DV1628
Owner's Manual
Thank you!
Thank you for choosing a JENSEN product. We ve tried to make the instructions in this owner s manual clear and easy to follow. If you take a few minutes to look through it, you ll learn how to use all of the features of your new JENSEN AM/FM/CD/DVD player for maximum enjoyment.
Installation........................................................................................... |
1 |
Troubleshooting.................................................................................. |
3 |
Operation............................................................................................. |
4 |
Specifications...................................................................................... |
16 |
Warranty............................................................................................. |
17 |
1
Installation:
Getting Started.
It is a good idea to read all of the instructions before you begin the installation.
Tools and supplies needed:
•Flat and Phillips screwdrivers
•Wire cutters and strippers
•Tools to remove existing radio
•Electrical tape
•Crimping tool
•Volt meter/ Test light
•Crimp connections
•Speaker Requirements: Only connect speakers rated in the load impedance range of 4 Ohms. Speakers with a load impedance less than 4 Ohms could damage the unit
1.Prepare:
•Disconnect battery. Before you begin always disconnect the battery s negative terminal
2.Mounting angle:
•Do not exceed a 30¡ mounting angle. Improper operation of the unit could occur if the mounting angle is exceeded.
3 0
3. Removal of factory radio or DV1628:
1
•Use factory radio or DV1628 removal tools to remove the radio from the DIN opening.
1
FIGURE1
2
3 |
4. Wire Connections: |
DV1628 |
|
• |
See Figure #1 |
|
Pin # |
Wire Color |
Function |
|
1 |
Violet w/ Black stripe |
Right Rear speaker |
( - ) |
2 |
Green w/ Black stripe |
Rear L Speaker |
( - ) |
3 |
Brown w/ Black stripe |
Center Speaker |
( - ) |
4 |
White w/ Black stripe |
Front L Speaker |
( - ) |
5 |
Gray w/ Black stripe |
Front R Speaker |
( - ) |
6 |
Blue |
Power Antenna |
( Trigger ) |
7 |
Black |
Ground |
( - ) |
8 |
Violet |
Rear R Speaker |
( + ) |
9 |
Green |
Rear L Speaker |
( + ) |
10 |
Brown |
Center Speaker |
( + ) |
11 |
White |
Front L Speaker |
( + ) |
12 |
Gray |
Front R Speaker |
( + ) |
13 |
Red |
12 V Plus |
( + ) |
14 |
Yellow |
Memory 12 V+ |
( Battery ) |
POWER/SPEAKER (5.1)
2
ANTENNA
EXTERNAL MUTE KEY IN
SUB OUT (VARIABLE PRE-AMP)
LEFT STEREO OUT (FIXED PRE-AMP)
RIGHT STEREO OUT (FIXED PRE-AMP)
VIDEO IN
LEFT STEREO IN
RIGHT STEREO IN
VIDEO 1 OUT
VIDEO 2 OUT
LEFT STEREO OUT
RIGHT STEREO OUT
AUX IN
SMART MODE (FIXED PRE-AMP)
POWER/SPEAKER (5.1)
CDC
2
Troubleshooting:
PROBLEM |
CAUSE |
CORRECTIVE |
|
ACTION |
|||
|
|
||
Does not |
No power to |
Check power |
|
connection with |
|||
operate, |
Yellow wire, |
||
Multi-meter. Check |
|||
display does |
No power to |
||
fuse for continuity |
|||
not light. |
Red |
||
with Multi-meter. |
|||
|
|
||
|
Inline fuse |
Replace fuse. |
|
|
blown |
||
|
|
||
No power to |
Inline fuse |
Check and/or |
|
unit |
blown |
replace fuse. |
|
No Audio to |
Speaker |
Check speaker |
|
harness not |
wires, connect |
||
speakers |
|||
connected |
harness. |
||
|
|||
|
Power wire |
Make sure wire is |
|
Blows fuses |
shorting to |
||
not pinched. |
|||
|
ground |
||
|
|
||
|
Speaker |
Make sure wire is |
|
|
wires shorting |
||
|
not pinched. |
||
|
to ground |
||
|
|
||
|
|
|
|
|
Incorrect |
Replace with |
|
|
fuse/ rating |
||
|
proper fuse. |
||
|
too small |
||
|
|
||
|
Mounting |
Check proper |
|
|
mounting angle |
||
|
angle is too |
||
CD/DVD skips |
and/or mounting |
||
great or not |
|||
|
strap for secure |
||
|
secure. |
||
|
mounting. |
||
|
|
||
|
Dirty laser. |
Use CD/DVD |
|
|
cleaning kit. |
||
|
|
3
ERROR
DISPLAY
CDP and CDC |
|
|
|
|
|
|
|
ERR1 appears |
Mechanism |
Press Reset button. |
|
on display |
Error |
||
|
|||
ERR6 appears |
Sled Error |
Press Reset button. |
|
on display |
|||
|
|
||
|
|
|
|
CDP ONLY |
|
|
|
|
|
|
|
ERR2 appears |
Servo Error |
Press Reset button. |
|
on display |
|||
|
|
||
|
|
Check disc - disc |
|
ERR7 appears |
TOC reading |
may be dirty or |
|
upside down. If not |
|||
on display |
error |
||
press the reset |
|||
|
|
||
|
|
button. |
|
|
|
|
|
CDC ONLY |
|
|
|
|
|
|
|
|
|
Check disc - disc |
|
ERR2 appears |
TOC reading |
may be dirty or |
|
upside down. If not |
|||
on display |
error |
||
press the reset |
|||
|
|
||
|
|
button. |
|
ERR3 appears |
Temperature |
Press Reset button. |
|
on display |
error |
||
|
|||
ERR7 appears |
Disc and |
Press Reset button. |
|
on display |
Servo error |
||
|
3
4
Operation: |
|
|
|
|
|
|
|
|
|
|
|
4. |
Source: |
Press the source button to toggle |
||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
between Radio, CD/DVD, CDC/DVDC, and Aux mode. |
|||||
1. Front Panel / Remote Control |
|
|
|
|
|
|
|
|
|
(NOTE: CDC/DVDC mode is active only if a changer is |
||||||||||
|
|
|
|
|
|
|
|
|
connected. This source will be skipped if a changer is not |
|||||||||||
• |
Controls |
|
|
|
|
|
|
|
|
|
|
|
|
|||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
installed.) Press and hold the Source button for 2 seconds to |
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
mute the rear speaker and subwoofer. Press and hold for 2 |
|||||
3 |
6 |
7 |
|
27 |
10 |
11 |
15 |
13 |
29 |
12 |
2 |
26 |
|
more seconds to re-activate the rear speakers and subwoofer. |
||||||
|
|
5. |
Enter / Mute: |
Press the Enter button to select the |
||||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
highlighted menu bar. Press and hold the Enter button for 2 |
|||||
|
OPEN |
|
|
|
BAND/MENU |
|
|
CLK |
DSP |
SMART |
|
SEL |
|
|
seconds to mute the speakers. |
|
|
|
||
|
|
|
|
|
|
|
MOODE |
|
|
|
|
|
|
|||||||
|
|
|
|
|
|
|
AS/PS |
|
AUDIO |
|
|
|
|
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
6. |
/ |
: |
Press the |
to fast forward the |
||
|
ENT |
|
|
|
|
|
|
|
|
|
PWR/ILL |
|
|
track. Press the |
to rewind the track. |
|
||||
|
MUTE |
|
|
|
|
|
|
|
|
|
|
|
|
|||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
DOLBY |
|
7. |
/ |
|
Press the |
to skip to the next |
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||
|
|
SOURCE |
|
1 |
2 SCN |
3 |
RPT |
4 RND |
5 D.DN |
6 D.UP |
|
|
|
|
track, press the |
to skip to the previous track. |
||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
8. |
Slow/Zoom: |
Activate the slow forward or zoom |
||||
|
5 |
4 |
25 |
9 |
21 |
22 |
20 |
23 |
24 |
|
|
1 |
|
|
function. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
9. |
/ |
|
Pause/Play button. Press once to |
|||
|
|
LED |
|
|
|
|
|
28 |
|
|
|
|
pause the CD/DVD, press again to resume play. |
|||||||
|
|
|
|
|
|
|
|
|
|
10. |
Band/Menu: |
In radio mode, press the |
|
|||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Band/Menu button to change from AM/FM bands. In |
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
DVD mode, press the Band/Menu button to activate |
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
the DVD menu. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
11. |
/AS/PS: |
In DVD mode, press the |
/AS/PS to |
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
stop the DVD. In Radio mode, press the |
/AS/PS to |
||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
access the Automatic memory storing and preset scanning |
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
mode. Press and hold the button for 2 seconds to scan |
|||||
|
1. |
Power Button: |
|
Press the Power button to turn the unit |
|
through the 6 preset stations. |
|
|
|
|||||||||||
|
|
12. |
Vol + / Vol - |
Controls the volume level, press the |
||||||||||||||||
|
|
on. Press and hold for 2 seconds to turn the unit off. Press the |
||||||||||||||||||
|
|
|
Vol+ |
button to increase the volume and the Volbutton to |
||||||||||||||||
|
|
Power button when the unit is on to select 4 different |
|
|
||||||||||||||||
|
|
brightness settings for the panel. |
|
|
|
|
|
|
decrease the volume. |
|
|
|
||||||||
|
2. |
SEL: |
|
|
|
|
Selects the audio effect. Press the select |
13. |
Audio/DSP: |
Chooses the audio soundtrack and the |
||||||||||
|
|
button to choose the desired Bass, Treble, or speaker setting. |
|
preset EQ. DVD mode: Press and hold for 2 seconds to |
||||||||||||||||
|
|
Use the VOL+ and VOLbutton to adjust the levels. |
|
|
change the language soundtrack. Feature is activated only |
|||||||||||||||
|
3. |
Open: |
|
|
|
|
Opens the front panel to allow access to |
|
if the DVD is recorded with multi language soundtracks. |
|||||||||||
|
|
the CD/DVD slot. |
|
|
|
|
|
|
|
|
|
CD Mode: Press and hold for 2 seconds to change from |
||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Stereo, Mono left and Mono right mode. Press once to |
4
toggle between EQ settings, each press will toggle from Flat, Classic, Pop, Rock, to off.
14.Angle: Allows the viewer to view the DVD at different angles if the DVD is recorded with this feature. Press the angle button while the DVD is Stopped. Then press the / to adjust the brightness and contrast levels.
15.Disp/Clock: Press to display the Clock or Disc information. Setting the clock: Press and hold the Disp/Clock button until the display begins to flash. Press the #6 / to adjust the hours or minutes.
16.Subtitle: Changes the subtitles language on the DVD if the DVD is recorded with this feature.
17.Title: Displays the title that is stored on the CD/DVD.
18.Setup: Displays the setup menu.
19. 0-9: |
Numeric key buttons. |
20.M1-M6: Selects the Radio stations stored in the memory.
21. Scan: Scans the entire disc and plays the first 10 seconds of each track.
22.Repeat: Replays the current disc or track.
23.Random: Plays the disc in random.
24.Disc- / Disc+: Chooses the CD/DVD, ( only if CDC or DVDC is connected.
25. |
Reset: |
Reset button, press only if the unit is |
|
locked up. This resets the unit to the factory settings. |
|
26. |
Remote IR: |
Receiving sensor for the remote control. |
27. |
Display: |
Main unit display |
28. |
Eject: |
Eject the CD or DVD |
29.Smart Mode / Disc: Press the Smart mode button to put the unit into Smart mode. See Smart mode function. In DVD changer mode ( Only if DVDC is connected ) press the button to enter the Disc Menu.
5
1 |
|
|
|
CLK |
|||||
|
|
|
|
|
|
15 |
|||
|
|
|
|||||||
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
||
|
|
|
|
|
SCN |
RPT |
RND D.DN D.UP
19
29 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
10 |
|
||||||||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
9 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
AS/PS |
|
||||||||||||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|||||||||||||||||||||||||
|
|
11 |
|
|
|
|
|
|
|
8 |
|
||||||||||||||||||||||||
|
|
|
|
||||||||||||||||||||||||||||||||
|
|
|
|
||||||||||||||||||||||||||||||||
|
|
|
|
||||||||||||||||||||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
5 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
7 |
|
||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
6 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
13 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||||
|
|
|
|
|
DSP |
|
|||||||||||||||||||||||||||||
|
|
|
|
|
|
|
|||||||||||||||||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||||||||||||||
16 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||||
17 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
2 |
|
||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||||||||
|
18 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||||||
|
|
14 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
12 |
|
|||||||||||||
4 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
5
•Front Panel removal:
a.Press the open button #3.
b.Press the middle release button and pull the panel straight out.
•Radio Removal
a.Grab the grooves of the front frame with fingers and pull.
b.Insert the supplied levers inside the grooves on the right and left hand side of the radio. Pull the levers out as shown.
6
2. MP3 Compatible:
This unit supports the following MP3 CD formats:
•Joliet
•Romeo
•ISO9660
3.Smart Mode function:
The Smart Mode feature allows the user to listen to two different audio sources at the same time. One source can be selected through the speaker system while the DVD can be listened to through an external audio source. Ex. IR transmitter for wireless headphones.
•Smart mode is activated only in DVD mode.
•Press Source button #4 to enter DVD mode.
•Press Smart button #29 to activate Smart Mode
•Press Smart button #29 again to deactivate Smart Mode.
•When Smart Mode is active, Smart Mode will be displayed in the top right corner of the Radio display.
•Pressing the Source button #4 while in Smart mode will change the Audio source being played on the speakers. The Smart Mode audio to the external audio source will remain DVD.
1
2
3 |
6