John Deere S-Series Combines (S550, S660–S690) |
Cleaning Guide |
|
|
IMPORTANT: Regular and thorough cleaning of machine combined with other routine maintenance procedures listed in the Operator’s Manual greatly reduce the risk offire,chanceofcostlydowntime,and improve machine performance.
Crop material and other debris can accumulate in various areas. Direction of wind, type of crop, and crop moisture content can all impact where and how much crop material and debris can accumulate. Be aware of harvest conditions and adjust your cleaning schedule to ensure proper machine function and to reduce the risk of fire.These areas may require more frequent cleaning, even multiple times per day,
depending on harvest conditions. Inspect and clean these areas as needed throughout the harvest day.
Other areas not covered in this section may also collect crop debris and MUST be cleaned periodically for machine function and appearance.
Thoroughly inspect the entire machine on a regular basis throughout the harvest season.
Refer to the Machine Cleanout Section of your Operator’s Manual for further information.
1 |
1A |
NOTE: Some shields were removed for photo clarity.
Engine Compartment
NOTE: (A) Photos (S550 Machines ONLY)
•Turbocharger(s) (1 and 1A)
•Exhaust Manifold and Manifold Shield, Turbo Interstage Tube, Exhaust Gas Recirculation (EGR) Cooler Tube (2 and 2A)
•Around Engine (3 and 3A)
•Underneath Engine (4)
3
READ SAFETY INFORMATION IN OPERATOR’S MANUAL
Always follow all safety procedures posted on the machine and in the Operator’s Manual. Before carrying out any inspection or cleaning, always shut OFF engine, set parking brake and remove key.
Thoroughly clean machine from top to bottom with compressed air. First clean all
2
2A
3A |
4 |
areas accessible from engine deck. Start with |
From ground level, clean rear underside |
engine compartment and work outwards |
of fuel tank area and top of the rear |
and counterclockwise to other areas around |
tailboard of the residue disposal system. |
enginecompartment,floorunderneath |
Dieselparticulatefilterarea(ifequipped) |
engine, top rear of rotor and rear deck, |
will also need to be cleaned from ground |
includingtopofdieselparticulatefilter |
level. Once the cleaning from ground level |
(if equipped). Once top areas of machine are |
isfinished,recheckenginecompartment |
clean, proceed to cleaning areas accessible |
for any crop debris that could have blown |
from ground level. |
in from ground level cleaning. |