) cards. The Antenna has two or three wires dual band antenna support for BTO.
Sound System
CONEXANT CX20671 integrated audio controller supports multimedia. The sound system contains the following:
yStereo speakers
yHeadphone jack
yInternal microphone
yExternal microphone jack
Keyboard (BTO)
30 kinds’ countries keyboard, which is TOSHIBA 2010 New A4 with numeric keypad flat one.
Toshiba Touch Pad
Normal Wide Touch Pad with ON / OFF mechanical button.
Bluetooth (BTO)
Bluetooth wireless technology eliminates the need for cables between electronic device such as desktop computer, printer and mobile phone.
eSATA / USB Combo Port
This product has one eSATA / USB Combo port, which allows device connection through either eSATA or USB signals of eSATA / USB Combo Port.
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
7 |
1 Hardware Overview |
1.1 Features |
USB Port
The computer has two USB 2.0 ports. It is supported to daisy-chain a maximum of 127 USB devices. The serial data transfer rate is 480Mbps, 12Mbps and 1.5Mbps. These ports support PnP installation and hot plugging.
RGB External Monitor Port
A 15-pin external monitor port is provided, through which the computer automatically recognizes an external VESA DDC 2B compatible monitor.
HDMI Out Port (BTO)
A HDMI monitor can be connected to HDMI Out Port on the computer.
Bridge Media Slot
This slot is for your memory card requirements like SD, Mini-SD, Micro-SD, SDHC, SDXC, MMC, Memory Stick and Memory Stick Pro Cards to provide memory card read on your computer.
Webcam (BTO)
The computer has an internal camera. It supports VGA (640x480) without Macro module, which also equips with Internal MIC.
Battery (BTO)
The computer has a removable 3/6/12 Cell Lithium Ion battery pack and an internal RTC battery (rechargeable).
8 |
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
1.1 Features |
1 Hardware Overview |
Figures 1-1/1-2/1-3 and 1-4 show the computer and its system unit configuration, respectively.
Figure 1-1 ID Parts Description Placement
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
9 |
1 Hardware Overview |
1.1 Features |
Figure 1-2 Computer Block Diagram
10 |
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
1.1 Features |
1 Hardware Overview |
Figure 1-3 System Board Configurations
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
11 |
1 Hardware Overview |
1B1.2 System Unit Components |
1.2 System Unit Components
Figure 1-4 is Block Diagram of the System Unit.
Figure 1-4 System Unit Block Diagram
12 |
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
1.2 System Unit Components |
1 Hardware Overview |
The system unit of the computer consists of the following components:
Processor: Mobile Intel Arrandale Processor.
yIntel Core i5 Processor (FSB, 1066MHz)
−Core Speed: 2.26/2.40 GHz
−System Bus: 1066 MHz
−On-Die Level 2 Cache: 3 MB
yIntel Core i3 Processor (FSB, 1066MHz)
−Core Speed: 2.13/2.26 GHz
−System Bus: 1066 MHz
−On-Die Level 2 Cache: 3 MB
Memory: Two expansion memory slots are provided. They can hold 1.0/2.0/4.0GB memory modules available as options to grow up to 8.0GB.
yPC3-8500 (1066MHz) DDR3 SDRAM supported
y1024/2048/4096MB modules supported
−1024 MB (128M x 64)
−2048 MB (256M x 64)
−4096 MB (512M x 64)
yDDR3 1.5 volt operation
yNo parity bit
y64-bit data transfer
BIOS ROM (Flash EEPROM)
y32Mb x 1 chip (4096KB flash parts)
−NvStorage Size : 64K
−NvStorage Free Space : 63K
−FV00 Size : 992K
−FV00 Free Space : 161K
−FV01 Size : 384K
−FV01 Free Space : 73K
System Controller
yMobile Intel 5 Series Chipset HM55 PCH
−Direct Media Interface (DMI)
−PCI Express Interface
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
13 |
1 Hardware Overview |
1B1.2 System Unit Components |
−Integrated Serial ATA (SATA) Host Controller
−Intel High Definition Audio Controller
−Simple Serial Transport (SST) 1.0 Bus
−Platform Environmental Control Interface (PECI)
−Universal Serial Bus (USB) Controller
−Integrated Gigabit LAN Controller
−Intel Active Management Technology with System Defense
−Intel I/O Virtualization (VT-d) Support
−Intel Trusted Execution Technology Support
−Power Management Logic
−External Glue Integration
−Enhanced DMA Controller
−System Management Bus
−High Precision Event Timers
−Timers Based on 82C54
−Real-Time Clock
−System TCO Reduction Circuits
−Serial Peripheral Interface (SPI) Support
−Interrupt Controller
−Firmware Hub Interface Support
−Low Pin Count (LPC) I/F
−GPIO
−Analog and Digit Display Ports
−JTAG Boundary Scan Support
Bridge Media Controller
y REA_RTS5159
− Memory Card Reader Controller
Audio Controller
CONEXANT CX20671 integrated audio controller supports multimedia. The sound system features contain the following:
y4 Stereo DACs support 16-bit to 24-bit PCM format for stereo audio playback
y6 stereo ADCs support 16-bit to 24-bit PCM format for stereo independent sound inputs
yAll ADCs support 44.1K to 192.0K Hz sample rate
yDigital microphone interface with internal MIC boost supporting
yJack sense detects up to 4 jacks using only one sense pin
yDigital Mixer
y+3.3V analog and I/O operation; uses Vaux for power management modes
14 |
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
1.2 System Unit Components |
1 Hardware Overview |
yAudio Director for Headphone and Internal Speakers Redirection
ySmart Audio GUI - advanced audio control
KBC/EC (Keyboard Controller/Embedded Controller)
A KBC WINBOND NPCE781LA0DX chip is used to serve as KBC/EC and Super IO: y KBC
−Scan controller function
−Interface controller function
y EC
−Power supply sequence control
−Overheat shutdown support
−LED control
−Beep control
−Device ON/OFF
−Cooling fan speed control
−Universal I/O port
−Battery capacity check
−Flash memory reprogramming function
−EC access interface
−I2C communication control
Battery EEPROM
y24C02 equivalent (128 words x 16 bits, I2C interface) integrated in battery pack
−Storing records of battery use
Clock Generator
yICS ICS9LPRS3197
−Generating the clock signal required for the system
Modem Controller
Built-in MDC card with Askey, Foxconn or Lite-On. Functions of modem controller:
yDigital signal conductor protection
yRing wake-up support
yAzalia interface
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
15 |
1 Hardware Overview |
1B1.2 System Unit Components |
yCommunication codes supported:
−For data communication:
V.90 (China)/V.92, data rates: 28kbps/56kbps
V.34 extended rates: 33.6K/2400/V.32 turbo, V.32 bits and fallbacks − For fax:
V.17, V.27, V.29, V.34 and V.21 Channel 2 V.253 Class 1 fax
LAN Controller
yAtheros AR8152 / AR8151 - 10/100Mbit / 1Gbit
−IEEE802.3 10BASE-T/100BASE-TX physical layer interface
−IEEE 802.3u Auto-Negotiation support
−Digital Adaptive Equalization control
−10BASE-T auto-polarity correction
−LAN Connect interface
−Automatic detection of “unplugged mode”
−Remote boot (PXE 2.1)
−Smart power down when link is not detected
Wireless LAN Controller
ySupport following 3 kinds of mini PCI wireless LAN cards
−IEEE 802.11bg
−IEEE 802.11ag
−IEEE 802.11agn
yData Rate
−IEEE 802.11bg: Standard 54M bps
−IEEE 802.11ag: Standard 54M bps
−IEEE 802.11agn: Standard 130M bps
yFrequency Channel
−IEEE802.11bg: 2.4GHz
−IEEE802.11ag: 2.4GHz / 5.4GHz
−IEEE802.11agn: 2.4GHz / 5.4GHz
16 |
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
2B1.3 2.5-inch HDD |
1 Hardware Overview |
1.3 2.5-inch HDD
The computer contains an extremely low-profile, lightweight and high-performance HDD. The HDD incorporates 9.5 mm height magnetic disk and mini-Winchester type magnetic heads. The HDD interface conforms to Serial ATA. Storage capacities supported are 250, 320, 500 & 640GB.
The HDD is shown in Figure 1-5 and some of its specifications are listed in Table 1-1.
Figure 1-5 SATA HDD
Table 1-1 HDD Specifications
Item |
|
Specifications |
|
|
|
|
|
Capacity (GB) |
250 GB |
320 GB |
500 GB |
|
|
|
|
Rotational Speed (RPM) |
5400 rpm |
5400 rpm |
5400 rpm |
|
|
|
|
Height |
9.5 mm |
9.5 mm |
9.5 mm |
|
|
|
|
User Data Sectors |
488,397,168 |
625,142,448 |
976,773,168 |
|
|
|
|
Bytes / Sector |
512 |
512 |
512 |
|
|
|
|
Item |
|
Specifications |
|
|
|
|
|
|
|
Capacity (GB) |
640 GB |
- |
- |
|
|
|
|
|
|
Rotational Speed (RPM) |
5400 rpm |
- |
- |
|
|
|
|
|
|
Height |
9.5 mm |
- |
- |
|
|
|
|
|
|
User Data Sectors |
1,250,263,728 |
- |
- |
|
|
|
|
|
|
Bytes / Sector |
512 |
- |
- |
|
|
|
|
|
|
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
17 |
1 Hardware Overview |
3B1.4 DVD Super Multi (+-R Double Layer) |
1.4 DVD Super Multi (+-R Double Layer)
The DVD Super Multi drive accepts 12-cm (4.72-inch) and 8-cm (3.15-inch) discs. At maximum, the drive can play back DVD-ROM at 8x speed, read CD-ROM at 24x speed, and write CD-R at 24x speed, CD-RW at 4x speed, US CD-RW at 24x speed, High Speed CDRW at 10x speed, DVD-R at 8x speed, DVD-RW at 6x speed, DVD-R DL at 6x speed, DVD+R at 8x speed, DVD+RW at 8x speed, DVD+R DL at 6x speed and DVD-RAM at 5x speed.
DVD Super Multi Drive is shown in Figure 1-6 and its specifications are listed in Table 1-2.
Figure 1-6 DVD Super Multi Drive
Table 1-2 DVD Super Multi Drive Specifications
Item |
DVD-ROM mode |
|
CD-ROM mode |
|
|
|
|
Data Transfer Rate |
33.3 (U-DMA transfer mode 2) |
|
|
(Mbytes/s) |
16.7 (PIO mode 4, Multiword DMA mode 2) |
|
|
|
|
||
Access Time (ms) |
|
|
|
Average Random |
130 ms |
|
130 ms |
Access |
|
||
|
|
|
|
Data Buffer Size |
2MB |
|
|
(Mbytes) |
|
||
|
|
|
|
Formats Supported |
DVD: |
|
|
|
DVD-VIDEO, DVD-ROM, DVD-R, DVD-RW, DVD-RAM, |
||
|
DVD+R, DVD+-R (Double Layer), DVD+RW. |
||
|
CD: |
|
|
|
CD-DA, CD-ROM, CD-R, CD-RW, CD-ROMXA, Photo CD (Multi- |
||
|
Session), Video CD, CD-Extra (CD+), CD-Text. |
||
|
|
|
|
18 |
Satellite/Satellite Pro/L650/L655 Maintenance Manual |
Loading...