105r, 132r, & 137r
Electric Trimmers
OPERATOR’S MANUAL
FOR QUESTIONS, CALL 1-800-345-8746 in U.S. or 1-800-265-6778 in CANADA
www.ryobi.com
IMPORTANT MANUAL |
DO NOT THROW AWAY |
INTRODUCTION
THANK YOU
Thank you for purchasing this quality product. This modern outdoor power tool is designed to provide many hours of useful service. You will find it to be a great labor-saving device.
This operator’s manual provides you with easy- to-understand operating instructions. Read the entire manual and follow all of the instructions to keep your new outdoor power tool in top operating condition.
The other manual that came with your power tool, the parts manual, contains all of the information that you need to order parts.
PRODUCT REFERENCES, ILLUSTRATIONS AND SPECIFICATIONS
All information, illustrations and specifications in this manual are based on the latest product information available at the time of printing. We reserve the right to make changes at any time without notice.
Copyright © 1998 Ryobi Outdoor Products, Inc. All Rights Reserved.
Click-Link® is a registered trademark of Ryobi Outdoor Products, Inc.
SpeedSpool® is a registered trademark of Ryobi Outdoor Products, Inc.
NOTE: PROOF OF PURCHASE WILL BE REQUIRED FOR WARRANTY SERVICE.
THIS PRODUCT IS COVERED BY ONE OR MORE OF THE US PATENTS: 5,076,149; 4,779,405; 4,651,422; 4,505,040; 4,463,498; 4,369,742; 4,342,236; 4,223,441; 2,125,688; D-249,012; D-239,329; OTHER PATENTS PENDING.
SERVICE INFORMATION
Service on this unit both within and after the warranty period should be performed only by an authorized and approved service dealer.
Dial 1-800-345-8746 in the United States and 1-800-265-6778 in Canada to obtain a listing of the authorized service dealer nearest you.
Do not return the unit to the retailer.
TABLE OF CONTENTS
I. Safety Warnings . . . . . . . . . . . . . . . . . . .3-6
A. Safety and International Symbols . . . . .6
II. Assembly Instructions . . . . . . . . . . . . . . .7-8
A. Installing the D-Handle . . . . . . . . . . . . .7
B. Adjusting the D-Handle . . . . . . . . . . . . .7
C. Installing the String Guard
Models 105r and 132r . . . . . . . . . . . . . .7
D. Installing the String Guard
Model 137r . . . . . . . . . . . . . . . . . . . . . .8
III. Operating Instructions . . . . . . . . . . . . .8-10 A. Connecting the cord . . . . . . . . . . . . . . .8 B. Starting the trimmer . . . . . . . . . . . . . . . .8 C. Holding the trimmer . . . . . . . . . . . . . . . .8 D. Operating two-speed switch
Models 132r and 137r . . . . . . . . . . . . . .9 E. Operating the Click-Link System . . . . . .9 F. Adjusting the trimming line length . . . . .10 G. Decorative trimming . . . . . . . . . . . . . .10
IV. Maintenance and Repair Instructions .11-14 A. Line installation . . . . . . . . . . . . . . . . . .11 B. Winding the existing reel . . . . . . . . . . .11 C. Cleaning the SpeedSpool® . . . . . . . . .12 D. Installing a prewound reel . . . . . . . . . .13 E. Cleaning the trimmer . . . . . . . . . . . . . .14
V. Specifications . . . . . . . . . . . . . . . . . . . . .14
VI. Troubleshooting . . . . . . . . . . . . . . . . . . . .14
VII. Notes . . . . . . . . . . . . . . . . . . . . . . . . . . . .15
VIII. Warranty . . . . . . . . . . . . . . . . . . . . . . . . .16
Make sure this manual is carefully read and understood before starting or operating this equipment.
CONTENTS OF CARTON
This carton includes the following:
1.For completely assembled models:
•Trimmer
•Operator’s manual
•Owner’s registration card
2.For unassembled models - hardware pack containing:
•D-Handle and hardware
•String guard and screws
•Operator's manual
•Owner’s registration card
2
SAFETY WARNINGS
THE PURPOSE OF SAFETY SYMBOLS IS TO ATTRACT YOUR ATTENTION TO POSSIBLE DANGERS. THE SAFETY SYMBOLS, AND THE EXPLANATIONS WITH THEM, DESERVE YOUR CAREFUL ATTENTION AND UNDERSTANDING. THE SAFETY WARNINGS DO NOT BY THEMSELVES ELIMINATE ANY DANGER.
THE INSTRUCTIONS OR WARNINGS THEY GIVE ARE NOT SUBSTITUTES FOR PROPER ACCIDENT PREVENTION MEASURES.
SYMBOL MEANING
SAFETY ALERT SYMBOL:
Indicates danger, warning or caution. May be used in conjunction with other symbols or pictographs.
NOTE: Advises you of information or instructions vital to the operation or maintenance of the equipment.
DANGER: Failure to obey a safety warning will result in serious injury to yourself or to others. Always follow the safety precautions to reduce the risk of fire, electric shock, and personal injury.
WARNING: Failure to obey a safety warning can result in serious injury to yourself or to others. Always follow the safety precautions to reduce the risk of fire, electric shock, and personal injury.
CAUTION: Failure to obey a safety warning may result in
property damage or personal injury to yourself or to others. Always follow the safety precautions to reduce the risk of fire, electric shock, and personal injury.
• IMPORTANT SAFETY INFORMATION •
WARNING: When using electric gardening appliances, basic safety precautions should always be followed to reduce the risk of fire, electric shock, and personal injury. Carefully read and understand the entire Operator's Manual before using your trimmer. Pay close attention to the Operating Instructions and Safety Warnings.
READ ALL INSTRUCTIONS
ELECTRICAL SAFETY WARNINGS
•This tool is double-insulated. Use only identical replacement parts when servicing. Repair or replace damaged cords.
•WARNING: To reduce the risk of electrical shock, use only extension cords approved for outdoor use, such as an extension cord of cord type SW-A, SOW-A, STW-A, STOW-A, SJW-A, SJOW-A, SJTW-W or SJTOW-A. A 2- wire extension cord (an extension cord without a ground) may be used because the tool is double insulated. However, a 3-wire extension cord (an extension cord with a ground) that uses a NEMA type connector (parallel blade, U ground) may also be used. Extension cords are available from your local retailer. Use only round-jacketed extension cords approved for outdoor use.
•To reduce the risk of electrical shock, this unit has a polarized plug (one blade is wider than the other) and will require the use of a polarized extension cord. This unit plug will fit into a polarized extension cord only one way. If the plug does not fit fully into the extension cord, reverse the plug. If the plug still does not fit, obtain a correct polarized extension cord. A polarized extension cord will require the use of a polarized wall outlet. This plug will fit into a polarized wall outlet only one way. If the plug does not fit fully into the wall outlet, reverse the plug. If the plug still does not fit, contact a qualified electrician to install the proper wall outlet. Do not change the unit plug, extension cord receptacle, or extension cord plug in any way.
•Ground Fault Circuit Interrupter (GFCI) protection should be provided on the circuit(s) or outlet(s) to be used for this unit. Receptacles are available having built-in GFCI protection and may be used for this measure of safety.
3
SAFETY WARNINGS
•CORD SETS: Make sure your cord set is in good condition. When using a cord set, be sure to use a cord that is heavy enough to carry the current that your unit will draw. An undersized cord set will cause a drop in line voltage resulting in loss of power and overheating. The table shows the correct size to use depending on the cord length and nameplate amperage rating. If in doubt, use the next heavier size line gauge. The smaller the gauge number, the heavier the cord. To reduce the possibility of disconnection of the unit cord from the cord set during operation, see Fig. 9.
MINIMUM WIRE SIZE FOR EXTENSION CORDS FOR 120 VOLT APPLIANCES USING 0-6 AMPS
Cord length (ft) |
25 |
50 |
100 |
150 |
|
|
|
|
|
Wire size (AWG) |
16 |
16 |
16 |
14 |
|
|
|
|
|
•A nameplate on your unit indicates what voltage it uses. Never connect the unit to an AC voltage that differs from this voltage.
•Inspect all extension cords and the unit power connection periodically. Look closely for deterioration, cuts or cracks in the insulation. Also inspect the connections for damage. Repair or replace the cords if any defects appear.
•Avoid dangerous environments. Never operate your unit in damp or wet conditions. Moisture is a shock hazard.
•Do not use the unit in the rain.
•Do not handle the plug or the unit with wet hands.
BEFORE OPERATING
•Read the instructions carefully. Be familiar with the controls and proper use of the unit.
•Children and adolescents must not manipulate units, except for adolescents in training and under the supervision of a specialist.
•Before each use, check that the cutting head is correctly fixed and that the trigger returns automatically in neutral position.
•Thoroughly inspect the trimmer for loose or damaged parts before each use. Do not use until adjustments or repairs are made.
•All guards and safety attachments must be installed properly before operating the unit.
•Use the unit only in daylight or good artificial light.
•Keep all bystanders, especially children and pets, at least 30 feet (9.2 m) away from the unit during operation.
•Before starting, adjust the handle to your size and make sure that the cutting head is not in contact with anything.
•Be aware of the risk of injury to the head, hands and feet.
•Carefully inspect the areas to be cut. Remove all debris that could become entangled in the string or blade. Also remove any objects that could be thrown during cutting.
WHILE OPERATING
•Use the right tool. Do not use this trimmer for any job except that for which it is intended.
•Avoid accidental starting. Do not carry plugged-in unit with your finger on the switch. Be sure switch is off when plugging in.
•Do not abuse the power cord. Never carry the unit by the cord or yank the plug out of the receptacle. Keep the cord away from heat, oil and sharp edges.
•Always remain alert. To prevent injury to yourself and others, do not operate this trimmer if you are fatigued.
•Do not operate the unit while under the influence of drugs, alcohol or medication.
•Wear safety glasses or goggles at all times when operating this trimmer.
•Use a face mask or dust mask if operation is dusty.
•Do not overreach. Keep proper footing and balance at all times.
•Dress properly. Do not operate this trimmer when barefoot or wearing open sandals. Always wear sturdy, rubber-soled footwear. The use of gloves, ear/hearing protection and long pants are recommended.
4
SAFETY WARNINGS
•Do not wear loose fitting clothing or articles such as scarves, strings, chains, ties, etc., because they could get caught in moving parts. Also make sure long hair does not get caught in moving parts. Long hair must be pulled back and secured off shoulders and neck.
•Keep hands, face, and feet away from all moving parts. Do not attempt to touch or stop the string when it is rotating.
•Always hold the trimmer with both hands when operating. Keep a firm grip on both the front and rear handles or grips.
•Frequently inspect the condition of the cutting head. All damaged parts must be replaced immediately. Follow all the required precautions when undertaking replacement.
•If you strike or become entangled with a foreign object, stop the engine immediately and check for damage. Repair any damage before further operation is attempted. Do not operate the trimmer with loose or damaged parts.
•Do not operate the unit faster than the speed necessary to cut, trim or edge. Do not run the unit at high speed when not cutting.
•Do not force the unit. It will do the job better and with less likelihood of a risk of injury at the rate for which it was designed.
•The string guard must be in place at all times while operating the trimmer. Failure to use the string guard may cause the unit to overheat. DO NOT OPERATE WITHOUT THE GUARD IN PLACE.
•Do not extend the trimming line beyond the length of the guard specified in this manual.
•Do not operate trimmer without both trimming lines extended, and the proper line installed.
•Never use metal-reinforced or monofilament line that is not specifically designed for use with your model.
•Keep trimmer clean of vegetation and other materials.
•Always stop the unit when cutting is delayed or when walking from one cutting location to another.
•All interventions, whether for maintenance, repair or for changing cutting head or safety attachments, must be undertaken with the unit disconnected from the power supply.
•Use only genuine replacement parts when servicing this trimmer. These parts are available from your authorized dealer. The use of non-standard parts, or other
accessories or attachments not designed for this trimmer, could result in serious injury to the user or damage to the trimmer and void your warranty.
OTHER SAFETY WARNINGS
•Disconnect the unit from the power supply when not in use, before servicing, when changing accessories such as cutting head, and the like.
•Maintain trimmer with care. Keep the unit clean and serviced for the best and safest performance. Follow the maintenance instructions. Always use a clean cloth when cleaning. Never use strong detergents, gasoline, petroleum-based products, or any strong solvents to clean the unit.
•Keep your unit in good working condition. Follow instructions for servicing and changing accessories. Inspect unit periodically, and if damaged, have it repaired by an authorized service facility. Inspect extension cords periodically and replace if damaged. Keep handles dry, clean, and free from oil and grease.
•Store unit indoors. When not in use, appliances should be stored indoors in a dry, and high or locked-up place, out of the reach of children.
•Keep these instructions. Refer to them frequently and use them to instruct other users. If you loan someone this unit, also loan them these instructions.
SAVE THESE INSTRUCTIONS
5
Loading...