Nokia N93i Service Manual ssue1

Nokia Customer Care

Service Manual

RM-156 (Nokia N93i)

Mobile Terminal

Part No: 9200670 (Issue 1)

COMPANY CONFIDENTIAL

Copyright © 2007 Nokia. All rights reserved.

	RM-156
Nokia Customer Care	Amendment Record Sheet

Amendment Record Sheet

Amendment No	Date	Inserted By	Comments
Issue 1	01/2007	M. Hautaniemi

Page ii	COMPANY CONFIDENTIAL	Issue 1
	Copyright © 2007 Nokia. All rights reserved.

RM-156
Copyright	Nokia Customer Care

Copyright

Copyright © 2007 Nokia. All rights reserved.

Reproduction, transfer, distribution or storage of part or all of the contents in this document in any form without the prior written permission of Nokia is prohibited.

Nokia, Nokia Connecting People, and Nokia X and Y are trademarks or registered trademarks of Nokia Corporation. Other product and company names mentioned herein may be trademarks or tradenames of their respective owners.

Nokia operates a policy of continuous development. Nokia reserves the right to make changes and improvements to any of the products described in this document without prior notice.

Under no circumstances shall Nokia be responsible for any loss of data or income or any special, incidental, consequential or indirect damages howsoever caused.

The contents of this document are provided "as is". Except as required by applicable law, no warranties of any kind, either express or implied, including, but not limited to, the implied warranties of merchantability and fitness for a particular purpose, are made in relation to the accuracy, reliability or contents of this document. Nokia reserves the right to revise this document or withdraw it at any time without prior notice.

The availability of particular products may vary by region.

IMPORTANT

This document is intended for use by qualified service personnel only.

Issue 1	COMPANY CONFIDENTIAL	Page iii
	Copyright © 2007 Nokia. All rights reserved.

	RM-156
Nokia Customer Care	Warnings and cautions

Warnings and cautions

Warnings

•IF THE DEVICE CAN BE INSTALLED IN A VEHICLE, CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH ELECTRONIC ENGINE MANAGEMENT SYSTEMS AND ANTI-SKID BRAKING SYSTEMS. UNDER CERTAIN FAULT CONDITIONS, EMITTED RF ENERGY CAN AFFECT THEIR OPERATION. IF NECESSARY, CONSULT THE VEHICLE DEALER/ MANUFACTURER TO DETERMINE THE IMMUNITY OF VEHICLE ELECTRONIC SYSTEMS TO RF ENERGY.

•THE PRODUCT MUST NOT BE OPERATED IN AREAS LIKELY TO CONTAIN POTENTIALLY EXPLOSIVE ATMOSPHERES, FOR EXAMPLE, PETROL STATIONS (SERVICE STATIONS), BLASTING AREAS ETC.

•OPERATION OF ANY RADIO TRANSMITTING EQUIPMENT, INCLUDING CELLULAR TELEPHONES, MAY INTERFERE WITH THE FUNCTIONALITY OF INADEQUATELY PROTECTED MEDICAL DEVICES. CONSULT A PHYSICIAN OR THE MANUFACTURER OF THE MEDICAL DEVICE IF YOU HAVE ANY QUESTIONS. OTHER ELECTRONIC EQUIPMENT MAY ALSO BE SUBJECT TO INTERFERENCE.

•BEFORE MAKING ANY TEST CONNECTIONS, MAKE SURE YOU HAVE SWITCHED OFF ALL EQUIPMENT.

Cautions

•Servicing and alignment must be undertaken by qualified personnel only.

•Ensure all work is carried out at an anti-static workstation and that an anti-static wrist strap is worn.

•Ensure solder, wire, or foreign matter does not enter the telephone as damage may result.

•Use only approved components as specified in the parts list.

•Ensure all components, modules, screws and insulators are correctly re-fitted after servicing and alignment.

•Ensure all cables and wires are repositioned correctly.

•Never test a mobile phone WCDMA transmitter with full Tx power, if there is no possibility to perform the measurements in a good performance RF-shielded room. Even low power WCDMA transmitters may disturb nearby WCDMA networks and cause problems to 3G cellular phone communication in a wide area.

•During testing never activate the GSM or WCDMA transmitter without a proper antenna load, otherwise GSM or WCDMA PA may be damaged.

Page iv	COMPANY CONFIDENTIAL	Issue 1
	Copyright © 2007 Nokia. All rights reserved.

RM-156
ESD protection	Nokia Customer Care

ESD protection

Nokia requires that service points have sufficient ESD protection (against static electricity) when servicing the phone.

Any product of which the covers are removed must be handled with ESD protection. The SIM card can be replaced without ESD protection if the product is otherwise ready for use.

To replace the covers ESD protection must be applied.

All electronic parts of the product are susceptible to ESD. Resistors, too, can be damaged by static electricity discharge.

All ESD sensitive parts must be packed in metallized protective bags during shipping and handling outside any ESD Protected Area (EPA).

Every repair action involving opening the product or handling the product components must be done under ESD protection.

ESD protected spare part packages MUST NOT be opened/closed out of an ESD Protected Area.

For more information and local requirements about ESD protection and ESD Protected Area, contact your local Nokia After Market Services representative.

Issue 1	COMPANY CONFIDENTIAL	Page v
	Copyright © 2007 Nokia. All rights reserved.

	RM-156
Nokia Customer Care	Care and maintenance

Care and maintenance

This product is of superior design and craftsmanship and should be treated with care. The suggestions below will help you to fulfil any warranty obligations and to enjoy this product for many years.

•Keep the phone and all its parts and accessories out of the reach of small children.

•Keep the phone dry. Precipitation, humidity and all types of liquids or moisture can contain minerals that will corrode electronic circuits.

•Do not use or store the phone in dusty, dirty areas. Its moving parts can be damaged.

•Do not store the phone in hot areas. High temperatures can shorten the life of electronic devices, damage batteries, and warp or melt certain plastics.

•Do not store the phone in cold areas. When it warms up (to its normal temperature), moisture can form inside, which may damage electronic circuit boards.

•Do not drop, knock or shake the phone. Rough handling can break internal circuit boards.

•Do not use harsh chemicals, cleaning solvents, or strong detergents to clean the phone.

•Do not paint the phone. Paint can clog the moving parts and prevent proper operation.

•Use only the supplied or an approved replacement antenna. Unauthorised antennas, modifications or attachments could damage the phone and may violate regulations governing radio devices.

All of the above suggestions apply equally to the product, battery, charger or any accessory.

Page vi	COMPANY CONFIDENTIAL	Issue 1
	Copyright © 2007 Nokia. All rights reserved.

RM-156
Company Policy	Nokia Customer Care

Company Policy

Our policy is of continuous development; details of all technical modifications will be included with service bulletins.

While every endeavour has been made to ensure the accuracy of this document, some errors may exist. If any errors are found by the reader, NOKIA MOBILE PHONES Business Group should be notified in writing/e- mail.

Please state:

•Title of the Document + Issue Number/Date of publication

•Latest Amendment Number (if applicable)

•Page(s) and/or Figure(s) in error

Please send to:

NOKIA CORPORATION

Nokia Mobile Phones Business Group

Nokia Customer Care

PO Box 86

FIN-24101 SALO

Finland

E-mail: [e-mail]

Issue 1	COMPANY CONFIDENTIAL	Page vii
	Copyright © 2007 Nokia. All rights reserved.

	RM-156
Nokia Customer Care	Battery information

Battery information

Note: A new battery's full performance is achieved only after two or three complete charge and discharge cycles!

The battery can be charged and discharged hundreds of times but it will eventually wear out. When the operating time (talk-time and standby time) is noticeably shorter than normal, it is time to buy a new battery.

Use only batteries approved by the phone manufacturer and recharge the battery only with the chargers approved by the manufacturer. Unplug the charger when not in use. Do not leave the battery connected to a charger for longer than a week, since overcharging may shorten its lifetime. If left unused a fully charged battery will discharge itself over time.

Temperature extremes can affect the ability of your battery to charge.

For good operation times with Ni-Cd/NiMh batteries, discharge the battery from time to time by leaving the product switched on until it turns itself off (or by using the battery discharge facility of any approved accessory available for the product). Do not attempt to discharge the battery by any other means.

Use the battery only for its intended purpose. Never use any charger or battery which is damaged.

Do not short-circuit the battery. Accidental short-circuiting can occur when a metallic object (coin, clip or pen) causes direct connection of the + and - terminals of the battery (metal strips on the battery) for example when you carry a spare battery in your pocket or purse. Short-circuiting the terminals may damage the battery or the connecting object.

Leaving the battery in hot or cold places, such as in a closed car in summer or winter conditions, will reduce the capacity and lifetime of the battery. Always try to keep the battery between 15°C and 25°C (59°F and 77° F). A phone with a hot or cold battery may temporarily not work, even when the battery is fully charged.

Batteries' performance is particularly limited in temperatures well below freezing. Do not dispose of batteries in a fire!

Dispose of batteries according to local regulations (e.g. recycling). Do not dispose as household waste.

Page viii	COMPANY CONFIDENTIAL	Issue 1
	Copyright © 2007 Nokia. All rights reserved.

RM-156
Nokia N93i Service Manual Structure	Nokia Customer Care

Nokia N93i Service Manual Structure

1 General Information

2 Parts Lists and Component Layouts

3 Phoenix Service Software Instructions

4 Service Tools and Service Concepts

5 Disassembly and reassembly instructions

6 BB Troubleshooting and Tuning Guide

7 RF Troubleshooting and Tuning Guide

8 Camera Module Troubleshooting

9 System Module

10 Schematics

Issue 1	COMPANY CONFIDENTIAL	Page ix
	Copyright © 2007 Nokia. All rights reserved.

	RM-156
Nokia Customer Care	Nokia N93i Service Manual Structure

(This page left intentionally blank.)

Page x	COMPANY CONFIDENTIAL	Issue 1
	Copyright © 2007 Nokia. All rights reserved.

Nokia Customer Care

1 — General Information

Issue 1	COMPANY CONFIDENTIAL	Page 1 –1
	Copyright © 2007 Nokia. All rights reserved.

	RM-156
Nokia Customer Care	General Information

(This page left intentionally blank.)

Page 1 –2	COMPANY CONFIDENTIAL	Issue 1
	Copyright © 2007 Nokia. All rights reserved.

RM-156
General Information	Nokia Customer Care

Table of Contents
RM-156 product selection......................................................................................................................................	1–5
Product features and sales package.....................................................................................................................	1–5
Mobile enhancements............................................................................................................................................	1–8
Technical specifications......................................................................................................................................	1–11
Transceiver general specifications ...............................................................................................................	1–11
Main RF characteristics for triple-band (EGSM900/GSM1800/GSM1900) and WCDMA phones ................	1–11
Operating times..............................................................................................................................................	1–12
Environmental conditions .............................................................................................................................	1–12
List of Tables
Table 1 Audio ..........................................................................................................................................................	1–8
Table 2 Car...............................................................................................................................................................	1–9
Table 3 Carrying...................................................................................................................................................	1–10
Table 4 Data .........................................................................................................................................................	1–10
Table 5 Messaging...............................................................................................................................................	1–10
Table 6 Power ......................................................................................................................................................	1–10
Table 7 Environmental conditions.....................................................................................................................	1–12
List of Figures
Figure 1 View of RM-156........................................................................................................................................	1–5

Issue 1	COMPANY CONFIDENTIAL	Page 1 –3
	Copyright © 2007 Nokia. All rights reserved.

	RM-156
Nokia Customer Care	General Information

(This page left intentionally blank.)

Page 1 –4	COMPANY CONFIDENTIAL	Issue 1
	Copyright © 2007 Nokia. All rights reserved.

RM-156
General Information	Nokia Customer Care

RM-156 product selection

RM-156 is a WCDMA/GSM dual mode handportable phone, supporting WCDMA 2100/EGSM 900/1800/1900.

According to GSM standard 05.05 it responds to class 4 (max. 2 W) in EGSM900, class 1 (1 W) in GSM1800 and class 1 in GSM1900. The device supports EGPRS (EDGE) class B as well as Bluetooth 2.0 + EDR (Enhanced Data Rate) standard. The handset has a full phase 2 Type Approval and it complies with the GSM Type Approval.

RM-156 also has a full CE approval and FCC (Federal Communications Commission) approval.

RM-156 supports two-way video calls with two integrated cameras. It is an MMS (Multimedia Messaging Service) enabled phone with a large bright colour display and an integrated 3.0 megapixel rear camera (3x optical zoom) and a CIF digital front camera.

The MMS implementation follows the OMA (Open Mobile Alliance) MMS standard release 1.2.

WAP 2.0 compatible browser supports XHTML Mobile Profile (MP) and uses a TCP/IP stack to communicate with a gateway in network.

RM-156 uses a Symbian 9.1 operating system and support also MIDP (Mobile Information Device Profile) Java 2.0 & CLDC 1.1 (Connected Limited Device Configuration), providing a good platform for 3rd party applications.

Figure 1 View of RM-156

Product features and sales package

Hardware characteristics

•Dual-mode: WCDMA2100/EGSM900/GSM1800/GSM1900 MHz

•Speech Codecs supported: AMR/FR/EFR

Issue 1	COMPANY CONFIDENTIAL	Page 1 –5
	Copyright © 2007 Nokia. All rights reserved.

	RM-156
Nokia Customer Care	General Information

•WCDMA 2100 MHz with simultaneous voice and packet data (PS max speed DL/UL= 384/384kbps, CS max speed 64kpbs)

•Dual Transfer Mode (DTM) support for simultaneous voice and packet data connection in GSM/EDGE networks. Simple class A, multi slot class 11, max data speed to be: 177.6/118.4 kbits/s

•EGPRS class B, multi slot class 32, (5 Rx + 3 Tx / Max Sum 6), max speed DL/UL= 296 / 177.6 kbits/s.

•GPRS class B, multi slot class 32, (5 Rx + 3 Tx / Max Sum 6), max speed DL/UL= 107/64.2 kbits/s.

•3.2 megapixel camera (2048 x 1536) with 3x continuous optical zoom and up to 20x digital zoom; High quality lens solution.

•Stereo microphone.

•LED Flash and red recording indicator LED.

•Sub camera, CIF (352 x 288) sensor.

•Large bright 2.4” QVGA (240 x 320 pixels) TFT colour display with 16.7M colours and wide viewing angle. Ambient light detector - used to optimize display brightness and power consumption

•Sub-display – 1.1” PM-OLED colour display (128x36), 65,536 colours.

•Keys : ITU numeric keys, Send/End keys, S60 keys (Application, Edit, Clear, 5-way navi key), Operator/ Multimedia key, Left/Right selection keys, Upper/Lower Landscape selection keys, Shutter key, Zoom key, Side 5-way navi key, Camera mode key, Flash key, Power key.

•50 Mbytes internal user memory

•Internal antennas

•Integrated handsfree speaker

•Vibrator

•Stereo FM radio

•(U)SIM chip slot (1.8 and 3.0 V)

•TV output support (PAL/NTSC)

•miniSD memory card support (hot swappable)

•Pop-Port™ interface with USB 2.0 connectivity

•WLAN - IEEE802.11 g /b

•Bluetooth wireless technology 2.0

•Infrared

Software platform

•Symbian 9.1

•Nokia Series 60 3.0 User Interface : C++ and Java SDKs

User interface

•Imaging

•Capture

•Video: Record DVD-like MPEG-4 VGA 30 fps movies with stereo audio and stabilization.

•Photos: Take high quality 3.2 megapixel pictures. User settings for Scene, Flash, White Balance, Exposure and Colour tone. Self timer support.

•Sequence mode: Capture 6 pictures in 2 seconds.

•Edit

•Photo editor

Page 1 –6	COMPANY CONFIDENTIAL	Issue 1
	Copyright © 2007 Nokia. All rights reserved.

RM-156
General Information	Nokia Customer Care

•Video editor

•View

•Slideshow from Gallery

•Show photo and videos on TV

•Share

•Sending via Bluetooth, Infrared, MMS, e-mail

•Online Album : Image/Video uploading from Gallery

•Print

•Nokia XpressPrint – direct printing from phone, memory card or via online album.

•Store

•Gallery with album support

•Nokia Lifeblog

•Messaging

•• Multimedia Messaging

•Concatenated SMS (MO/MT)

•E-mail (SMTP, IMAP4, POP3)

•Predictive text input

•Music

•Music player : Supports MP3/AAC/WMA with playlists

•Stereo FM radio + Visual radio support

•PIM

•Contacts, Calendar, To-do, Notes

•Recorder, Calculator, Clock, Converter

•Synchronization

•Local/Remote (using SyncML)

•Data: Calendar, Contacts, To-do, Notes, E-mail

•PC Applications: Microsoft Outlook (98, 2000, 2002, 2003), Outlook Express, Lotus Organizer (5.0, 6.0), Lotus Notes (5.0, 6.0)

•Phone

•3GPP Rel ’99 compliant

•Voice dialling (Flexible SIND)

•Voice commands

•Push to Talk (PoC)

•Java: MIDP2.0

•Browser : full web browser

•Personalization

•Themes

•SP-MIDI (64 polyphonics), True Tones

•Location based services

•MT-LR Control Plane Cell-Id Positioning with DTAP LCS Location Notification

Issue 1	COMPANY CONFIDENTIAL	Page 1 –7
	Copyright © 2007 Nokia. All rights reserved.

	RM-156
Nokia Customer Care	General Information

Sales package

•Transceiver with lens cover

•BL-5F li-ion battery cell

•Mini-SD memory card (1GB)

•CA-53 connectivity cable (USB)

•CA-64U video out cable

•AC-4 travel charger

•CP-83 carrying case

•CP-84 wrist strap

•HS-23 stereo headset

•User guide, Quick start guide, and add-on application guide

•DVD-ROM (with PC Suite and other applications)

Mobile enhancements

	Table 1 Audio
Enhancement		Type
Headsets
Wireless Headset		HS-11W
		HS-26W
		HS-37W
		HDW-3
		BH-300 (HS-50W)
		HS-36W
Wireless Clip-on Headset		HS-21W
Wireless Image Headset		HS-13W
Wireless Boom Headset		HS-4W
Bluetooth Headset		BH-800 (HS-24W)
		BH-900 (HS-25W)
		BH-700(HS-57W)
		BH-200 (HS-58W)
		BH-600(HS-59W)
		BH-301 (HS-51W) PR2
		BH-302 (HS-73W)
		BH-202 (HS-38W)
		BH-801 (HS-64W) PR2
		BH-500 (HS-39W) PR2
		BH-501 (HS-71W)

Page 1 –8	COMPANY CONFIDENTIAL	Issue 1
	Copyright © 2007 Nokia. All rights reserved.

RM-156
General Information				Nokia Customer Care
Enhancement		Type
Wireless Stereo Headset		HS-12W (PR-2)
		HS-34W (PR-2)
Boom Headset		HDB-4
Headset		HS-5
Activity Stereo Headset		HS-8
Stereo Headset		HS-23
		HDS-3
Stereo Fashion Headset		HS-3
Activity Stereo Headset		HS-29
Display Headset		HS-6
Music Headset		HS-20
Fashion Stereo Headset		HS-31
Stereo Headset		HDS-3
Music Display Headset		HS-69
Other
Music Stand		MD-1
Audio Adapter		AD-15
		AD-46
Inductive Loopset		LPS-4
Mini Speaker		MD-4
	Table 2 Car
Enhancement		Type
Car kits
Advanced Car Kit	CK-7W
	CK-20W
Wireless Car Kit	CK-1W
Car Kit	N616
Other car enhancements
Mobile Charger	DC-4
Headrest Handsfree	BHF-3
Wireless Plug-in Car Handsfree	HF-3
	HF-6W
	HF-35W
	HF-33W (PR2)

Issue 1	COMPANY CONFIDENTIAL	Page 1 –9
	Copyright © 2007 Nokia. All rights reserved.

					RM-156
Nokia Customer Care					General Information
Enhancement		Type
Universal Mobile Holder		CR-39
Wireless GPS Module		LD-3W
GPS module		LD-2
		Table 3 Carrying
Enhancement		Type
Carrying case		CP-83
Wrist strap		CP-84
		Table 4 Data
Enhancement		Type
Connectivity Cable		CA-53
Video out cable		CA-64U
Charging Data Cable		CA-70
Wireless GPS Module		LD-1W
Memory Cards		Mini SD 64MB
		Mini-SD 128MB
		Mini-SD 256MB
		Mini-SD 512MB
		Mini-SD 1GB
		Mini SD 2GB MU-36
TTY Adapter		HDA-10
	Table 5 Messaging
Enhancement		Type
Wireless Keyboard		SU-8W
Digital Pen		SU-1B
		SU-27W
		Table 6 Power
Enhancement		Type
Chargers
Travel Charger		AC-4
		AC-5
Compact charger		AC-3
Page 1 –10	COMPANY CONFIDENTIAL				Issue 1
	Copyright © 2007 Nokia. All rights reserved.

RM-156
General Information		Nokia Customer Care
Enhancement	Type
Charging Adapter	CA-44
Batteries
Battery	BL-5F

Technical specifications

Transceiver general specifications

Unit	Dimensions (L x W x T)	Weight (g)	Volume (cm3)
Transceiver with BL-5F	46.2 x 40 x 5.4	21	9.98
950 mAh li-ion battery
back

Main RF characteristics for triple-band (EGSM900/GSM1800/GSM1900) and WCDMA phones

Parameter	Unit
Cellular system	EGSM900, GSM1800/1900 and WCDMA
Rx frequency band	EGSM900: 925 - 960 MHz
	GSM1800: 1805 - 1880 MHz
	GSM1900: 1930 - 1990 MHz
	WCDMA: 2110 - 2170 MHz
Tx frequency band	EGSM900: 880 - 915 MHz
	GSM1800: 1710 - 1785 MHz
	GSM1900: 1850 - 1910 MHz
	WCDMA: 1920 - 1980 MHz
Output power	GSM900: +5 … +33dBm/3.2mW … 2W
	GSM1800: +0 … +30dBm/1.0mW … 1W
	GSM1900: +0 … +30dBm/1.0mW … 1W
	WCDMA -50 … 21 dBm
Number of RF channels	GSM900: 125
	GSM1800: 375
	GSM1900: 300
	WCDMA: 277
Channel spacing	200 kHz
Number of Tx power levels	GSM900: 15
	GSM1800: 16
	GSM1900: 16

Issue 1	COMPANY CONFIDENTIAL	Page 1 –11
	Copyright © 2007 Nokia. All rights reserved.

	RM-156
Nokia Customer Care	General Information

Operating times

Battery	Talk time	Stand-by	Still	Video	Video call	Video	Music
			Images	capture	talk time	playback	playback
						time	time
BL-5F	3.1 - 3.9	9.3 - 11.8	up to 291	up to 112	up to 107	up to 205	up to 6.3
950 mAh	hrs (GSM)	days (GSM)	pictures	min (VGA,	min	min (VGA,	hours
				30fps)		30fps)	(offline
	1.7 - 3.3	7.8 - 9.4	(3M, flash
							mode)
	hrs	days	off)
	(WCDMA )	(WCDMA)

Note: Operating times with in-box battery. Variation in operation times will occur depending on SIM card, network settings and usage.

Charging times

AC-4

1 h 15 min

Environmental conditions

Table 7 Environmental conditions

Environmental	Ambient temperature	Notes
condition
Normal operation	-15oC...+55oC	Specifications fulfilled
Reduced performance	-20oC...-15oC	Main camera performance reduced.
	+35oC...+55oC
Charging allowed	-25oC...+50oC
Long term storage	0oC...+85oC
conditions

Page 1 –12	COMPANY CONFIDENTIAL	Issue 1
	Copyright © 2007 Nokia. All rights reserved.

Nokia Customer Care

2 — Parts Lists and Component

Layouts

Issue 1	COMPANY CONFIDENTIAL	Page 2 –1
	Copyright © 2007 Nokia. All rights reserved.

	RM-156
Nokia Customer Care	Parts Lists and Component Layouts

(This page left intentionally blank.)

Page 2 –2	COMPANY CONFIDENTIAL	Issue 1
	Copyright © 2007 Nokia. All rights reserved.

RM-156
Parts Lists and Component Layouts	Nokia Customer Care

Table of Contents
Spare parts overview and exploded view............................................................................................................	2–5
Mechanical spare parts list ....................................................................................................................................	2–6
Component parts lists and layouts .......................................................................................................................	2–8
Engine PWB component parts list ...................................................................................................................	2–8
Engine PWB component layouts...................................................................................................................	2–28
UI PWB component parts list ........................................................................................................................	2–30
UI PWB component layout.............................................................................................................................	2–31
Flip PWB component parts list......................................................................................................................	2–32
Flip PWB component layouts ........................................................................................................................	2–34
Mic PWB component parts list ......................................................................................................................	2–35
Mic PWB component layout ..........................................................................................................................	2–36
List of Tables
Table 8 Component parts list 1UV_060a ..............................................................................................................	2–8
Table 9 Component parts list 1UX_030a............................................................................................................	2–30
Table 10 Component parts list 1UY_0301a .......................................................................................................	2–32
Table 11 Component parts list 1YQ_030a .........................................................................................................	2–35
List of Figures
Figure 2 Component layout - Bottom (1UV_060a) ...........................................................................................	2–28
Figure 3 Component layout - Top (1UV_060a)..................................................................................................	2–29
Figure 4 Component layout - Top (1UX_030a)..................................................................................................	2–31
Figure 5 Component layout - Bottom (1UY_0301a) .........................................................................................	2–34
Figure 6 Component layout - Top (1UY_0301a)................................................................................................	2–35
Figure 7 Component layout - Top (1YQ_030a)..................................................................................................	2–36

Issue 1	COMPANY CONFIDENTIAL	Page 2 –3
	Copyright © 2007 Nokia. All rights reserved.

	RM-156
Nokia Customer Care	Parts Lists and Component Layouts

(This page left intentionally blank.)

Page 2 –4	COMPANY CONFIDENTIAL	Issue 1
	Copyright © 2007 Nokia. All rights reserved.

RM-156
Parts Lists and Component Layouts	Nokia Customer Care

Spare parts overview and exploded view

Issue 1	COMPANY CONFIDENTIAL	Page 2 –5
	Copyright © 2007 Nokia. All rights reserved.

	RM-156
Nokia Customer Care	Parts Lists and Component Layouts

Mechanical spare parts list

Note: For Nokia product codes, please refer to the latest Service Bulletins on the Partner Website (PWS). To ensure you are always using the latest codes, please check the PWS on a daily basis.

	ITEM/ CIRCUIT	QTY	SPARE PART DESCRIPTION
	REF.
	A1	1	FLIP A-COVER ASSY (I001 - I003)
	I001	1	FLIP A-COVER
	I002	1	FLIP SOFT KEYMAT
	I003	1	EARPIECE GASKET
	I004	1	EARPIECE
	I005	1	MAIN LCD
	A2	1	FLIP FRAME ASSY (I006 - I007)
	I006	1	CMOS CAMERA
	I007	1	1 UY FLIP PWB FLEX
	I008	1	SUB LCD
	I009	1	FLIP B-COVER
	I010	4	SCREW M1.7 x 3.1
	I011	2	SCREW M1.8x2.7
	I012	1	SUB LCD WINDOW ASSY
	A3	1	HINGE CAPTURE ASSY (I101 - I107)
	I101	1	CAPTURE KEY COVER PAINTED
	I102	1	CAPTURE KEY BUTTON SPUTTERING
	I103	1	ZOOM KEY LEVER PAINTED
	I104	1	CAPTURE RETURN SPRING
	I105	1	HINGE ASSEMBLY
	I106	1	CAPTURE KEY INNER COVER
	I107	1	ADHESIVE FOR DETECTOR SWITCH
	I108	2	SCREW M2X3.7 TORX PLUS 6
	I109	1	CABLE ASSY
	I110	1	CAMERA MODULE
	I111	1	CAMERA SUPPORT FRAME ASSY
	I112	1	CAMERA BEZEL
	I113	1	LENS CAP ASSY
	I201	1	KEYMAT

Page 2 –6	COMPANY CONFIDENTIAL	Issue 1
	Copyright © 2007 Nokia. All rights reserved.

RM-156
Parts Lists and Component Layouts			Nokia Customer Care
ITEM/ CIRCUIT	QTY	SPARE PART DESCRIPTION
REF.
A4	1	GRIP A-COVER ASSY (I202 - I205, I211, A5, A6)
I202	1	GRIP A-COVER
I203	1	PILLOW
I204	1	GRIP BUMPER A ADHESIVE
I205	1	GRIP BUMPER A
A5	1	UI ASSY (I206 - I210)
I206	1	EL DOMESHEET ASSY
I207	1	JOYSTICK
I208	1	SIDEKEY DOME SWITCH
I209	1	JOYSTICK HAT
I210	1	MICROPHONE
I211	1	CONN 2mm DC-JACK
A6	1	DIGITAL MIC ASSY (I212 - I213)
I212	2	MIC
I213	1	POWER KEY DOME SWITCH
A7	1	1UV LIGHT SWAP PACKAGE (I214 - I221)
I214	1	BB OMAP SHIELD LID
I215	1	BB CAMERA SHIELD LID
I216	1	RF WLAN SHIELD LID
I217	1	BB FLASH SHIELD LID
I218	1	RF LID
I219	1	1UV ENGINE MODULE
I220	1	WCDMA LID (RM-156 only)
I221	1	TYPE LABEL
I222	1	LABEL PLATE
A8	1	ANTENNA ASSY (I223 - I224)
I223	1	ANTENNA
I224	1	IHF SPEAKER
I225	1	GRIP INNER FRAME
I226	1	CABLE CLAMP
I227	1	CAMERA GROUND CLIP
I228	1	SIM SHIELD COVER
I229	1	SIM INSULATOR PRINTED

Issue 1	COMPANY CONFIDENTIAL	Page 2 –7
	Copyright © 2007 Nokia. All rights reserved.

				RM-156
Nokia Customer Care			Parts Lists and Component Layouts
ITEM/ CIRCUIT		QTY	SPARE PART DESCRIPTION
REF.
I230		1	GIF GND CLIP
I231		1	CUSHION BT
A9		1	GRIP B-COVER ASSY (I232 - I235)
I232		1	GRIP B-COVER
I233		1	BT/WLAN ANTENNA
I234		1	ORNAMENT B
I235		1	SD HATCH
I236		1	POP-PORT HATCH
I237		1	ORNAMENT L ASSY (incl. Adhesive)
I238		1	ORNAMENT R ASSY
I239		1	SIDE KEYMAT
I240		4	SCREW RF 1.8X9
I241		1	GRIP C-COVER ASSY

Component parts lists and layouts

Engine PWB component parts list

Table 8 Component parts list 1UV_060a

Note: For Nokia product codes, please refer to the latest Service Bulletins on the Partner Website (PWS). To ensure you are always using the latest codes, please check the PWS on a daily basis.

Item	Side		Grid ref.		Type	Description and value
					SHIELD_040_0136
A1	Top	G		7	93	RF SHIELD ASSEMBLY	~	~
						WCDMA-SHIELD
A2	Top	G		4	SHIELD_WCDMA	ASSEMBLY	~	~
					SHIELD_040_0230	RF WLAN SHIELD ASSY
A3	Bot	F		12	57	040-023057	~	~
					SHIELD_040_0230	BB OMAP SHIELD ASSY
A4	Top	F		14	51	040-023051	~	~
					SHIELD_040_0230	BB FLASH SHIELD ASSY
A5	Bot	D		14	54	040-023054	~	~
					SHIELD_040_0230	BB CAMERA SHELD ASSY
A6	Bot	I		14	48	040-023048	~	~
						CLAPTON EMC
					MIC_OBE_415S42_	MICROPHONE MOD
B8100	Top	D		3	RC3310CL	-42DB	~	~
						CHIPCAP X5R 100N K
C1001	Top	F		15	0402C_H0.6	16V 0402	100n	16V

Page 2 –8	COMPANY CONFIDENTIAL	Issue 1
	Copyright © 2007 Nokia. All rights reserved.