Lennox SUGK35C, SUGK35SP, SUGK40C, SUGK40SP, SUGK45C Installation Manual

...
0 (0)

 

 

LENNOX HEARTH PRODUCTS

 

 

KITS AND ACCESSORIES

750,202M

DECORATIVE UPPER AND LOWER GRILLE KITS

REV. NC 02/2006

CHARCOAL & SATIN PEWTER

 

 

 

 

 

INSTALLATION INSTRUCTIONS FOR UPPER AND LOWER GRILLE KITS

FOR USE WITH LENNOX35/40/45 GAS FIREPLACES

UPPER GRILLE KITS - SUNRISE

Cat. No.#

Model

Description

Model Series

 

 

 

 

H3565

SUGK35C

35” Charcoal

MPD3530, MPD35ST,

 

 

 

H3567

SUGK35SP

35” Satin Pewter

MPB-35ST & EDV3530

 

 

 

 

 

H3573

SUGK40C

40” Charcoal

EDV4035, EDVST,

 

 

 

 

 

 

H3575

SUGK40SP

40” Satin Pewter

MPD4035, EBVST

 

 

 

 

H3581

SUGK45C

45” Charcoal

EDV4540,

 

 

 

H3583

SUGK45SP

45” Satin Pewter

MPD4540

 

 

 

 

 

 

 

LOWER GRILLE KITS

- SUNRISE

 

 

 

 

 

Cat. No.#

Model

 

Description

Model Series

 

 

 

 

 

H3569

SLGK35C

 

35” Charcoal

MPD3530, MPD35ST,

 

 

 

 

H3571

SLGK35SP

 

35” Satin Pewter

MPB-35ST & EDV3530

 

 

 

 

 

 

 

H3577

SLGK40C

 

40” Charcoal

EDV4035, EDVST,

 

 

 

 

H3579

SLGK40SP

 

40” Satin Pewter

MPD4035, EBVST

 

 

 

 

 

H3585

SLGK45C

 

45” Charcoal

EDV4540,

 

 

 

 

H3587

SLGK45SP

 

45” Satin Pewter

MPD4540

 

 

 

 

 

 

 

UPPER GRILLE KITS - CRESCENTS

Cat. No.#

Model

Description

Model Series

 

 

 

 

H3541

CUGK35C

35” Charcoal

MPD3530, MPD35ST,

 

 

 

H3543

CUGK35SP

35” Satin Pewter

MPB-35ST & EDV3530

 

 

 

 

 

H3549

CUGK40C

40” Charcoal

EDV4035, EDVST,

 

 

 

H3551

CUGK40SP

40” Satin Pewter

MPD4035, EBVST

 

 

 

 

H3557

CUGK45C

45” Charcoal

EDV4540,

 

 

 

H3559

CUGK45SP

45” Satin Pewter

MPD4540

 

 

 

 

 

LOWER GRILLE KITS - CRESCENTS

Cat. No.#

Model

Description

Model Series

 

 

 

 

H3545

CLGK35C

35” Charcoal

MPD3530, MPD35ST,

 

 

 

H3547

CLGK35SP

35” Satin Pewter

MPB-35ST & EDV3530

 

 

 

 

H3553

CLGK40C

40” Charcoal

EDV4035, EDVST,

 

 

 

H3555

CLGK40SP

40” Satin Pewter

MPD4035, EBVST

 

 

 

 

 

H3561

CLGK45C

45” Charcoal

EDV4540,

 

 

 

H3563

CLGK45SP

45” Satin Pewter

MPD4540

 

 

 

 

KIT CONTENTS

ITEM

QUANTITY

DESCRIPTION

 

 

 

1

1 ea.

Grill, Upper or Lower

 

 

 

2

1 ea.

Instruction Sheet

 

 

 

Table 1 - Refer to Figure 1

Notes:

The upper and lower grilles are ordered

 

 

separately.

 

Only the lower grilles include knobs (see 2

Figure 1

 

knobs shown on Crescent Style, Figure 1).

 

Sunrise Style (upper grille shown)

Crescent Style (lower grille shown)

Knobs

NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.

1

Lennox SUGK35C, SUGK35SP, SUGK40C, SUGK40SP, SUGK45C Installation Manual

Read and understand all instructions and warnings in this document before beginning the installation.

TOOLS REQUIRED

Phillips Screwdriver

Cutting Pliers (required for modesty panels with side locating tabs only as shown in Figure 6)

GENERAL INFORMATION

These decorative grilles are offered in four attractive finishes and fit on the face of the appliance in place of the standard louvers or radiant panels. If you encounter any problems, need clarification of these instructions or are not qualified to properly install this kit, contact you local distributor or dealer.

WARNINGS

• Hot! Do not touch! These decorative grilles are NOT heat guards. Carefully supervise children in the same room as appliance.

The lower Grille covering the controls will become hot during operation. Use care when removing the grille to access the controls and make sure to place the grille on a surface that is non-combustible or will not be damaged by high temperatures.

INSTALL THIS KIT ONLY WHEN THE FIREPLACE IS OFF AND COLD!

INSTALLATION INSTRUCTIONS:

1.Remove Louvered or Radiant Panel/Hood Assembly -

Upper Panel - Remove the upper louvered or radiant panel/hood assembly by pulling the assembly up and out (see Figure 2). In instances where the radiant panel is used and it is framed in with tile or other approved material, the hood must still be removed by firmly pulling it forward until it releases from the receiving brackets.

Top Panel

Louvered

Removed

Trim Panels will

Panels

 

be either Lou-

 

 

vered Panels or

 

 

Radiant Panels.

Radiant

Panels

Figure 2 - Remove Upper and/or Lower Panel(s)

Lower Panel - Remove the lower louvered or radiant panel assemby as follows:

Hinged Panel (see Figure 3) - Gently depress the outer top corners of the louvered Control Compartment Access Panel until the spring-loaded magnetic catches "pop" it free, allowing it to swing out and down to open. With the panel in the open position, depress the spring-loaded hinge pin on left side until it disengages from the left cabinet panel hole. Pull panel away from fireplace.

Hinge Pin

Latch for

Glass Door

Control Compartment

Access panel

Figure 3 - Remove Hinged Lower Panel

Hooked Panel (see Figure 4) - Remove the panel by gently lifting it upward until the hook catches on boths sides clear the locating slots. Then pull door out to remove.

OPENING CONTROL COMPARTMENT DOOR

Lift the Lower Control Compartment

Door up and pull out to remove.

Hook Catch

Control Valve

Out

 

Up

Lower Control

Compartment Door

Figure 4 - Remove Hooked Lower Panel

2

NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.

Loading...
+ 2 hidden pages