Pentair UVBB-120, UV-120, UVS-110, UV-110 User Manual

0 (0)

UV Systems

Installation and Operating Instructions

Models UVS-110, UV-110, UV-120, UVBB-120

Model

 

Part #

Part #

 

(120v/60Hz)

(220v/50Hz)

UVS-110

 

163003

163004

UV-110

 

163005

163006

UV-120

 

163007

163008

UVBB-120

 

163009

163010

APPLICATION

 

 

 

 

Ultraviolet Water Disinfection

 

 

 

SPECIFICATIONS

 

 

 

Models

UVS-110

UV-110

UV-120 UVBB-120

Maximum Operating Pressure

65 psi

65 psi

65 psi

65 psi

 

(4.5 bar)

(4.5 bar)

(4.5 bar)

(4.5 bar)

Temperature Range

40–100° F

40–100° F

40–100° F

40–100° F

(4.4–37.8° C) (4.4–37.8° C)

(4.4–37.8° C)

(4.4–37.8° C)

Flow Rate @ 60 psi (4.1 bar)

1 gpm

2 gpm

8 gpm

15 gpm

 

(3.8 Lpm)

(7.6 Lpm)

(30 Lpm)

(56 Lpm)

Voltage (Domestic)

120v/60Hz

120v/60Hz

120v/60Hz

120v/60Hz

Voltage (International)

220v/50Hz

220v/50Hz

220v/50Hz

220v/50Hz

CBU Cartridge

 

 

 

 

The UVS-110 and the UV-110 are supplied with a carbon block filter cartridge which reduces sediment, bad taste and odor.

GENERAL PRECAUTIONS

WARNING: Always disconnect the UV from the power source. Follow the procedures provided in this manual. Improper handling can result in death or serious injury.

WARNING: Do not look directly at the UV lamp. This can cause retina/eye damage.

WARNING: Do not touch the UV bulb. Any fingerprints or dirt will reduce the efficiency of the bulb and may cause it to explode. WARNING: Observe caution when inserting quartz sleeve to prevent breakage and cracking, which may result in injury and damage to unit. NOTE: When handling the UV bulb hold only the plastic-covered ends of the bulb. If the bulb has been touched, remove bulb and clean with alcohol before reinserting

CAUTION: If water pressure exceeds 65 psi, a pressure regulator, set at less than 65 psi, must be installed before the Ultraviolet system. CAUTION: Install on cold water lines only.

CAUTION: Do not install where system is exposed to direct sunlight. CAUTION: Do not use wicking or sealing agents for fitting connections. Teflon® tape is recommended.

CAUTION: This system must be protected from freezing which can cause cracking of the filter housing and water leakage.

CAUTION: Because of the product’s limited service life, and to prevent costly repairs or possible water damage, we strongly recommend that the bottom of all opaque housings be replaced every ten years. If the bottom of your housing has been in use for more than this period, it should be replaced immediately. Date the bottom of any new or replacement housing to indicate the next recommended replacement date. NOTE: Filter cartridge life varies depending on filter type, usage and water conditions.

For the UVS-110 and UV-110

Allow a minimum of 12 inches clearance under the filter for changing the cartridge, and above the system to allow the UV bulb to be changed.

For the UV-120 and UVBB-120

Allow a minimum of 20 inches clearance under the filter for changing the cartridge, and above the system to allow the UV bulb to be changed.

ASSEMBLY INSTRUCTIONS

See exploded assembly drawings on pages 2 and 3.

CARTRIDGE REPLACEMENT (for UVS-110 and UV-110 only)

Your cartridge should be replaced when there is a noticeable drop in water flow at the faucet or tap, and/or when unpleasant odors return (approximately every 6-9 months).

1.Turn off water supply to the system.

2.Open faucet to relieve water pressure to the housing.

3.Unscrew housing from cap. If housing sticks or is difficult to open use an Pentek spanner wrench.

4.Remove used cartridge from housing, remove Teflon® sleeve and discard cartridge.

5.Remove O-ring from groove below the threads of the housing and wipe groove and O-ring clean. Lubricate O-ring with silicone grease. Place O-ring back into the groove. With two fingers wipe or press O- ring down into the groove. NOTE: This step is important to ensure a proper filter seal. Make sure that the O-ring is seated level in the groove.

6.Insert a new cartridge into the sump making sure that it slips down over the sump standpipe.

7Remove gasket from cartridge end and slide Teflon® sleeve into center of cartridge then replace gasket on top of cartridge.

8.Screw the sump onto the cap and hand-tighten. Do not over-tight- en. Make sure that the cap slips over the cap standpipe.

9.Turn on the water supply to allow the unit to slowly fill with water.

10.Check for leaks before leaving installation.

Each time that you use water from your unit for drinking or cooking purposes, it is recommended that you run (flush) the tap for at least 10 seconds prior to using water. This is particularly important if the water tap is not used daily.

UV LAMP REPLACEMENT

1.Turn off all electrical power to the system by unplugging or throwing the circuit.

2.Unscrew the UV control module from the mounting bracket (4 screws) for Models UV-110, UV-120 and UVBB-120.

For Model UVS-100, slide mounting bracket retainer to allow access to the UV bulb.

3.Slide the old bulb out and unplug from the control module.

NOTE: Hold the UV lamp only by the plastic covered ends of the bulb.

4.Carefully discard the old UV lamp.

5.Holding the new UV lamp only by the plastic covered ends of the bulb, plug the new UV lamp into the control module or power cord. Slide the new bulb into the cartridge housing and reattach UV control module or secure mounting bracket retainer (depending on model).

6.Restore electrical power to unit.

7.Check for leaks.

Pentair UVBB-120, UV-120, UVS-110, UV-110 User Manual

UVS-110

REPLACEMENT PARTS

Part Description

Part #

 

 

 

 

 

 

 

 

 

1.

10” SlimLine™ Housing

153017

 

 

 

 

 

 

 

 

 

2.

O-ring

143026

 

 

 

 

 

 

 

 

 

3.

CBU-10

155271-03

 

 

 

 

 

 

4.

Teflon® Sleeve

163518

 

 

 

 

 

 

 

 

 

5.

Quartz Sleeve

163504

 

 

 

 

 

 

 

 

 

6.

O-rings for Quartz Sleeve

163538

 

 

 

 

 

 

 

 

 

7.

1/2” Blk Cap w/o pr

SPECIAL ORDER

8.

Spacer Bushing

163517

 

 

 

 

 

 

 

 

 

9.

Mounting bracket

SPECIAL ORDER

10.

UV lamp

163503

 

 

 

 

 

 

 

 

 

11.

Control Module (120v/60Hz)

163501

 

for use with UVS-110-1

 

Control Module (220v/50Hz)

163502

 

for use with UVS-110-2

12.

SW-1 Wrench (not shown)

150539

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

UV-110

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

REPLACEMENT PARTS

Part Description

 

 

Part #

 

 

 

 

 

 

 

 

 

 

1.

 

10” Housing

153001

 

 

 

 

 

 

 

 

 

 

 

 

 

 

2.

 

O-ring

143011

 

 

 

 

 

 

 

 

 

 

 

 

 

 

3.

 

CBU-10

155271-03

 

 

 

 

 

 

 

 

 

 

4.

 

Teflon® Sleeve

163518

 

 

 

 

 

 

 

 

 

 

 

 

 

 

5.

 

Quartz Sleeve

163509

 

 

 

 

 

 

 

 

 

 

 

 

 

 

6.

 

O-rings for Quartz sleeve

163516

 

 

 

 

 

 

 

 

 

 

 

 

 

 

7.

 

Plunger Rod w/retainer

163519

 

 

 

 

 

 

 

 

 

 

 

 

 

 

8.

 

3/4” blk cap w/o pr

 

 

SPECIAL ORDER

9.

 

Spacer Bushing

163517

 

 

 

 

 

 

 

 

 

 

 

 

 

 

10.

Mounting bracket

 

 

SPECIAL ORDER

11.

UV Lamp

163508

 

 

 

 

 

 

 

 

 

 

 

 

 

 

12.

Control Module (120v/60Hz)

163506

 

 

 

 

for use with UV-110-1

 

 

Control Module (220v/50Hz)

163507

 

 

 

 

for use with UV-110-2

13.

SW-2 Wrench (not shown)

150295

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Loading...
+ 2 hidden pages