PS-500-1A
OWNER’S MANUAL
INSTANT POWER PLUS
™
CAUTION:
Before first use of power source, read this
manual, and follow all its Safety and Operating
Instructions with every use.
Save these Instructions
Schumacher Electric Corporation
Mount Prospect, IL 60056
00-99-000293/502
Model No.
PS-500-1A
Power Source
2
TABLE OF CONTENTS
SAFETY ............................................................................................... 3
Important Safety Instructions.......................................................... 3
OPERATION ........................................................................................ 4
Before using your power source ..................................................... 4
Low battery audio alarm ................................................................. 4
Setting the controls ........................................................................ 4
Operating instructions .................................................................... 5
Use of jump starter feature ............................................................. 5
Using the emergency flashing light................................................. 5
Using the white spotlight ................................................................ 5
LED lights operation ....................................................................... 5
12 volt DC cigarette lighter socket .................................................. 6
DC accessories socket on front ............................................... 6
Inverter socket only on back .................................................... 7
Inverter mounting straps and strips ................................................ 7
Inverter use with the power source ................................................ 7
Storage .......................................................................................... 7
WARRANTY ......................................................................................... 8
Please read this Owner’s Manual before
using your INSTANT POWER PLUS™.
CONTAINS SEALED NON-SPILLABLE LEAD-ACID BATTERY. MUST BE
DISPOSED OF PROPERLY.
WARNING: Possible explosion hazard. Contact with battery acid may
cause severe burns and blindness. Keep out of reach of children.
3
This product contains a sealed non-
spillable lead acid battery and must
be recycled or disposed of properly.
WARNING:
Working in the vicinity of a lead acid
battery is dangerous. Batteries re-
lease explosive gases during nor-
mal operation, charging and jump-
starting. Pay special attention to
cautionary markings on the battery,
the engine and any equipment to be
used. Read this guide completely
before using this product.
IMPORTANT:
Someone should be within range of
your voice or close enough to come
to your aid when you work near a
lead acid battery.
Have plenty of fresh water and soap
nearby in case battery acid contacts
skin, clothing, or eyes. If acid en-
ters the eye area, rinse with cold
water for at least 10 minutes and get
medical attention immediately.
Do not smoke, use matches or ciga-
rette lighter, or allow any spark or
flame near the battery or engine.
Do not drop any metal tool on to the
battery. It might spark or short-cir-
cuit the battery or other electrical
part that may cause an explosion.
Remove personal metal items
such as rings, bracelets, necklaces
and watches when working with a
lead acid battery. A lead acid bat-
tery could produce short circuit cur-
rent high enough to weld a ring or
the like, causing a severe burn.
IMPORTANT SAFETY INSTRUCTIONS
Never operate the power source unit
if it has received a hard blow, been
dropped, or otherwise damaged.
Take it to a qualified professional for
inspection and repair.
Never operate the power source unit
if it has a damaged lead wire or
clamp. Have the lead replaced.
Never disassemble unit, take it to
a qualified service professional if
service or repair is required. In-
correct assembly may result in
fire or electrical shock.
Place power unit as far away from
the battery as the cables will per-
mit.
CAUTION: JUMP START LEAD
ACID BATTERY ONLY
Use this power source for jumping
a lead acid battery only. It is not in-
tended to supply power to a low volt-
age electrical system other than in
a starter motor application. Do not
use to jump start dry cell batteries
that are commonly used with home
appliances. These batteries may
burst and cause bodily injury and
property damage.
Loading...