Nokia Customer Care
Service Manual
RM-180 (Nokia N72)
Mobile Terminal
Part No: 9250815 (Issue 1)
COMPANY CONFIDENTIAL
Copyright © 2006 Nokia. All rights reserved.
|
RM-180 |
Nokia Customer Care |
Amendment Record Sheet |
Amendment Record Sheet
Amendment No |
Date |
Inserted By |
Comments |
Issue 1 |
05/2006 |
Merja Hautaniemi |
|
|
|
|
|
Page ii |
COMPANY CONFIDENTIAL |
Issue 1 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
RM-180 |
|
Copyright |
Nokia Customer Care |
Copyright
Copyright © 2006 Nokia. All rights reserved.
Reproduction, transfer, distribution or storage of part or all of the contents in this document in any form without the prior written permission of Nokia is prohibited.
Nokia, Nokia Connecting People, and Nokia X and Y are trademarks or registered trademarks of Nokia Corporation. Other product and company names mentioned herein may be trademarks or tradenames of their respective owners.
Nokia operates a policy of continuous development. Nokia reserves the right to make changes and improvements to any of the products described in this document without prior notice.
Under no circumstances shall Nokia be responsible for any loss of data or income or any special, incidental, consequential or indirect damages howsoever caused.
The contents of this document are provided "as is". Except as required by applicable law, no warranties of any kind, either express or implied, including, but not limited to, the implied warranties of merchantability and fitness for a particular purpose, are made in relation to the accuracy, reliability or contents of this document. Nokia reserves the right to revise this document or withdraw it at any time without prior notice.
The availability of particular products may vary by region.
IMPORTANT
This document is intended for use by qualified service personnel only.
Issue 1 |
COMPANY CONFIDENTIAL |
Page iii |
|
Copyright © 2006 Nokia. All rights reserved. |
|
|
RM-180 |
Nokia Customer Care |
Warnings and cautions |
Warnings and cautions
Warnings
•IF THE DEVICE CAN BE INSTALLED IN A VEHICLE, CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH ELECTRONIC ENGINE MANAGEMENT SYSTEMS AND ANTI-SKID BRAKING SYSTEMS. UNDER CERTAIN FAULT CONDITIONS, EMITTED RF ENERGY CAN AFFECT THEIR OPERATION. IF NECESSARY, CONSULT THE VEHICLE DEALER/ MANUFACTURER TO DETERMINE THE IMMUNITY OF VEHICLE ELECTRONIC SYSTEMS TO RF ENERGY.
•THE PRODUCT MUST NOT BE OPERATED IN AREAS LIKELY TO CONTAIN POTENTIALLY EXPLOSIVE ATMOSPHERES, FOR EXAMPLE, PETROL STATIONS (SERVICE STATIONS), BLASTING AREAS ETC.
•OPERATION OF ANY RADIO TRANSMITTING EQUIPMENT, INCLUDING CELLULAR TELEPHONES, MAY INTERFERE WITH THE FUNCTIONALITY OF INADEQUATELY PROTECTED MEDICAL DEVICES. CONSULT A PHYSICIAN OR THE MANUFACTURER OF THE MEDICAL DEVICE IF YOU HAVE ANY QUESTIONS. OTHER ELECTRONIC EQUIPMENT MAY ALSO BE SUBJECT TO INTERFERENCE.
•BEFORE MAKING ANY TEST CONNECTIONS, MAKE SURE YOU HAVE SWITCHED OFF ALL EQUIPMENT.
Cautions
•Servicing and alignment must be undertaken by qualified personnel only.
•Ensure all work is carried out at an anti-static workstation and that an anti-static wrist strap is worn.
•Ensure solder, wire, or foreign matter does not enter the telephone as damage may result.
•Use only approved components as specified in the parts list.
•Ensure all components, modules, screws and insulators are correctly re-fitted after servicing and alignment.
•Ensure all cables and wires are repositioned correctly.
•During testing never activate the GSM transmitter without a proper antenna load, otherwise the GSM PA may be damaged.
Page iv |
COMPANY CONFIDENTIAL |
Issue 1 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
RM-180 |
|
ESD protection |
Nokia Customer Care |
ESD protection
Nokia requires that service points have sufficient ESD protection (against static electricity) when servicing the phone.
Any product of which the covers are removed must be handled with ESD protection. The SIM card can be replaced without ESD protection if the product is otherwise ready for use.
To replace the covers ESD protection must be applied.
All electronic parts of the product are susceptible to ESD. Resistors, too, can be damaged by static electricity discharge.
All ESD sensitive parts must be packed in metallized protective bags during shipping and handling outside any ESD Protected Area (EPA).
Every repair action involving opening the product or handling the product components must be done under ESD protection.
ESD protected spare part packages MUST NOT be opened/closed out of an ESD Protected Area.
For more information and local requirements about ESD protection and ESD Protected Area, contact your local Nokia After Market Services representative.
Issue 1 |
COMPANY CONFIDENTIAL |
Page v |
|
Copyright © 2006 Nokia. All rights reserved. |
|
|
RM-180 |
Nokia Customer Care |
Care and maintenance |
Care and maintenance
This product is of superior design and craftsmanship and should be treated with care. The suggestions below will help you to fulfil any warranty obligations and to enjoy this product for many years.
•Keep the phone and all its parts and accessories out of the reach of small children.
•Keep the phone dry. Precipitation, humidity and all types of liquids or moisture can contain minerals that will corrode electronic circuits.
•Do not use or store the phone in dusty, dirty areas. Its moving parts can be damaged.
•Do not store the phone in hot areas. High temperatures can shorten the life of electronic devices, damage batteries, and warp or melt certain plastics.
•Do not store the phone in cold areas. When it warms up (to its normal temperature), moisture can form inside, which may damage electronic circuit boards.
•Do not drop, knock or shake the phone. Rough handling can break internal circuit boards.
•Do not use harsh chemicals, cleaning solvents, or strong detergents to clean the phone.
•Do not paint the phone. Paint can clog the moving parts and prevent proper operation.
•Use only the supplied or an approved replacement antenna. Unauthorised antennas, modifications or attachments could damage the phone and may violate regulations governing radio devices.
All of the above suggestions apply equally to the product, battery, charger or any accessory.
Page vi |
COMPANY CONFIDENTIAL |
Issue 1 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
RM-180 |
|
Company Policy |
Nokia Customer Care |
Company Policy
Our policy is of continuous development; details of all technical modifications will be included with service bulletins.
While every endeavour has been made to ensure the accuracy of this document, some errors may exist. If any errors are found by the reader, NOKIA MOBILE PHONES Business Group should be notified in writing/e- mail.
Please state:
•Title of the Document + Issue Number/Date of publication
•Latest Amendment Number (if applicable)
•Page(s) and/or Figure(s) in error
Please send to:
NOKIA CORPORATION
Nokia Mobile Phones Business Group
Nokia Customer Care
PO Box 86
FIN-24101 SALO
Finland
E-mail: Service.Manuals@nokia.com
Issue 1 |
COMPANY CONFIDENTIAL |
Page vii |
|
Copyright © 2006 Nokia. All rights reserved. |
|
|
RM-180 |
Nokia Customer Care |
Battery information |
Battery information
Note: A new battery's full performance is achieved only after two or three complete charge and discharge cycles!
The battery can be charged and discharged hundreds of times but it will eventually wear out. When the operating time (talk-time and standby time) is noticeably shorter than normal, it is time to buy a new battery.
Use only batteries approved by the phone manufacturer and recharge the battery only with the chargers approved by the manufacturer. Unplug the charger when not in use. Do not leave the battery connected to a charger for longer than a week, since overcharging may shorten its lifetime. If left unused a fully charged battery will discharge itself over time.
Temperature extremes can affect the ability of your battery to charge.
For good operation times with Ni-Cd/NiMh batteries, discharge the battery from time to time by leaving the product switched on until it turns itself off (or by using the battery discharge facility of any approved accessory available for the product). Do not attempt to discharge the battery by any other means.
Use the battery only for its intended purpose. Never use any charger or battery which is damaged.
Do not short-circuit the battery. Accidental short-circuiting can occur when a metallic object (coin, clip or pen) causes direct connection of the + and - terminals of the battery (metal strips on the battery) for example when you carry a spare battery in your pocket or purse. Short-circuiting the terminals may damage the battery or the connecting object.
Leaving the battery in hot or cold places, such as in a closed car in summer or winter conditions, will reduce the capacity and lifetime of the battery. Always try to keep the battery between 15°C and 25°C (59°F and 77° F). A phone with a hot or cold battery may temporarily not work, even when the battery is fully charged.
Batteries' performance is particularly limited in temperatures well below freezing. Do not dispose of batteries in a fire!
Dispose of batteries according to local regulations (e.g. recycling). Do not dispose as household waste.
Page viii |
COMPANY CONFIDENTIAL |
Issue 1 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
RM-180 |
|
Nokia N72 Service Manual Structure |
Nokia Customer Care |
Nokia N72 Service Manual Structure
1 General Information
2 Parts Lists and Component Layouts
3 Service Software Instructions
4 Service Tools and Service Concepts
5 Disassembly/Reassembly Instructions
6 BB Troubleshooting and Tuning Guide
7 RF Troubleshooting and Tuning Guide
8 Camera Module Troubleshooting
9 System Module
10 Schematics
Glossary
Issue 1 |
COMPANY CONFIDENTIAL |
Page ix |
|
Copyright © 2006 Nokia. All rights reserved. |
|
|
RM-180 |
Nokia Customer Care |
Nokia N72 Service Manual Structure |
(This page left intentionally blank.)
Page x |
COMPANY CONFIDENTIAL |
Issue 1 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
Nokia Customer Care
1 — General Information
Issue 1 |
COMPANY CONFIDENTIAL |
Page 1 –1 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
|
RM-180 |
Nokia Customer Care |
General Information |
(This page left intentionally blank.)
Page 1 –2 |
COMPANY CONFIDENTIAL |
Issue 1 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
RM-180 |
|
General Information |
Nokia Customer Care |
Table of Contents
Product selection.................................................................................................................................................... |
1–5 |
RM-180 product features and sales package....................................................................................................... |
1–5 |
Mobile enhancements............................................................................................................................................ |
1–6 |
Technical specifications......................................................................................................................................... |
1–8 |
Transceiver general specifications.................................................................................................................. |
1–8 |
Main RF characteristics for triple-band phones.............................................................................................. |
1–8 |
Battery endurance............................................................................................................................................. |
1–9 |
Environmental conditions................................................................................................................................ |
1–9 |
List of Tables |
|
Table 1 Audio.......................................................................................................................................................... |
1–6 |
Table 2 Car............................................................................................................................................................... |
1–7 |
Table 3 Carrying...................................................................................................................................................... |
1–7 |
Table 4 Data............................................................................................................................................................ |
1–7 |
Table 5 Imaging...................................................................................................................................................... |
1–8 |
Table 6 Messaging.................................................................................................................................................. |
1–8 |
Table 7 Power......................................................................................................................................................... |
1–8 |
List of Figures |
|
Figure 1 View of RM-180........................................................................................................................................ |
1–5 |
Issue 1 |
COMPANY CONFIDENTIAL |
Page 1 –3 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
|
RM-180 |
Nokia Customer Care |
General Information |
(This page left intentionally blank.)
Page 1 –4 |
COMPANY CONFIDENTIAL |
Issue 1 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
RM-180 |
|
General Information |
Nokia Customer Care |
Product selection
RM-180 is a tri-band GSM phone, supporting EGSM900/1800/1900 bands.
According to GSM standard 05.05 it responds to class 4 (max. 2 W) in EGSM 900, class 1 (1 W) in GSM 1800 and class 1 in GSM 1900. The device supports EGPRS (EDGE) class B as well as Bluetooth 2.0 + EDR (Enhanced Data Rate) standard. The handset has a full phase 2 Type Approval and it complies with the GSM Type Approval.
RM-180 also has a full CE approval and FCC (Federal Communications Commission) approval.
RM-180 is an MMS (Multimedia Messaging Service) enabled phone with a large bright colour display and an integrated 2.0 megapixel rear camera.
The MMS implementation follows the OMA (Open Mobile Alliance) MMS standard release 1.2.
WAP 2.0 compatible browser supports XHTML Mobile Profile (MP) and uses a TCP/IP stack to communicate with a gateway in network.
RM-180 use a Symbian 8.0a operating system and support also MIDP (Mobile Information Device Profile) Java 2.0 & CLDC 1.1 (Connected Limited Device Configuration), providing a good platform for 3rd party applications.
Figure 1 View of RM-180
RM-180 product features and sales package
Imaging and video
•2 megapixel camera (1600 x 1200 pixels) with 20x digital zoom
•Dedicated shutter key and camera activation slide
•Integrated flash (operating range up to 1.5 m)
•Flash modes: on, off, automatic, and anti red-eye
•Advanced camera modes: still, sequence, video
Issue 1 |
COMPANY CONFIDENTIAL |
Page 1 –5 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
|
RM-180 |
Nokia Customer Care |
General Information |
•Six possible capture scene settings including scenery, portrait, night and sports
•Settings, brightness adjustment, image quality, self-timer, white balance settings and colour tones
•Video and still image editors
•Movie Director for automated video production
Bearers & transport
•GPRS class B, multislot class 10
•EGPRS multislot class 10
•USB 2.0
•Bluetooth 2.0
Software platform
•Nokia Series 60 release 2.8
•Symbian 8.1
Connectivity
•Integrated Bluetooth wireless technology v.2.0
•USB 2.0 full speed via Pop-Port™ interface
•Nokia PC Suite connectivity via USB and Bluetooth wireless technology
•Local synchronisation of contacts and calendar to a compatible PC using compatible connection
•Remote over-the-air synchronisation
•Send and receive images, video clips, graphics, and business cards via Bluetooth wireless technology
•Profiles with Bluetooth connectivity: Basic Printing Profile (BPP) using Image Print or Info Print applications, Human Interface Device Profile (HID) using Nokia Wireless Keyboard application
Sales package
• RM-180 transceiver
• HS-3 stereo headset
• CA-53 USB connectivity cable
• MU-1 RS-MMC 64 MB with adapter
• BL-5C Li-ion battery cell
• AC-3 charger
• User guide
• CD-ROM (with PC-Suite)
• Carry strap
Mobile enhancements
Table 1 Audio
Enhancement |
|
|
Type |
Boom mono headset |
|
HDB-4 |
|
|
|
|
|
Fashion stereo headset |
|
HS-3 |
|
|
|
|
|
Mono headset |
|
HS-5 |
|
|
|
|
|
|
|
|
|
Page 1 –6 |
COMPANY CONFIDENTIAL |
Issue 1 |
|
Copyright © 2006 Nokia. All rights reserved.
RM-180 |
|
General Information |
Nokia Customer Care |
|
|
Enhancement |
Type |
Stereo headset |
HDS-3 |
|
|
Inductive loopset |
LPS-4 |
|
|
Wireless headset |
HDW-3 |
|
|
|
HS-4W |
|
|
|
HS-11W |
|
|
Wireless clip-on headset |
HS-21W |
|
|
Wireless image headset |
HS-13W |
|
|
Audio adapter |
AD-15 |
|
|
TTY adapter |
HDA-10 |
|
|
Music stand |
MD-1 |
|
|
|
Table 2 Car |
||
|
|
|
|
Enhancement |
|
|
Type |
Mobile charger |
|
|
DC-4 |
|
|
|
|
Headrest handsfree |
|
|
BHF-3 |
|
|
|
|
Basic handsfree |
|
|
HF-3 |
|
|
|
|
Advanced car kit (sales pack) |
|
|
CK-7W |
|
|
|
|
Wireless car kit |
|
|
CK-1W |
|
|
|
|
Wireless plug-in car handsfree |
|
|
HF-6W |
|
|
|
|
Universal holder |
|
|
CR-39 |
|
|
|
|
|
Table 3 Carrying |
||
|
|
|
|
Enhancement |
|
|
Type |
Carrying case |
|
CNT-676 |
|
|
|
|
|
|
Table 4 Data |
||
|
|
|
|
Enhancement |
|
|
Type |
USB data cable |
|
DKU-2 |
|
|
|
|
|
Connectivity cable |
|
CA-53 |
|
|
|
|
|
Wireless GPS module |
|
LD-1W |
|
|
|
|
|
RS multimedia card 64 MB |
|
MU-1 |
|
|
|
|
|
RS multimedia card 128 MB |
|
MU-2 |
|
|
|
|
|
RS multimedida card 256 MB |
|
MU-9 |
|
|
|
|
|
RS multimedia card 512 MB |
|
MU-12 |
|
|
|
|
|
Issue 1 |
COMPANY CONFIDENTIAL |
Page 1 –7 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
|
|
RM-180 |
Nokia Customer Care |
|
General Information |
|
Table 5 Imaging |
|
|
|
|
Enhancement |
|
Type |
Nokia image album |
|
PD-1 |
|
|
|
Nokia remote camera |
|
PT-6 |
|
|
|
|
Table 6 Messaging |
|
|
|
|
Enhancement |
|
Type |
Nokia digital pen |
|
SU-1B |
|
|
|
Bluetooth QWERTY keypad |
|
SU-8W |
|
|
|
|
Table 7 Power |
|
|
|
|
Enhancement |
|
Type |
Battery 970mAh Li-ion |
|
BL-5C |
|
|
|
Compact charger |
|
AC-3 |
|
|
|
Travel charger |
|
AC-4 |
|
|
|
Charging adapter |
|
CA-44 |
|
|
|
Technical specifications
Transceiver general specifications
Unit |
Dimensions (L x W x T) |
Weight (g) |
Volume (cm3) |
|
(mm) |
|
|
Transceiver with BL-5C |
108.8 x 53 x 21.8 |
126 |
95.9 |
900mAh li-ion battery |
|
|
|
back |
|
|
|
|
|
|
|
Main RF characteristics for triple-band phones
Parameter |
|
Unit |
|
Cellular system |
|
GSM/EGSM900,GSM1800/1900 |
|
|
|
|
|
Rx frequency band |
|
EGSM900: 925 - 935 MHz |
|
|
|
|
|
|
|
GSM900: 935 - 960MHz |
|
|
|
|
|
|
|
GSM1800: 1805 - 1880 MHz |
|
|
|
|
|
|
|
GSM1900: 1930 - 1990 MHz |
|
|
|
|
|
Tx frequency band |
|
EGSM900: 880 - 890MHz |
|
|
|
|
|
|
|
GSM900: 890 - 915MHz |
|
|
|
|
|
|
|
GSM1800: 1710 - 1785 MHz |
|
|
|
|
|
|
|
GSM1900: 1850 - 1910 MHz |
|
|
|
|
|
|
|
|
|
Page 1 –8 |
COMPANY CONFIDENTIAL |
Issue 1 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
||
RM-180 |
|
General Information |
Nokia Customer Care |
|
|
Parameter |
Unit |
Output power |
GSM900: +5 … +33dBm/3.2mW … 2W |
|
|
|
GSM1800: +0 … +30dBm/1.0mW … 1W |
|
|
|
GSM1900: +0 … +30dBm/1.0mW … 1W |
|
|
Number of RF channels |
GSM900: 125 |
|
|
|
GSM1800: 375 |
|
|
|
GSM1900: 300 |
|
|
Channel spacing |
200KHz |
|
|
Number of Tx power levels |
GSM900: 15 |
|
|
|
GSM1800: 16 |
|
|
|
GSM1900: 16 |
|
|
Battery endurance
|
Battery |
|
Capacity (mAh) |
Talk time |
Stand-by |
BL-5C |
|
970 |
|
up to 3.5* hrs |
up to 11* days |
*Variation in operation times will occur depending on the SIM card, network settings and usage. Talk time is increased by up to 30% if half rate is active and reduced by 5% if enhanced full rate is active.
Charging times
AC-4 |
AC-3 |
1 h 15 min |
2 h 45 min |
|
|
Environmental conditions
Environmental condition |
Ambient temperature |
Notes |
Normal operation |
-15oC...+55oC |
Specifications fulfilled |
Reduced performance |
-25oC...-15oC |
Operational for shorts periods |
|
+55oC...+70oC |
only |
|
|
|
Intermittent operation |
-40oC...-15oC |
Operation not guaranteed but an |
|
+70oC...+85 oC |
attempt to operate does not |
|
damage the phone. |
|
|
|
|
|
|
|
No operation or storage |
<-40oC...>+85oC |
No storage or operation: an |
|
|
attempt may damage the phone. |
|
|
|
Charging allowed |
-25oC...+50oC |
|
Long term storage conditions |
0oC...+85oC |
|
Issue 1 |
COMPANY CONFIDENTIAL |
Page 1 –9 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
|
RM-180 |
Nokia Customer Care |
General Information |
(This page left intentionally blank.)
Page 1 –10 |
COMPANY CONFIDENTIAL |
Issue 1 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
Nokia Customer Care
2 — Parts Lists and Component
Layouts
Issue 1 |
COMPANY CONFIDENTIAL |
Page 2 –1 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
|
RM-180 |
Nokia Customer Care |
Parts Lists and Component Layouts |
(This page left intentionally blank.)
Page 2 –2 |
COMPANY CONFIDENTIAL |
Issue 1 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
RM-180 |
|
Parts Lists and Component Layouts |
Nokia Customer Care |
Table of Contents |
|
Exploded view......................................................................................................................................................... |
2–5 |
Spare parts overview............................................................................................................................................. |
2–6 |
Parts lists................................................................................................................................................................. |
2–7 |
Mechanical spare parts list............................................................................................................................... |
2–7 |
Component parts list (1YA_02.1f)..................................................................................................................... |
2–8 |
Component layouts.............................................................................................................................................. |
2–27 |
Component layouts (1YA_02.1f)..................................................................................................................... |
2–27 |
List of Figures |
|
Figure 2 Component layout - bottom view (1YA_02.1f)................................................................................... |
2–27 |
Figure 3 Component layout - top view (1YA_02.1f).......................................................................................... |
2–28 |
Issue 1 |
COMPANY CONFIDENTIAL |
Page 2 –3 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
|
RM-180 |
Nokia Customer Care |
Parts Lists and Component Layouts |
(This page left intentionally blank.)
Page 2 –4 |
COMPANY CONFIDENTIAL |
Issue 1 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
RM-180 |
|
Parts Lists and Component Layouts |
Nokia Customer Care |
Exploded view
Issue 1 |
COMPANY CONFIDENTIAL |
Page 2 –5 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
|
RM-180 |
Nokia Customer Care |
Parts Lists and Component Layouts |
Spare parts overview
Page 2 –6 |
COMPANY CONFIDENTIAL |
Issue 1 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
RM-180 |
|
Parts Lists and Component Layouts |
Nokia Customer Care |
Parts lists
Mechanical spare parts list
Note: For Nokia product codes, please refer to the latest Service Bulletins on the Partner Website (PWS). To ensure you are always using the latest codes, please check the PWS on a daily basis.
Bold = ASSY
ITEM/ CIRCUIT |
QTY |
PART NAME |
|
REF. |
|||
|
|
||
I001 |
1 |
A COVER ASSY |
|
|
|
|
|
I002 |
1 |
MMC DOOR |
|
|
|
|
|
I003 |
1 |
KEYMAT |
|
|
|
|
|
I004 |
6 |
SCREW RF 1.8X9 |
|
|
|
|
|
|
|
|
|
|
1 |
UI FRAME ASSY |
|
|
|
|
|
I005 |
1 |
UI FRAME |
|
|
|
|
|
I006 |
1 |
BEZEL GROUND SPRING |
|
|
|
|
|
I007 |
4 |
LCD GROUND PIN |
|
|
|
|
|
I008 |
1 |
EARPIECE |
|
|
|
|
|
I009 |
1 |
EARPIECE ADHESIVE |
|
|
|
|
|
|
1 |
1NC UI PWB ASSY |
|
|
|
|
|
I010 |
1 |
UI PWB |
|
|
|
|
|
I011 |
1 |
SWITCH |
|
|
|
|
|
I012 |
1 |
DOMESHEET |
|
|
|
|
|
I013 |
1 |
BB SHIELD ASSEMBLY |
|
|
|
|
|
|
|
|
|
I014 |
1 |
LCD AM 176X208 |
|
|
|
|
|
I017 |
1 |
ENGINE MODULE |
|
|
|
|
|
I018 |
1 |
GSM PA SHIELDING LID |
|
|
|
|
|
I020 |
1 |
TAHVO SHIELDING LID |
|
|
|
|
|
I021 |
1 |
HINKU / VINKU SHIELDING LID |
|
|
|
|
|
I022 |
1 |
FLASH SHIELDING LID ASSY |
|
|
|
|
|
I023 |
1 |
CAMERA MODULE 2MP |
|
|
|
|
|
|
|
|
|
|
1 |
CHASSIS ASSY |
|
|
|
|
|
I024 |
1 |
CHASSIS |
|
|
|
|
|
I025 |
1 |
DC JACK 2mm |
|
|
|
|
|
I026 |
1 |
MICROPHONE |
|
|
|
|
|
I027 |
1 |
VIBRA MOTOR |
|
|
|
|
|
I028 |
1 |
IHF SPEAKER |
|
|
|
|
Issue 1 |
COMPANY CONFIDENTIAL |
Page 2 –7 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
|
|
|
RM-180 |
Nokia Customer Care |
Parts Lists and Component Layouts |
||
|
|
|
|
ITEM/ CIRCUIT |
QTY |
PART NAME |
|
REF. |
|
||
|
|
|
|
I029 |
1 |
IHF TOP PAD |
|
|
|
|
|
I030 |
1 |
SLIDE DETECT LEVER |
|
|
|
|
|
I031 |
1 |
SIM FLAP |
|
|
|
|
|
I032 |
1 |
BT ANTENNA ASSY |
|
|
|
|
|
I033 |
1 |
IHF COVER ASSY |
|
|
|
|
|
I034 |
1 |
LED FLASH |
|
|
|
|
|
I035 |
1 |
CAMERA REAR BEZEL ASSY |
|
|
|
|
|
I036 |
1 |
CAMERA REAR BEZEL ADHESIVE |
|
|
|
|
|
|
1 |
ANTENNA ASSY |
|
|
|
|
|
I037 |
1 |
ANTENNA RADIATOR GSM |
|
|
|
|
|
I039 |
1 |
ANTENNA MODULE |
|
|
|
|
|
|
|
|
|
I040 |
1 |
TYPE LABEL |
|
|
|
|
|
I041 |
1 |
ANTENNA COVER |
|
|
|
|
|
I042 |
1 |
POWER BUTTON |
|
|
|
|
|
I043 |
1 |
BATTERY COVER |
|
|
|
|
|
Component parts list (1YA_02.1f)
Item |
Side |
|
Grid ref. |
Type |
Description and value |
|
||
|
|
|
|
|
|
SHIELD ASSEMBLY |
|
|
|
|
|
|
|
SHIELD_ROLF_R |
HINKU/VINKU |
|
|
A7003 |
Bot |
D |
|
10 |
F |
040-010018 |
~ |
~ |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
SHIELD_ROLF_V |
|
|
|
A7004 |
Bot |
B |
|
7 |
CO |
SHIELD ROLF VCO |
~ |
~ |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
SHIELD_ROLF_F |
SHIELD ROLF GSM |
|
|
A7005 |
Bot |
E |
|
12 |
LASH |
FLASH |
~ |
~ |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
SHIELD_ROLF_T |
|
|
|
A7006 |
Bot |
D |
|
6 |
AHVO |
SHIELD ROLF TAHVO |
~ |
~ |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
SHIELD_ROLF_ |
|
|
|
A7008 |
Bot |
H |
|
17 |
GSM_PA |
SHIELD ROLF GSM PA |
~ |
~ |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CRYSTAL_3.3X1 |
CRYSTAL 32.768KHZ |
32.768kH |
|
B2200 |
Top |
D |
|
6 |
.6_H0.9 |
+-20PPM 12.5PF |
z |
~ |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CHIPCAP X5R 1U K 6V3 |
|
|
C1470 |
Bot |
D |
|
15 |
0603C |
0603 |
1u0 |
6.3V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CHIPCAP X5R 1U K 6V3 |
|
|
C1471 |
Bot |
F |
|
18 |
0603C |
0603 |
1u0 |
6.3V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CHIPCAP X5R 1U K 6V3 |
|
|
C1472 |
Bot |
F |
|
6 |
0603C |
0603 |
1u0 |
6.3V |
|
|
|
|
|
|
|
|
|
Page 2 –8 |
COMPANY CONFIDENTIAL |
Issue 1 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
RM-180 |
|
|
|
|
|
|
|
|
|
|
Parts Lists and Component Layouts |
|
|
|
Nokia Customer Care |
||||||
|
|
|
|
|
|
|
|
|
|
|
Item |
Side |
|
Grid ref. |
Type |
Description and value |
|
||||
|
|
|
|
|
|
CHIPCAP X5R 1U K 6V3 |
|
|
|
|
C1473 |
Bot |
G |
|
7 |
0603C |
0603 |
1u0 |
|
6.3V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CHIPCAP X5R 1U K 6V3 |
|
|
|
|
C1479 |
Bot |
E |
|
14 |
0603C |
0603 |
1u0 |
|
6.3V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CHIPCAP X5R 1U K 6V3 |
|
|
|
|
C1480 |
Bot |
D |
|
14 |
0603C |
0603 |
1u0 |
|
6.3V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CHIPCAP X5R 100N M |
|
|
|
|
C1481 |
Top |
D |
|
20 |
0402C_H0.6 |
16V 0402 |
100n |
|
16V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CHIPCAP X5R 100N M |
|
|
|
|
C1482 |
Top |
D |
|
20 |
0402C_H0.6 |
16V 0402 |
100n |
|
16V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CHIPCAP X5R 100N M |
|
|
|
|
C1483 |
Top |
E |
|
6 |
0402C_H0.6 |
16V 0402 |
100n |
|
16V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CHIPCAP X5R 4U7 K 6V3 |
|
|
|
|
C1484 |
Bot |
E |
|
12 |
0805C |
0805 |
4u7 |
|
6V3 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CHIPCAP 2U2 K 25V |
|
|
|
|
C1485 |
Bot |
E |
|
13 |
1206C_TDK |
1206 |
2u2 |
|
25V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CHIPCAP X5R 100N M |
|
|
|
|
C1486 |
Bot |
E |
|
13 |
0402C_H0.6 |
16V 0402 |
100n |
|
16V |
|
|
|
|
|
|
|
|
|
|
|
|
C1487 |
Bot |
C |
|
15 |
0402C |
Chipcap 5% NP0 |
10p |
|
50V |
|
|
|
|
|
|
|
|
|
|
|
|
C1488 |
Bot |
C |
|
15 |
0402C |
Chipcap 5% NP0 |
10p |
|
50V |
|
|
|
|
|
|
|
|
|
|
|
|
C1489 |
Top |
E |
|
19 |
0402C |
Chipcap 5% NP0 |
22p |
|
50V |
|
|
|
|
|
|
|
|
|
|
|
|
C1490 |
Top |
E |
|
20 |
0402C |
Chipcap 5% NP0 |
22p |
|
50V |
|
|
|
|
|
|
|
|
|
|
|
|
C1491 |
Top |
D |
|
19 |
0402C |
Chipcap 5% NP0 |
22p |
|
50V |
|
|
|
|
|
|
|
|
|
|
|
|
C2000 |
Bot |
C |
|
3 |
0402C |
Chipcap 5% NP0 |
27p |
|
50V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CHIPCAP X5R 2U2 K 6V3 |
|
|
|
|
C2002 |
Bot |
F |
|
3 |
0603C |
0603 |
2u2 |
|
6V3 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CERCAP X7R 22N K 16V |
|
|
|
|
C2003 |
Bot |
F |
|
3 |
0402C |
0402 |
22n |
|
16V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CERCAP X7R 22N K 16V |
|
|
|
|
C2004 |
Bot |
G |
|
3 |
0402C |
0402 |
22n |
|
16V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Chipcap X7R 10% 16V |
|
|
|
|
C2005 |
Bot |
F |
|
2 |
0402C |
0402 |
10n |
|
16V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Chipcap X7R 10% 16V |
|
|
|
|
C2006 |
Bot |
G |
|
2 |
0402C |
0402 |
10n |
|
16V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Chipcap X7R 10% 16V |
|
|
|
|
C2007 |
Bot |
G |
|
2 |
0402C |
0402 |
10n |
|
16V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Chipcap X7R 10% 16V |
|
|
|
|
C2008 |
Bot |
G |
|
2 |
0402C |
0402 |
10n |
|
16V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Chipcap X7R 10% 16V |
|
|
|
|
C2009 |
Bot |
G |
|
2 |
0402C |
0402 |
10n |
|
16V |
|
|
|
|
|
|
|
|
|
|
|
|
Issue 1 |
COMPANY CONFIDENTIAL |
Page 2 –9 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
|
|
|
|
|
|
|
|
RM-180 |
|
Nokia Customer Care |
|
|
|
|
Parts Lists and Component Layouts |
||||
|
|
|
|
|
|
|
|
|
|
Item |
Side |
|
Grid ref. |
Type |
Description and value |
|
|
||
|
|
|
|
|
|
Chipcap X7R 10% 16V |
|
|
|
C2010 |
Bot |
G |
|
3 |
0402C |
0402 |
10n |
16V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CHIPCAP NP0 270P J |
|
|
|
C2011 |
Top |
F |
|
1 |
0402C |
25V 0402 |
270p |
25V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CHIPCAP X5R 1U K 25V |
|
|
|
C2012 |
Bot |
C |
|
3 |
0603C_H0.95 |
0603 |
1u0 |
25V |
|
|
|
|
|
|
|
|
|
|
|
C2070 |
Bot |
G |
|
14 |
0402C |
Chipcap 5% NP0 |
15p |
50V |
|
|
|
|
|
|
|
|
|
|
|
C2072 |
Bot |
I |
|
15 |
0402C |
Chipcap 5% NP0 |
15p |
50V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CHIPCAP X7R 15N K |
|
|
|
C2100 |
Bot |
F |
|
2 |
0402C |
16V 0402 |
15n |
16V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CHIPCAP X7R 15N K |
|
|
|
C2101 |
Bot |
F |
|
2 |
0402C |
16V 0402 |
15n |
16V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CHIPCAP X5R 2U2 K 6V3 |
|
|
|
C2102 |
Bot |
F |
|
2 |
0603C |
0603 |
2u2 |
6V3 |
|
|
|
|
|
|
|
|
|
|
|
C2103 |
Top |
E |
|
6 |
0402C |
Chipcap 5% X7R |
1n0 |
50V |
|
|
|
|
|
|
|
|
|
|
|
C2104 |
Top |
E |
|
6 |
0402C |
Chipcap 5% X7R |
1n0 |
50V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Chipcap X7R 10% 50V |
|
|
|
C2105 |
Top |
A |
|
6 |
0402C |
0402 |
1n0 |
50V |
|
|
|
|
|
|
|
|
|
|
|
C2106 |
Top |
A |
|
6 |
0402C |
Chipcap 5% NP0 |
27p |
50V |
|
|
|
|
|
|
|
|
|
|
|
C2107 |
Top |
A |
|
6 |
0402C |
Chipcap 5% NP0 |
27p |
50V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Chipcap X7R 10% 50V |
|
|
|
C2108 |
Top |
B |
|
6 |
0402C |
0402 |
1n0 |
50V |
|
|
|
|
|
|
|
|
|
|
|
C2109 |
Top |
B |
|
7 |
0402C |
Chipcap 5% NP0 |
27p |
50V |
|
|
|
|
|
|
|
|
|
|
|
C2110 |
Top |
A |
|
7 |
0402C |
Chipcap 5% NP0 |
27p |
50V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CHIPCAP X5R 1U K 6V3 |
|
|
|
C2200 |
Top |
C |
|
5 |
0603C |
0603 |
1u0 |
6.3V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CHIPCAP X5R 1U K 6V3 |
|
|
|
C2201 |
Top |
C |
|
7 |
0603C |
0603 |
1u0 |
6.3V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Chipcap X7R 10% 50V |
|
|
|
C2202 |
Top |
D |
|
6 |
0402C |
0402 |
1n0 |
50V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Chipcap X7R 10% 50V |
|
|
|
C2203 |
Top |
D |
|
6 |
0402C |
0402 |
1n0 |
50V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Chipcap X7R 10% 50V |
|
|
|
C2204 |
Top |
E |
|
6 |
0402C |
0402 |
1n0 |
50V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Chipcap X7R 10% 50V |
|
|
|
C2205 |
Top |
D |
|
5 |
0402C |
0402 |
1n0 |
50V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Chipcap X7R 10% 50V |
|
|
|
C2206 |
Top |
D |
|
6 |
0402C |
0402 |
1n0 |
50V |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Chipcap X7R 10% 50V |
|
|
|
C2207 |
Top |
E |
|
6 |
0402C |
0402 |
1n0 |
50V |
|
|
|
|
|
|
|
|
|
|
|
Page 2 –10 |
COMPANY CONFIDENTIAL |
Issue 1 |
|
Copyright © 2006 Nokia. All rights reserved. |
|
Loading...