Loading...Toshiba Personal Computer
PORTÉGÉ M500
Satellite U200
Maintenance Manual
TOSHIBA CORPORATION
File Number 960-559
[CONFIDENTIAL]
Copyright
© 2006 by Toshiba Corporation. All rights reserved. Under the copyright laws, this manual cannot be reproduced in any form without the prior written permission of Toshiba. No patent liability is assumed with respect to the use of the information contained herein.
Toshiba Personal Computer PORTÉGÉ M500 Maintenance Manual
First edition April 2006
Disclaimer
The information presented in this manual has been reviewed and validated for accuracy. The included set of instructions and descriptions are accurate for the PORTÉGÉ M500 at the time of this manual's production. However, succeeding computers and manuals are subject to change without notice. Therefore, Toshiba assumes no liability for damages incurred directly or indirectly from errors, omissions, or discrepancies between any succeeding product and this manual.
Trademarks
IBM is a registered trademark and IBM PC is a trademark of International Business Machines Corporation.
Intel, Intel SpeedStep, Intel Core, Celeron and Centrino are trademarks or registered trademarks of Intel Corporation or its subsidiaries in the United States and other countries/regions.
Windows and Microsoft are registered trademarks of Microsoft Corporation. Photo CD is a trademark of Eastman Kodak.
Bluetooth is a trademark owned by its proprietor and used by TOSHIBA under license. i.LINK is a trademark of Sony Corporation.
ii |
[CONFIDENTIAL] |
PORTÉGÉ M500 Maintenance Manual (960-559) |
Preface
This maintenance manual describes how to perform hardware service maintenance for the Toshiba Personal Computer PORTÉGÉ M500.
The procedures described in this manual are intended to help service technicians isolate faulty Field Replaceable Units (FRUs) and replace them in the field.
SAFETY PRECAUTIONS
Four types of messages are used in this manual to bring important information to your attention. Each of these messages will be italicized and identified as shown below.
DANGER: “Danger” indicates the existence of a hazard that could result in death or serious bodily injury, if the safety instruction is not observed.
WARNING: “Warning” indicates the existence of a hazard that could result in bodily injury, if the safety instruction is not observed.
CAUTION: “Caution” indicates the existence of a hazard that could result in property damage, if the safety instruction is not observed.
NOTE: “Note” contains general information that relates to your safe maintenance service.
Improper repair of the computer may result in safety hazards. Toshiba requires service technicians and authorized dealers or service providers to ensure the following safety precautions are adhered to strictly.
Be sure to fasten screws securely with the right screwdriver. If a screw is not fully fastened, it could come loose, creating a danger of a short circuit, which could cause overheating, smoke or fire.
If you replace the battery pack or RTC battery, be sure to use only the same model battery or an equivalent battery recommended by Toshiba. Installation of the wrong battery can cause the battery to explode.
PORTÉGÉ M500 Maintenance Manual (960-559) |
[CONFIDENTIAL] |
iii |
The manual is divided into the following parts:
Chapter 1 Hardware Overview describes the PORTÉGÉ M500 system unit and each FRU.
Chapter 2 Troubleshooting Procedures explains how to diagnose and resolve FRU problems.
Chapter 3 Test and Diagnostics describes how to perform test and diagnostic operations for maintenance service.
Chapter 4 Replacement Procedures describes the removal and replacement of the FRUs.
Appendices The appendices describe the following:
Handling the LCD module
Board layout
Pin assignments
Keyboard scan/character codes
Key layout
Wiring diagrams
BIOS rewrite procedures
EC/KBC rewrite procedures
Reliability
iv |
[CONFIDENTIAL] |
PORTÉGÉ M500 Maintenance Manual (960-559) |
Conventions
This manual uses the following formats to describe, identify, and highlight terms and operating procedures.
Acronyms
On the first appearance and whenever necessary for clarification acronyms are enclosed in parentheses following their definition. For example:
Read Only Memory (ROM)
Keys
Keys are used in the text to describe many operations. The key top symbol as it appears on the keyboard is printed in boldface type.
Key operation
Some operations require you to simultaneously use two or more keys. We identify such operations by the key top symbols separated by a plus (+) sign. For example, Ctrl + Pause (Break) means you must hold down Ctrl and at the same time press Pause (Break). If three keys are used, hold down the first two and at the same time press the third.
User input
Text that you are instructed to type in is shown in the boldface type below:
DISKCOPY A: B:
The display
Text generated by the computer that appears on its display is presented in the type face below:
Format complete
System transferred
PORTÉGÉ M500 Maintenance Manual (960-559) |
[CONFIDENTIAL] |
v |
Table of Contents
Chapter 1 Hardware Overview |
|
|
1.1 |
Features ...................................................................................................................... |
1-1 |
1.2 |
2.5-inch Hard Disk Drive......................................................................................... |
1-12 |
1.3 |
Keyboard.................................................................................................................. |
1-14 |
1.4 |
Optical Drive............................................................................................................ |
1-15 |
1.5 |
TFT Color Display................................................................................................... |
1-17 |
1.6 |
Power Supply ........................................................................................................... |
1-19 |
1.7 |
Batteries ................................................................................................................... |
1-21 |
1.8 |
AC Adaptor.............................................................................................................. |
1-23 |
Chapter 2 Troubleshooting Procedures |
|
|
2.1 |
Troubleshooting ......................................................................................................... |
2-1 |
2.2 |
Troubleshooting Flowchart........................................................................................ |
2-3 |
2.3 |
Power Supply Troubleshooting.................................................................................. |
2-7 |
2.4 |
System Board Troubleshooting................................................................................ |
2-19 |
2.5 |
USB FDD Troubleshooting ..................................................................................... |
2-36 |
2.6 |
HDD Troubleshooting ............................................................................................. |
2-39 |
2.7 |
Keyboard and Touch pad Troubleshooting.............................................................. |
2-44 |
2.8 |
Display Troubleshooting.......................................................................................... |
2-47 |
2.9 |
Optical Drive Troubleshooting ................................................................................ |
2-49 |
2.10 |
Modem Troubleshooting.......................................................................................... |
2-51 |
2.11 |
LAN Troubleshooting.............................................................................................. |
2-53 |
2.12 |
Bluetooth Troubleshooting ...................................................................................... |
2-54 |
2.13 |
Wireless LAN Troubleshooting............................................................................... |
2-56 |
2.14 |
Sound Troubleshooting............................................................................................ |
2-58 |
2.15 |
Bridge media Slot Troubleshooting......................................................................... |
2-61 |
2.16 |
Fingerprint sensor Troubleshooting......................................................................... |
2-62 |
vi |
[CONFIDENTIAL] |
PORTÉGÉ M500 Maintenance Manual (960-559) |
Chapter 3 Tests and Diagnostics |
|
|
3.1 |
The Diagnostic Test ................................................................................................... |
3-1 |
3.2 |
Executing the Diagnostic Test ................................................................................... |
3-4 |
3.3 |
Setting of the hardware configuration ....................................................................... |
3-9 |
3.4 |
Heatrun Test............................................................................................................. |
3-11 |
3.5 |
Subtest Names.......................................................................................................... |
3-12 |
3.6 |
System Test.............................................................................................................. |
3-14 |
3.7 |
Memory Test............................................................................................................ |
3-16 |
3.8 |
Keyboard Test.......................................................................................................... |
3-17 |
3.9 |
Display Test ............................................................................................................. |
3-18 |
3.10 |
Floppy Disk Test...................................................................................................... |
3-21 |
3.11 |
Printer Test............................................................................................................... |
3-23 |
3.12 |
Async Test ............................................................................................................... |
3-25 |
3.13 |
Hard Disk Test ......................................................................................................... |
3-26 |
3.14 |
Real Timer Test........................................................................................................ |
3-29 |
3.15 |
NDP Test.................................................................................................................. |
3-31 |
3.16 |
Expansion Test......................................................................................................... |
3-32 |
3.17 |
CD-ROM/DVD-ROM Test ..................................................................................... |
3-34 |
3.18 |
Error Code and Error Status Names......................................................................... |
3-35 |
3.19 |
Hard Disk Test Detail Status ................................................................................... |
3-38 |
3.20 |
ONLY ONE TEST................................................................................................... |
3-40 |
3.21 |
Head Cleaning.......................................................................................................... |
3-47 |
3.22 |
Log Utilities ............................................................................................................. |
3-48 |
3.23 |
Running Test............................................................................................................ |
3-50 |
3.24 |
Floppy Disk Drive Utilities...................................................................................... |
3-51 |
3.25 |
System Configuration .............................................................................................. |
3-56 |
3.26 |
Wireless LAN Test Program (Atheros) ................................................................... |
3-58 |
3.27 |
Wireless LAN Test Program (Intel-made a/b/g)...................................................... |
3-65 |
3.28 |
LAN/Modem/Bluetooth/IEEE1394 Test Program .................................................. |
3-69 |
3.29 |
Sound Test program................................................................................................. |
3-84 |
3.30 |
SETUP ..................................................................................................................... |
3-90 |
PORTÉGÉ M500 Maintenance Manual (960-559) |
[CONFIDENTIAL] |
vii |
Chapter 4 Replacement Procedures |
|
|
4.1 |
General....................................................................................................................... |
4-1 |
4.2 |
Battery pack ............................................................................................................... |
4-8 |
4.3 |
PC card..................................................................................................................... |
4-10 |
4.4 |
Bridge media............................................................................................................ |
4-11 |
4.5 |
HDD......................................................................................................................... |
4-12 |
4.6 |
Optical drive............................................................................................................. |
4-15 |
4.7 |
Keyboard.................................................................................................................. |
4-18 |
4.8 |
Memory module....................................................................................................... |
4-21 |
4.9 |
Cover FAT assembly ............................................................................................... |
4-23 |
4.10 |
Fingerprint sensor board .......................................................................................... |
4-28 |
4.11 |
Touch pad................................................................................................................. |
4-30 |
4.12 |
SW membrane.......................................................................................................... |
4-32 |
4.13 |
Bluetooth module..................................................................................................... |
4-34 |
4.14 |
Wireless LAN card .................................................................................................. |
4-36 |
4.15 |
MDC (Modem Daughter Card)................................................................................ |
4-38 |
4.16 |
Internal microphone ................................................................................................. |
4-40 |
4.17 |
RTC battery ............................................................................................................. |
4-42 |
4.18 |
Harness holder/LAN cable....................................................................................... |
4-44 |
4.19 |
System board/DC-IN jack........................................................................................ |
4-47 |
4.20 |
Modem jack/Wireless communication SW.............................................................. |
4-50 |
4.21 |
Fan/CPU................................................................................................................... |
4-53 |
4.22 |
HDD cable/PC card slot........................................................................................... |
4-57 |
4.23 |
LCD unit/FL inverter ............................................................................................... |
4-59 |
4.24 |
Speaker/LCD cable .................................................................................................. |
4-65 |
4.25 |
Cover latch............................................................................................................... |
4-67 |
4.26 |
Wireless LAN antenna/Bluetooth antenna............................................................... |
4-68 |
4.27 |
Hinge........................................................................................................................ |
4-70 |
4.28 |
Battery slider............................................................................................................ |
4-72 |
4.29 |
Fluorescent Lamp..................................................................................................... |
4-73 |
viii |
[CONFIDENTIAL] |
PORTÉGÉ M500 Maintenance Manual (960-559) |
Appendices |
|
|
Appendix A |
Handling the LCD Module ........................................................................... |
A-1 |
Appendix B |
Board Layout ................................................................................................ |
B-1 |
Appendix C |
Pin Assignments............................................................................................ |
C-1 |
Appendix D |
Keyboard Scan/Character Codes .................................................................. |
D-1 |
Appendix E |
Key Layout..................................................................................................... |
E-1 |
Appendix F |
Wiring Diagrams............................................................................................ |
F-1 |
Appendix G |
BIOS rewrite Procedures .............................................................................. |
G-1 |
Appendix H |
EC/KBC rewrite Procedures ......................................................................... |
H-1 |
Appendix I |
Reliability........................................................................................................ |
I-1 |
PORTÉGÉ M500 Maintenance Manual (960-559) |
[CONFIDENTIAL] |
ix |
x |
[CONFIDENTIAL] |
PORTÉGÉ M500 Maintenance Manual (960-559) |
Chapter 1
Hardware Overview
[CONFIDENTIAL]
1 Hardware Overview
1-ii |
[CONFIDENTIAL] |
PORTÉGÉ M500 Maintenance Manual (960-559) |
|
|
|
1 Hardware Overview |
|
|
|
|
Chapter 1 |
Contents |
|
|
1.1 |
Features....................................................................................................................... |
|
1-1 |
1.2 |
2.5-inch Hard Disk Drive ......................................................................................... |
1-12 |
|
1.3 |
Keyboard .................................................................................................................. |
|
1-14 |
1.4 |
Optical Drive ............................................................................................................ |
1-15 |
|
|
1.4.1 DVD-ROM & CD-R/RW Drive ......................................................... |
1-15 |
|
|
1.4.2 |
DVD-Super Multi Drive ..................................................................... |
1-16 |
1.5 |
TFT Color Display ................................................................................................... |
1-17 |
|
|
1.5.1 |
LCD Module ....................................................................................... |
1-17 |
|
1.5.2 |
FL Inverter Board ............................................................................... |
1-18 |
1.6 |
Power Supply............................................................................................................ |
1-19 |
|
1.7 |
Batteries.................................................................................................................... |
|
1-21 |
|
1.7.1 |
Main Battery ....................................................................................... |
1-21 |
|
1.7.2 |
RTC battery......................................................................................... |
1-22 |
1.8 |
AC Adaptor .............................................................................................................. |
|
1-23 |
PORTÉGÉ M500 Maintenance Manual (960-559) |
[CONFIDENTIAL] |
1-iii |
1 Hardware Overview
Figures |
|
|
Figure 1-1 |
Front of the computer ..................................................................................... |
1-5 |
Figure 1-2 |
System unit configuration............................................................................... |
1-5 |
Figure 1-3 |
System unit block diagram ............................................................................. |
1-6 |
Figure 1-4 |
2.5-inch HDD ............................................................................................... |
1-12 |
Figure 1-5 |
Keyboard ...................................................................................................... |
1-14 |
Figure 1-6 |
LCD module ................................................................................................. |
1-17 |
Tables |
|
|
Table 1-1 |
2.5-inch HDD specifications ........................................................................ |
1-12 |
Table 1-2 |
DVD-ROM&CD-R/RW drive specifications............................................... |
1-15 |
Table 1-3 |
DVD Super Multi drive specifications......................................................... |
1-16 |
Table 1-4 |
LCD module specifications .......................................................................... |
1-17 |
Table 1-5 |
FL inverter board specifications................................................................... |
1-18 |
Table 1-6 |
Power supply output rating........................................................................... |
1-20 |
Table 1-7 |
Battery specifications ................................................................................... |
1-21 |
Table 1-8 |
Time required for charges ............................................................................ |
1-21 |
Table 1-9 |
Data preservation time.................................................................................. |
1-22 |
Table 1-10 |
RTC battery charging/data preservation time............................................... |
1-22 |
Table 1-11 |
AC adapter specifications............................................................................. |
1-23 |
1-iv |
[CONFIDENTIAL] |
PORTÉGÉ M500 Maintenance Manual (960-559) |
1.1 Features |
1 Hardware Overview |
1.1Features
The Toshiba PORTÉGÉ M500 Personal Computer uses advanced Large Scale Integration (LSI), and Complementary Metal-Oxide Semiconductor (CMOS) technology extensively to provide compact size, minimum weight, low power usage and high reliability. This computer incorporates the following features.
There some models and options according to BTO system. Refer to the Parts List for the configuration of each model and options.
Microprocessor
The PORTÉGÉ M500 computer is equipped with one of the following processors.
Intel® CoreTM Duo
CoreTM Duo 1.66GHz (Processor Number : T2300)
1.83GHz (Processor Number : T2400)
2.00GHz (Processor Number : T2500)
2.16GHz (Processor Number : T2600)
2.33GHz (Processor Number : T2700)
Intel® CoreTM Solo
CoreTM Solo 1.66GHz (Processor Number : T1300)
1.83GHz (Processor Number : T1400)
Intel® Celeron® M
Celeron® M 1.46GHz (Processor Number : 410)
1.60GHz (Processor Number : 420)
1.73GHz (Processor Number : 430)
Chipset
Equipped with Intel 945GM/940GML as North Bridge, Intel ICH7-M as South Bridge and Texas Instrument PCI7412 as Card Controller.
VGA Controller
An internal Graphics Controller in North Bridge is used.
PORTÉGÉ M500 Maintenance Manual (960-559) |
[CONFIDENTIAL] |
1-1 |
1 Hardware Overview |
1.1 Features |
Memory
Two DDR2-533/DDR2-667 SDRAM slots. Memory modules can be installed to provide a maximum of 4GB (Intel 945GM) or 2GB (Intel 940GML). Memory modules are available in 256MB, 512MB, 1024MB and 2048MB sizes.
HDD
The computer has a 2.5-inch SATA HDD. The following capacities are available.
•40/60/80/100/120 GB
USB FDD
A 3.5-inch USB FDD accommodates 2HD (1.44MB) or 2DD (720KB) disks.
Optical Drive
DVD-ROM&CD-R/RW drive or DVD Super Multi drive (double layer) can be installed.
Display
LCD : Built-in 12.1 inch, 16M colors, WXGA (1280×800dots), thin type low temperature poly-silicon TFT color display.
External monitor : Supported via an RGB connector.
Keyboard
An-easy-to-use 84(US)/85(UK)-key keyboard provides a numeric keypad overlay for fast
numeric data entry or for cursor and page control. The keyboard also includes two keys that have special functions in Microsoft® Windows® 2000/XP. It supports software that uses a 101or 102-key enhanced keyboard.
Touch pad
A Touch Pad and control buttons in the palm rest enable control of the on-screen pointer and scrolling of windows.
Batteries
The computer has two batteries: a rechargeable Lithium-Ion main battery pack and RTC battery (that backs up the Real Time Clock and CMOS memory).
1-2 |
[CONFIDENTIAL] |
PORTÉGÉ M500 Maintenance Manual (960-559) |
1.1 Features |
1 Hardware Overview |
Universal Serial Bus (USB2.0)
Three USB ports are provided. The ports comply with the USB2.0 standard.
IEEE 1394 port
The computer comes with one IEEE 1394 port. It enables high-speed data transfer directly from external devices such as digital video cameras.
External monitor (RGB) port
The port enables connection of an external monitor, which is recognized automatically by Video Electronics Standards Association (VESA) Display Data Channel (DDC) 2B compatible functions.
PC card slot
A PC card slot is provided. The PC card slot (PCMCIA) accommodates one Type II card.
Bridge media slot
This supports one SD memory card/SDIO card/Memory stick/Memory stick PRO/xD picture card/MultiMediaCard slot. Data can be read and written by inserting each media to the slot.
Fingerprint sensor
The computer is equipped with a fingerprint sensor and fingerprint authentication utility. They enable only person who has registered his/her fingerprint to use the computer.
Sound system
The sound system is equipped with the following features:
•Stereo speakers
•Built-in microphone
•Volume control
•Stereo headphone jack
•External microphone jack
PORTÉGÉ M500 Maintenance Manual (960-559) |
[CONFIDENTIAL] |
1-3 |
1 Hardware Overview |
1.1 Features |
Internal modem
The computer contains a MDC, enabling data and fax communication. It supports ITU-T V.90 (V.92). The transfer rates are 56 Kbps for data reception, 33.6 Kbps for data transmission, and 14,400 bps for fax transmission. However, the actual speed depends on the line quality. The RJ11 modem jack is used to accommodate a telephone line. Both of V.90 and V.92 are supported only in USA, Canada and Australia. Only V.90 is available in other regions.
Internal LAN
The computer has built-in support for Ethernet LAN (10 megabits per second, 10BASE- T), Fast Ethernet LAN (100 megabits per second, 100BASE-TX) and Gigabit Ethernet LAN (1000 megabits per second, 1000BASE-T). It also supports Wakeup on LAN (WOL), Magic Packet and LED. Some models are not equipped with a Gigabit Ethernet LAN.
Wireless LAN
The computer is equipped with PCI Express Mini Card type wireless LAN card that supports 802.11 b/g or 802.11 a/b/g in the PCI Express MiniCard slot. This function can be switched on and off by a switch on the computer.
Bluetooth
The computer is equipped with Bluetooth (V2.0+EDR) communications standard enable wireless connection between electronic devices such as computers and printers. It supports wireless communication switch.
Presentation button
This button switches the display between internal display, external display, simultaneous display and multi-monitor display.
TOSHIBA Assist button
When this button is pressed during power-on, the PC is connected to “Toshiba Assist”. When this button is pressed during power-off, the PC is turned on and connected to “Toshiba Assist”.
1-4 |
[CONFIDENTIAL] |
PORTÉGÉ M500 Maintenance Manual (960-559) |
1.1 Features |
1 Hardware Overview |
The front of the computer is shown in figure 1-1.
Figure 1-1 Front of the computer
The system unit configuration is shown in figure 1-2.
Figure 1-2 System unit configuration
PORTÉGÉ M500 Maintenance Manual (960-559) |
[CONFIDENTIAL] |
1-5 |
1 Hardware Overview |
1.1 Features |
System Unit Block Diagram
Figure 1-3 is a block diagram of the system unit.
Figure 1-3 System unit block diagram
1-6 |
[CONFIDENTIAL] |
PORTÉGÉ M500 Maintenance Manual (960-559) |
1.1 Features |
1 Hardware Overview |
The system unit is composed of the following major components:
Processor
Intel® CoreTM Duo Processor (dual core) or Intel® CoreTM Solo Processor (single core)
• Core speed: |
|
Dual core: |
1.66GHz (T2300) /1.83GHz (T2400)/2.00GHz (T2500)/ |
|
2.16GHz (T2600)/2.33GHz (T2700) |
Single core |
1.66GHz (T1300)/1.83GHz (T1400) |
( |
): Processor Number |
–Processor bus speed: 667MHz
–Core voltage: 0.50 to 1.30V
–Integrated L1 cache memory of 64KB (32KB +32KB)
–Integrated L2 cache memory of 2MB
–Integrated NDP
–478-pin Micro FC-PGA package
Intel® Celeron® M Processor
•Core speed:
1.46GHz (410)/1.60GHz (420)/1.72GHz (430) ( ): Processor Number
–Processor bus speed: 533MHz
–Core voltage: 1.00 to 1.30V
–Integrated L1 cache memory of 64KB (32KB +32KB)
–Integrated L2 cache memory of 1MB
–Integrated NDP
–478-pin Micro FC-PGA package
PORTÉGÉ M500 Maintenance Manual (960-559) |
[CONFIDENTIAL] |
1-7 |
1 Hardware Overview |
1.1 Features |
Memory
Two memory slots capable of accepting DDR2-SDRAM 256MB, 512MB, 1024MB or 2048MB memory modules for a maximum of 4GB (Intel 945GM) or 2GB (Intel 940GML).
•200-pin Small Outline DIMM
•1.8V operation
•PC2-4200(DDR2-533)/PC2-5300(DDR2-667) support
Serial Peripheral Interface (SPI)
•One STMicro M25PE80-VMW6TG is used.
•8Mbits of flash memory are used.
–320KB for System BIOS
–64KB for VGA BIOS
–64KB for Finger Print PBA
–128KB for LAN BIOS
–24KB for Boot
–16KB for Parameter Block
–32KB for Option Log
–Others
North Bridge
•One Intel 945GM/940GML is used.
•Features:
–Supports Yonah Processor System Bus
–Supports System Memory : DDR2-400/DDR2-533/DDR2-667, 4GB (Intel 945GM) (max) or 2GB (Intel 940GML) (max)
–Internal Graphics Controller : Inter Generation 3.5 Integrated GFX Core (250MHz)
–DMI(Direct Media Interface)
–Supports ICH.
–1466-ball 37.5×37.5×2.56mm FC-BGA package
1-8 |
[CONFIDENTIAL] |
PORTÉGÉ M500 Maintenance Manual (960-559) |
1.1 Features |
1 Hardware Overview |
South Bridge (Intel ICH7-M)
•Features:
–DMI(Direct Media Interface)
–PCI Express I/F (4 ports)
–PCI Bus I/F Rev2.3 (6 PCI REQ/GNT Pairs)
–Integrated Serial ATA Host Controller (2 Prots,150MB/S)
–Integrated IDE Controller (Ultra ATA 100/66/33)
–AC’97 2.3 codecs
–Intel High Definition controller (Azalia)
–USB 1.1/2.0 Controller 8 ports
–Built-in LAN controller (WfM 2.0 & IEEE 802.3 compliance)
–Power Management (ACPI 2.0 compliance)
–SMBus2.0 controller
–Low Pin Count (LPC) interface (EC/KBC, Super I/O)
–IRQ controller
–Serial Interrupt Function
–Suspend/Resume control
–Built –in RTC
–GPIO
–652-ball 31×31×2.51mm BGA Package
PC Card Controller (TI PCI7412)
−PCI I/F
−CardBus / Ultra media Controller (1 socket)
−SD/MMC, Memory Stick, XD Card Controller
−1394 Controller (2 ports)
– 288-ball, 16×16×1.4mm, BGA Package
PORTÉGÉ M500 Maintenance Manual (960-559) |
[CONFIDENTIAL] |
1-9 |
1 Hardware Overview |
1.1 Features |
GPU
Graphics interface in North Bridge (Intel 945GM/940GML) is used.
−PCI Express Interface
−LCD Interface LVDS 2ch, Supports UXGA (1600×1200)
−Analog CRT : 400MHz RAMDAC, QXGA (2048×1536) monitor
−Does not support DVI
Sound Controller
•Azalia Link (Intel High Definition Audio I/F) built in the South Bridge (ICH7-M) + ADI AD1981HD
−Stereo speakers
−Built-in microphone
−Volume control
−Stereo headphone jack
−External microphone jack
Modem Controller
•Askey/FOXCONN-made one MDC is used.
•This controller has the following functions:
–One RJ11 port
–V.92 (V.90) 56K Modem/FAX
–Supports Ring Wakeup
1-10 |
[CONFIDENTIAL] |
PORTÉGÉ M500 Maintenance Manual (960-559) |
1.1 Features |
1 Hardware Overview |
Internal LAN Controller
•Intel made Ethernet LAN (10 megabits per second, 10BASE-T), Fast Ethernet LAN (100 megabits per second, 100BASE-TX) or Gigabit Ethernet LAN (1000 megabits per second, 1000BASE-T) is used. Some models are not equipped with a Gigabit Ethernet LAN.
•This controller has the following functions:
–PCI-Ex connection
–Supports Gigabit Ethernet
–Supports Fast Ethernet
–One RJ45 port
–Supports WOL
–Supports Magic Packet
–Supports LED
–Makes LAN to “Disable” in BIOS
Wireless LAN
•One Mini PCI Express Card slot
−Supports 802.11b/g or 802.11a/b/g
−Supports Communication SW
−Supports W-LAN via PCMCIA (Euro : GSM/GPRS)
−Does not support WOL
Other main system chips
•Clock Generator (ICS-made 954321AGLFT)
•EC/KBC (Renesas-made M306KAFCLRP U0)
•PSC (Toshiba-made TMP86FS49UG)
•Temperature sensor (ADM-made 1032ARMZ ×2)
•Acceleration sensor (ST Micro-made LIS3L02AQ3)
•TPM (Infineon-made SLB9635 TT 1.2)
PORTÉGÉ M500 Maintenance Manual (960-559) |
[CONFIDENTIAL] |
1-11 |
1 Hardware Overview |
1.2 2.5-inch Hard Disk Drive |
1.22.5-inch Hard Disk Drive
The removable HDD is a random access non-volatile storage device. It has a non-removable 2.5-inch magnetic disk and mini-Winchester type magnetic heads.
The computer supports a 40GB, 60GB, 80GB, 100GB or 120GB.
The HDD is shown in figure 1-4. Specifications are listed in Table 1-1.
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Figure 1-4 |
2.5-inch HDD |
|
|
|
|
|
|
|
Table 1-1 2.5-inch HDD specifications (1/2) |
|
|||||
|
|
|
|
|
|
|
|
||
|
Items |
|
Specifications |
|
|||||
|
|
|
|
|
|
|
|||
|
TOSHIBA |
TOSHIBA |
|
TOSHIBA |
TOSHIBA |
||||
|
|
|
|
|
|||||
|
|
|
|
HDD2D34BZK01 |
HDD2D35BZK01 |
|
HDD2D32BZK01 |
HDD2D30BZK01 |
|
Outline |
|
Width (mm) |
|
69.85±0.25 |
|
|
|||
dimensions |
|
Height (mm) |
|
9.5±0.2 |
|
|
|||
|
|
Depth (mm) |
|
100±0.41 |
|
|
|||
|
|
Weight (g) |
98 max. |
|
|
102 max. |
|||
Storage size (formatted) |
40GB |
60GB |
|
80GB |
100GB |
||||
|
|
|
|
|
|
||||
Speed (RPM) |
|
5,400 |
|
|
|||||
|
|
|
|
|
|
||||
Data transfer rate (Mb/s) |
218-429 |
244.7-474.7 |
|
218-429 |
236.1-456.0 |
||||
|
|
|
|
|
|
|
|||
Data buffer size (KB) |
|
8,192 |
|
|
|
16,384 |
|||
|
|
|
|
|
|
|
|||
Average seek time (ms) |
|
12 |
|
|
|
||||
Read |
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||
Motor startup time (s) |
4 typ. |
3.5 typ. |
|
|
4 typ. |
||||
|
|
|
|
|
|
|
|
|
|
1-12 |
[CONFIDENTIAL] |
PORTÉGÉ M500 Maintenance Manual (960-559) |
1.2 2.5-inch Hard Disk Drive |
1 Hardware Overview |
Table 1-1 2.5-inch HDD specifications (2/2)
|
Items |
|
Specifications |
|
|||
|
|
|
|
|
|
||
|
HITACHI GST |
HITACHI GST |
|
HITACHI GST |
HITACHI GST |
||
|
|
|
|
||||
|
|
|
G8BC00029411 |
G8BC00029611 |
|
G8BC00029811 |
G8BC00029A11 |
Outline |
|
Width (mm) |
|
69.85±0.25 |
|
||
dimensions |
|
Height (mm) |
|
9.5±0.2 |
|
||
|
|
Depth (mm) |
|
100.2±0.25 |
|
||
|
|
Weight (g) |
95 max. |
|
|
102 max. |
|
Storage size (formatted) |
40GB |
60GB |
|
80GB |
100GB |
||
|
|
|
|
|
|||
Speed (RPM) |
|
5,400 |
|
||||
|
|
|
|
|
|
||
Data transfer rate |
|
493 Mb/s max. |
|
||||
To/From media |
|
|
|||||
To/From host |
|
1.5Gbps |
|
||||
|
|
|
|
|
|||
Data buffer size (MB) |
|
|
8 |
|
|||
|
|
|
|
|
|
||
Average seek time (ms) |
|
|
12 |
|
|||
Read |
|
|
|
|
|
||
|
|
|
|
|
|
|
|
Motor startup time (s) |
|
3.5 typ. |
|
||||
|
|
|
|
|
|
|
|
|
Items |
|
Specifications |
||
|
|
|
|
||
|
TOSHIBA |
|
HITACHI GST |
||
|
|
|
|
||
|
|
|
HDD2D31BZK01 |
|
G8BC0002NA10 |
Outline |
|
Width (mm) |
69.85±0.25 |
|
69.85±0.25 |
dimensions |
|
Height (mm) |
9.5±0.2 |
|
9.5±0.2 |
|
|
Depth (mm) |
100±0.41 |
|
100.2±0.25 |
|
|
Weight (g) |
102 max. |
|
115 max. |
Storage size (formatted) |
120GB |
|
100GB |
||
|
|
|
|
||
Speed (RPM) |
5,400 |
|
7,200 |
||
|
|
|
|
||
Data transfer rate |
|
|
|
||
To/From media (Mb/s) |
244.7-474.7 |
|
629 max. |
||
To/From host (Gbps) |
- |
|
1.5 |
||
Data buffer size (KB) |
8,192 |
|
8,192 |
||
|
|
|
|
||
Average seek time (ms) |
12 |
|
10 typ. |
||
Read |
|
|
|
||
|
|
|
|
|
|
|
|
|
|
||
Motor startup time (s) |
3.5 typ. |
|
4 typ. |
||
|
|
|
|
|
|
PORTÉGÉ M500 Maintenance Manual (960-559) |
[CONFIDENTIAL] |
1-13 |
1 Hardware Overview |
1.3 Keyboard |
1.3Keyboard
The keyboard is mounted 84(US)/85(UK) keys that consist of character key and control key. The keyboard is connected to membrane connector on the system board and controlled by the keyboard controller.
Figure 1-5 is a view of the keyboard.
See Appendix E about a layout of the keyboard.
Figure 1-5 Keyboard
1-14 |
[CONFIDENTIAL] |
PORTÉGÉ M500 Maintenance Manual (960-559) |
1.4 Optical Drive |
1 Hardware Overview |
1.4Optical Drive
1.4.1 DVD-ROM & CD-R/RW Drive
The DVD-ROM & CD-R/RW drive accommodates either 12 cm (4.72-inch) or 8 cm (3.15inch) CD-ROM, DVD-ROM and CD-R/RW.
The specifications of the DVD-ROM & CD-R/RW drive are described in Table 1-2.
Table 1-2 DVD-ROM & CD-R/RW drive specifications
|
Item |
Specifications |
|
|
|
|
MATSUSHITA G8CC00025A20 |
|
|
|
|
|
|
|
Outline |
Width (mm) |
128 (excluding projections) |
dimensions |
|
|
Height (mm) |
9.5 (excluding projections) |
|
|
|
|
|
Depth (mm) |
129 (excluding projections) |
|
|
|
|
Mass (g) |
141±3 |
|
|
|
Data transfer speed (Read) |
|
|
DVD-ROM |
|
Max. 8x CAV |
CD-ROM |
|
Max. 24x CAV |
Data transfer speed (Write) |
|
|
CD-R |
|
Max. 24x CAV |
CD-RW |
|
Max. 4x CLV |
High Speed CD-RW |
Max. 10x CLV |
|
Ultra Speed CD-RW |
Max. 24x CAV |
|
|
|
|
ATAPI Burst (MB/s) |
16.6 (PIO MODE4) |
|
PIO Mode |
|
|
DMA Mode |
|
16.6 (Multi Word Mode2) |
Ultra DMA Mode |
33.3 (Ultra DMA Mode2) |
|
|
|
|
Data Buffer Capacity |
2MB |
|
|
|
|
Access time (ms) |
|
|
CD-ROM |
|
150 typ. (Random) |
DVD-ROM |
|
170 typ. (Random) |
Supported Disks |
CD: CD/CD-ROM (12cm, 8cm), CD-R, |
|
|
|
CD-RW |
|
|
DVD:DVD-ROM, DVD-R, DVD-RW, DVD-RAM, |
|
|
DVD-R DL, DVD+RW, DVD+RAM, |
|
|
DVD+R DL |
|
|
|
Supported Formats |
CD: CD-DA, CD-ROM, CD-ROM XA, |
|
|
|
PHOTO CD, CD-Extra(CD+), CD-text |
|
|
DVD:DVD-R, DVD-RW (Ver.1.2), |
|
|
DVD-Video, DVD+R, DVD+RW, |
|
|
DVD-RAM (2.6GB/4.7GB) |
PORTÉGÉ M500 Maintenance Manual (960-559) |
[CONFIDENTIAL] |
1-15 |
1 Hardware Overview |
1.4 Optical Drive |
1.4.2 DVD-Super Multi Drive
The DVD Super Multi drive accommodates either 12 cm (4.72-inch) or 8 cm (3.15-inch) CD-ROM, DVD-ROM, CD-R, CD-RW, DVD-R, DVD+R, DVD-RW, DVD+RW, DVDRAM, DVD-R DL and DVD+R DL.
The specifications are listed in Table 1-3.
Table 1-3 DVD Super Multi drive specifications
|
Item |
Specifications |
|
|
|
|
|
|
|
|
MATSUSHITA G8CC00030120 |
|
|
|
|
Outline |
|
Width (mm) |
128 (excluding projections) |
dimensions |
|
|
|
|
Height (mm) |
9.5 (excluding projections) |
|
|
|
||
|
|
|
|
|
|
Depth (mm) |
129 (excluding projections) |
|
|
|
|
|
|
Mass (g) |
140±5 |
|
|
|
|
Data transfer speed (Read) |
|
||
DVD-ROM |
|
|
Max. 8x CAV |
CD-ROM |
|
|
Max. 24x CAV |
Data transfer speed (Write) |
|
||
CD-R |
|
|
Max. 24x ZCLV |
CD-RW |
|
|
Max. 4x CLV |
High Speed CD-RW |
Max. 10x CLV |
||
Ultra Speed CD-RW |
Max. 16x CLV |
||
DVD-R |
|
|
Max. 8x ZCLV |
DVD-R DL |
|
|
Max. 2x CLV |
DVD-RW |
|
|
Max. 4x ZCLV |
DVD+R |
|
|
Max. 8x ZCLV |
DVD+R DL |
|
|
Max. 2.4x CLV |
DVD+RW |
|
|
Max. 4x ZCLV |
DVD-RAM |
|
|
Max. 2-3x ZCLV (4.7GB) |
ATAPI Burst (MB/s) |
16.6 (PIO MODE4) |
||
PIO Mode |
|
|
|
DMA Mode |
|
|
16.6 (Multi Word Mode2) |
Ultra DMA Mode |
33.3 (Ultra DMA Mode2) |
||
Data Buffer Capacity |
2MB |
||
|
|
||
Access time (ms) |
|
||
CD-ROM |
|
|
150Msec typ. |
DVD-ROM |
|
|
180msec typ. |
|
|
||
Supported Disks |
CD: CD/CD-ROM (12cm, 8cm), CD-R, CD-RW |
||
|
|
|
DVD: DVD-ROM, DVD-R, DVD-RW, DVD-RAM, DVD-R DL, |
|
|
|
DVD+RW, DVD+RAM, DVD+R DL |
|
|
||
Supported Formats |
CD: CD-DA, CD-ROM, CD-ROM XA, Photo CD (multi- |
||
|
|
|
Session), Video CD, CD-Extra (CD+), CD-text |
|
|
|
DVD:DVD-VIDEO, DVD-ROM, DVD-R (3.9GB, 4.7GB), |
|
|
|
DVD-R DL, DVD-RW (Ver.1.1, Ver.1.2), DVD-RAM, |
|
|
|
DVD+R, DVD+R DL, DVD+RW |
1-16 |
[CONFIDENTIAL] |
PORTÉGÉ M500 Maintenance Manual (960-559) |
Loading...