Invacare Tilt Only (2GT), Recline Only (2GR), Tilt and Recline (2GTR), Tarsys 2GT, Tarsys 2GR Parts Catalog
...
Parts Catalog
Tilt and Recline (2GTR™)
Issued: Apr 4, 2014
Tarsys®
Tilt Only (2GT™)
Recline Only (2GR™)
For 2G/3G Storm Series® RWD
and Arrow® FWD
Power Wheelchairs
Throughout this catalog you will notice letters to draw your attention to specific footnotes which are located at the
bottom of the page or below specified charts.
Parts Catalog Usage Guide
To order call toll free 1-800-333-6900, or www.invacare.com
The information contained in this document is subject to change without notice. This catalog contains
service parts for Form No. 99-150. If you have any questions regarding this catalog, please contact one
of our Customer Service Representatives.
For Customer Service Support Call:
1-800-333-6900
For Faxed In Orders Call:
1-800-678-4682 or
1-440-366-0709
For Technical Service Call:
1-800-832-4707
Literature Can Be Found at:
www.invacare.com or
1-800-828-6272
SYMBOL DEFINITION
Examples:
A,B,C etc.
NOTE:
NLA
= Special Comments
= General information pertaining to that specific page
= No Longer Available
HARDWARE MEASUREMENTS
The measurements for the hardware will be listed as follows:
Screws, Bolts
Washers
Spacers
For your convenience, we have supplied an area for you to list your Invacare Representatives.
© 2014 Invacare Corporation. Elyria, Ohio. Invacare, Yes, you can., the Blue Medallion Design, Storm Series, Arrow, Silhouette, Contour U, and Arrow are
registered trademarks and 2GT, 2GR, 2GTR, MKIV, Infinity, and Personal Back are trademarks of Invacare Corporation.
Otto Bock is a registered trademark owned by Otto Bock Orthopaedische Industrie GMBH & Co.. JAY Back is a registered trademark of Sunrise Medical
Diameter X Thread Count/Pitch X Length
Inside Diameter X Outside Diameter X Thickness
Inside Diameter X Outside Diameter X Length
Name Phone Numbers
HHG, Inc. Corporation
Form No. 99-150
1
Accessories - Back Hardware (Infinity, Personal, JAY, Silhouette, Contour U Backs w/
Extruded Canes) (Profile Back w/ 7/8" Round Canes)
TABLE of CONTENTS
Page
Number
To order call toll free 1-800-333-6900, or www.invacare.com
Form No. 99-150
Description
Accessories - Arm Pads - Otto Bock ........................................................................................ 142
154
Accessories - Headrest Support Assembly - A.B.S. Curved and Profile Back ......................... 144
Accessories - Lateral Support Assembly .................................................................................. 146
Accessories - Miscellaneous .................................................................................................... 159
Accessories - Power Wheelchair Tool Kit ................................................................................ 157
Accessories - Vent Tray Assembly - FWD ............................................................................... 151
Accessories - Vent Tray Assembly - RWD ............................................................................... 148
Arms - 2GR & 2GTR ................................................................................................................ 82
Arms - 2GT ............................................................................................................................... 79
Backs - A.B.S. Curved w/o Hardware - 2GR/2GTR w/ V.S.R. (After 4/20/03) ......................... 67
Backs - A.B.S. Curved w/o Hardware - 2GR/2GTR w/ V.S.R. (Before 4/21/03) ...................... 59
Backs - A.B.S. Curved w/o Hardware - 2GT (After 10/31/00) .................................................. 53
Backs - A.B.S. Curved w/o Hardware - 2GT (Before 11/1/00) ................................................. 45
Backs - Mounting Hardware - A.B.S. Curved & Profile ............................................................ 74
Backs - Profile w/o Mounting Hardware ................................................................................... 72
Backs - V.S.R. Actuator Motor & Mounting Hardware - 2GR and 2GTR ................................. 77
Canes - Back & Spreader Bar Assembly - Recline Only & Tilt/ Recline ................................... 42
Canes - Back & Spreader Bar Assembly - Tilt Only ................................................................. 37
Canes - Back (7/8" Round) & Spreader Bar Assembly - 2GT .................................................. 40
Electronics - Mid-Line Swing Bracket Assembly ...................................................................... 135
2
TABLE of CONTENTS
Page
Number
To order call toll free 1-800-333-6900, or www.invacare.com
Form No. 99-150
Description
Electronics - MKIV TRCM 2G, MKIV TAC & 4-Way Switch ..................................................... 128
Electronics - MKIV TRCM 2G, MKIV TAC & 4-Way Switch For TRBKTS Option .................... 131
Electronics - Quad Link (After 10/30/05) .................................................................................. 140
Electronics - Quad Link (Before 10/31/05) ............................................................................... 137
Electronics - Tilt Recline Single Switch (TRSS) ....................................................................... 126
Electronics - Tilt/Recline Potentiometers & Hardware .............................................................. 133
Frame - Base Interface Hardware - 2GR - FWD ...................................................................... 20
Frame - Base Interface Hardware - 2GR - RWD ...................................................................... 9
Frame - Base Interface Hardware - Includes Tilt Actuator - 2GT/2GTR - FWD ....................... 18
Frame - Base Interface Hardware - Includes Tilt Actuator - 2GT/2GTR - RWD ....................... 13
Frame - Base Interface Hardware w/ TRBKTS Option - 2GR - RWD ...................................... 11
Frame - Base Interface w/ TRBKTS Option - Includes Tilt Actuator - 2GT/2GTR - RWD ........ 15
Frame - Center Seat Assembly - 2GT ...................................................................................... 26
Frame - Center Seat Assembly - Includes Recline Actuator - 2GR ......................................... 28
Frame - Center Seat Assembly - Includes Recline Actuator - 2GTR ....................................... 30
Frame - Center Seat Attaching Hardware - RWD & FWD ........................................................ 24
Frames - Side ........................................................................................................................... 22
Front Pivot Bracket & Links Kit ................................................................................................. 32
Front Riggings - Front Rigging Hanger Assembly - Sector, Pin and Genius Style ................... 90
Front Riggings - Legrest Support Push Rod Assembly ............................................................ 124
Front Riggings - Legrest Supports - Mechanical - AT5544P .................................................... 92
3
Front Riggings - Power Non-Articulating Legrest Kits - POWELR18/POWELR20
(9/15/01-4/30/02)
TABLE of CONTENTS
Page
Number
To order call toll free 1-800-333-6900, or www.invacare.com
Form No. 99-150
Description
Front Riggings - Legrest, Genius (Mechanical) ........................................................................ 95
Front Riggings - Power Articulating Legrest - ELRPW (5/1/02-7/26/04) .................................. 106
Front Riggings - Power Articulating Legrest - ELRPW (After 7/26/04) ..................................... 110
Front Riggings - Power Articulating Legrest - POWELR18/POWELR20 (Before 9/15/01) ...... 99
Front Riggings - Power Articulating Legrest Kits - ELRPW (5/1/02-7/26/04) ........................... 121
Front Riggings - Power Articulating Legrest Kits - ELRPW (After 7/26/04) .............................. 123
Front Riggings - Power Articulating Legrest Kits - POWELR18/POWELR20 (Before 9/15/01)
Front Riggings - Power Articulating/Non-Articulating Legrest Harnesses & Hardware ............ 113
Front Riggings - Power Non-Articulating Legrest - POWELR18/POWELR20 (9/15/01-4/30/02) 103
Label Locations For TRBKTS Option ....................................................................................... 7
Packaging & Literature ............................................................................................................. 5
Seat Pan ................................................................................................................................... 34
Seat Pan Mounting Hardware .................................................................................................. 35
Shroud Covers - Controller ....................................................................................................... 87
Shroud Covers - Rear - Side - Lower Seat & V.S.R. Actuator Cover ....................................... 85
TRBKTS Option Clarification Reference .................................................................................. 8
116
119
4
Packaging & Literature
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
5
Packaging & Literature
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1030364 Carton, Cover 1 11 B
1091514-NLA NLA - Insert, Carton 1 12
40131X161 Insert, Plain Pad 1 23
1106472-NLA NLA - Carton 1 14
1021149-NLA NLA - Bag, Poly Zip-Lip (13" L x 9" W) 1 15
1080876-NLA NLA - Carton 1 16
1092284-NLA NLA - Insert, Carton 1 17
40131X045-NLA NLA - Carton 1 18
1091517-NLA NLA - Carton 1 19
See Note See Footnote 1 110 D
1030362 Carton, Tray 1 211
1115174 Carton, Corner Reinforcement 1 412
00077X031-NLA NLA - Warranty Card 1 1A
1134791-NLA NLA - Owner's Manual, 3G Storm with MKIV
Electronics
1 1A,B,E
1031682 Carton, Cover 1 1A,C
1030362 Carton, Tray 1 1A,C
A - Not Shown
B - All Systems
C - Complete Seating Systems with Chair Base
D - Wood skid not supplied
E - Item is no longer available from the Invacare Service Parts Department. Refer to the Invacare Website under "Product
Literature Search". Enter the part number in the "Keywords" field and download a free PDF version copy.
NOTE:
When adjusting or replacing parts, please refer to you Owner's Manual for assistance.
NOTE:
6
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
Label Locations For TRBKTS Option
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
7
TRBKTS Option Clarification Reference
TRBKTS Option was introduced 12/19/05 as an On-Chair option only for 3G RWD Storm Series models.
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
8
Base Frame Interface Hardware
RWD
Recline Only (2GR)
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
9
Base Frame Interface Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1082873-NLA NLA - Pivot Assembly, Rear 1 11
1030949 Screw, Hex Head (1/4-20 x 1-1/2") 1 62
1086943-NLA NLA - Bar, Spacer, Black 1 23
1070462 Screw, Hex Head w/ Patch (5/16-18 x 7/8") 1 64
1082872-NLA NLA - Bracket, Pivot, Front, Black 1 15 A
1086944 Screw, Socket Head (5/16-18 x 3/4") 1 46
1025704 Washer, Flat (5/16 x 5/8 x 1/16") 1 57
1082880 Support, Seat 1 28
1069724 T-Nut (5/16-18) 1 69
7930318 Package, Screw, Phillips Pan Head (#4-40 x 1/2") 25 110
1070430 Bracket, Charger Connector, Black 1 111
P0870X000 Nut, Hex Keps (#4-40) 1 212
A - Front pivot bracket made before 5/20/02 is no longer available. For seating systems manufactured before 5/20/02, see
Front Pivot Bracket and Links Kit page and order Kit part number 1112693.
NOTE:
RWD
Recline Only (2GR)
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
10
Base Frame Interface Hardware
RWD
Recline Only (2GR) with TRBKTS Option
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
11
Base Frame Interface Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1082873-NLA NLA - Pivot Assembly, Rear 1 11
1030949 Screw, Hex Head (1/4-20 x 1-1/2") 1 62
1086943-NLA NLA - Bar, Spacer, Black 1 23
1070462 Screw, Hex Head w/ Patch (5/16-18 x 7/8") 1 44
1082872-NLA NLA - Bracket, Pivot, Front, Black 1 15
1021344 Screw, Socket Head (5/16-18 x 1-1/2") 1 46
1025704 Washer, Flat (5/16 x 5/8 x 1/16") 1 67
1082880 Support, Seat 1 28
1140342 Spacer, Seat Support Mounting, Black 1 29
1069724 T-Nut (5/16-18) 1 610
1043627-NLA NLA - Screw, Hex Head w/ Patch (5/16-18 x 1-3/4") 1 211
1070430 Bracket, Charger Connector, Black 1 112
1140259 Kit, Front/Rear Tie-Down Brackets Mounting
Hardware
1 113 A
NLA - Screw, Hex Head (5/16-18 x 3/4") 1 414
Washer, Flat (5/16 x 5/8 x 1/16") 1 415
T-Nut (5/16-18) 1 416
Screw, Socket Head w/ Patch (5/16-18 x 1-3/4") 1 417
NLA - Screw, Socket Head (3/8-16 x 3/4") 1 218
1140263 Kit, Top Battery Support Bracket and Mounting
Hardware
1 119 B
Bracket, Top Battery Support, Black 1 120
Washer, Flat (5/16 x 5/8 x 1/16") 1 721
Screw, Hex Head w/ Patch (5/16-18 x 5/8") 1 322
Screw, Hex Head w/ Patch (5/16-18 x 3/4") 1 423
T-Nut (5/16-18) 1 424
1135963 Bracket, Battery Support, Black 1 125
1140260 Kit, Front Battery Support Bracket with Mounting
Hardware
1 126 C
Bracket, Battery Support, Front, Black 1 127
Washer, Flat (5/16 x 5/8 x 1/16") 1 328
NLA - Screw, Hex Head w/ Patch (5/16-18 x 1/2") 1 329
A - Includes items 14-18
B - Includes items 20-23
C - Includes items 27-29
NOTE:
RWD
Recline Only (2GR) with TRBKTS Option
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
12
Base Frame Interface Hardware
RWD
Tilt Only (2GT) and Tilt/Recline (2GTR)
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
13
Base Frame Interface Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1082778 Actuator Motor Assembly, Tilt 1 11 B
1026158 Locknut (5/16-18) 1 42
1031665 Screw, Shoulder Hex Socket Head (3/8 x 1-1/2",
5/16-18)
1 23
1082873-NLA NLA - Pivot Assembly, Rear 1 14
1082760-NLA NLA - Guidance Assembly, Linear 1 25
1117326 Screw, Socket Head w/ Patch (5/16-18 x 7/8") 1 46
1091869 Screw, Socket Flat Head w/ Patch (1/4-20 x 3/4") 1 67
1082877-NLA NLA - Bar, Clamp, Black 1 28
1070398-NLA NLA - Screw, Hex Head (5/16-18 x 1-1/2") 1 29
1039655 Bushing, Rubber 1 210
1070462 Screw, Hex Head w/ Patch (5/16-18 x 7/8") 1 611
1082872-NLA NLA - Bracket, Pivot, Front, Black 1 112 A
1086944 Screw, Socket Head (5/16-18 x 3/4") 1 413
1025704 Washer, Flat (5/16 x 5/8 x 1/16") 1 514
1082880 Support, Seat 1 215
1069724 T-Nut (5/16-18) 1 616
P0870X000 Nut, Hex Keps (#4-40) 1 217
1070430 Bracket, Charger Connector, Black 1 118
7930318 Package, Screw, Phillips Pan Head (#4-40 x 1/2") 25 119
1070411 Bolt, Shoulder (3/8 x 2-1/2") 1 220
1098646-NLA NLA - Bushing, Black (7/16 x 1/2 x 11/16") 1 221
1098645-NLA NLA - Block, Black Tilt Angle 1 222
1140059 Kit, Actuator Braking Module w/ Instruction Sheet 1 123 C
1141508 Instruction Sheet, Actuator Braking Module 1 1D
A - Front pivot bracket made before 5/20/02 is no longer available. For seating systems manufactured before 5/20/02, see
Front Pivot Bracket and Links Kit page and order Kit part number 1112693.
B - Actuator Braking Module added to Tilt Actuator and is backward compatible to all systems made before 5/18/06. The
addition of the braking module eliminated the requirement of a Heavy Duty Tilt Actuator.
C - Actuator Braking Module can be assembled in the field on seating systems before 5/18/06 as well. Must verify with an
Invacare Technician when a kit is required.
D - Not Shown
NOTE:
RWD
Tilt Only (2GT) and Tilt/Recline (2GTR)
Form No. 99-150
14
To order call toll free 1-800-333-6900, or www.invacare.com
Base Frame Interface Hardware - RWD
Tilt Only (2GT) and Tilt/Recline (2GTR) with TRBKTS Option
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
15
Base Frame Interface Hardware - RWD
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1082778 Actuator Motor Assembly, Tilt 1 11 D
1026158 Locknut (5/16-18) 1 42
1031665 Screw, Shoulder Hex Socket Head (3/8 x 1-1/2",
5/16-18)
1 23
1082873-NLA NLA - Pivot Assembly, Rear 1 14
1082760-NLA NLA - Guidance Assembly, Linear 1 25
1117326 Screw, Socket Head w/ Patch (5/16-18 x 7/8") 1 46
1091869 Screw, Socket Flat Head w/ Patch (1/4-20 x 3/4") 1 67
1082877-NLA NLA - Bar, Clamp, Black 1 28
1070462 Screw, Hex Head w/ Patch (5/16-18 x 7/8") 1 49
1082872-NLA NLA - Bracket, Pivot, Front, Black 1 110
1021344 Screw, Socket Head (5/16-18 x 1-1/2") 1 411
1025704 Washer, Flat (5/16 x 5/8 x 1/16") 1 612
1082880 Support, Seat 1 213
1140342 Spacer, Seat Support Mounting, Black 1 214
1069724 T-Nut (5/16-18) 1 615
1043627-NLA NLA - Screw, Hex Head w/ Patch (5/16-18 x 1-3/4") 1 216
1070430 Bracket, Charger Connector, Black 1 117
1140259 Kit, Front/Rear Tie-Down Brackets Mounting
Hardware
1 118 A
NLA - Screw, Hex Head (5/16-18 x 3/4") 1 419
Washer, Flat (5/16 x 5/8 x 1/16") 1 420
T-Nut (5/16-18) 1 421
Screw, Socket Head w/ Patch (5/16-18 x 1-3/4") 1 422
NLA - Screw, Socket Head (3/8-16 x 3/4") 1 223
1140263 Kit, Top Battery Support Bracket and Mounting
Hardware
1 124 B
Bracket, Top Battery Support, Black 1 125
Washer, Flat (5/16 x 5/8 x 1/16") 1 726
Screw, Hex Head w/ Patch (5/16-18 x 5/8") 1 327
Screw, Hex Head w/ Patch (5/16-18 x 3/4") 1 428
T-Nut (5/16-18) 1 429
1135963 Bracket, Battery Support, Black 1 130
1140260 Kit, Front Battery Support Bracket with Mounting
Hardware
1 131 C
Bracket, Battery Support, Front, Black 1 132
Washer, Flat (5/16 x 5/8 x 1/16") 1 333
NLA - Screw, Hex Head w/ Patch (5/16-18 x 1/2") 1 334
1140059 Kit, Actuator Braking Module w/ Instruction Sheet 1 135 E
1141508 Instruction Sheet, Actuator Braking Module 1 1F
Tilt Only (2GT) and Tilt/Recline (2GTR) with TRBKTS Option
Form No. 99-150
16
To order call toll free 1-800-333-6900, or www.invacare.com
Base Frame Interface Hardware - RWD
A - Includes items 19-23
B - Includes items 25-28
C - Includes items 32-34
D - Actuator Braking Module added to Tilt Actuator and is backward compatible to all systems manufactured before 5/18/06.
The addition of the braking module eliminated the requirement of a Heavy Duty Tilt Actuator.
E - Actuator Braking Module can be assembled in the field on seating systems manufactured before 5/18/06 as well. Must
verify with an Invacare Technician when a kit is required.
F - Not Shown
NOTE:
Tilt Only (2GT) and Tilt/Recline (2GTR) with TRBKTS Option
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
17
Base Frame Interface Hardware - FWD
Tilt Only (2GT) and Tilt/Recline (2GTR)
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
18
Base Frame Interface Hardware - FWD
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1082778 Actuator Motor Assembly, Tilt 1 11 B
1026158 Locknut (5/16-18) 1 42
1031665 Screw, Shoulder Hex Socket Head (3/8 x 1-1/2",
5/16-18)
1 23
1082873-NLA NLA - Pivot Assembly, Rear 1 14
1082760-NLA NLA - Guidance Assembly, Linear 1 25
1117326 Screw, Socket Head w/ Patch (5/16-18 x 7/8") 1 46
1091869 Screw, Socket Flat Head w/ Patch (1/4-20 x 3/4") 1 67
1082877-NLA NLA - Bar, Clamp, Black 1 28
1074133 Washer, Steel (5/16 x 3/4 x 1/16") 1 29
7930337 Package, Screw, Hex Head w/ Patch (5/16-18 x
1-1/4")
25 110
1095481-NLA NLA - Plate, Wedge 1 211
1095479-NLA NLA - Wedge, Seat Mounting, Black 1 212
1086944 Screw, Socket Head (5/16-18 x 3/4") 1 613
1061922-NLA NLA - Screw, Hex Head w/ Patch (5/16-18 x 1/2") 1 414
1082872-NLA NLA - Bracket, Pivot, Front, Black 1 115 A
1039655 Bushing, Rubber 1 216
1070398-NLA NLA - Screw, Hex Head (5/16-18 x 1-1/2") 1 217
1069724 T-Nut (5/16-18) 1 418
1070411 Bolt, Shoulder (3/8 x 2-1/2") 1 219
1098646-NLA NLA - Bushing, Black (7/16 x 1/2 x 11/16") 1 220
1098645-NLA NLA - Block, Black Tilt Angle 1 221
1140059 Kit, Actuator Braking Module w/ Instruction Sheet 1 122 C
1141508 Instruction Sheet, Actuator Braking Module 1 1D
A - Front pivot bracket made before 5/20/02 is no longer available. For seating systems manufactured before 5/20/02, see
Front Pivot Bracket and Links Kit page and order Kit part number 1112693.
B - Actuator Braking Module added to Tilt Actuator and is backward compatible to all systems manufactured before 5/18/06.
The addition of the braking module eliminated the requirement of a Heavy Duty Tilt Actuator.
C - Actuator Braking Module can be assembled in the field on seating systems manufactured before 5/18/06 as well. Must
verify with an Invacare Technician when a kit is required.
D - Not Shown
NOTE:
Tilt Only (2GT) and Tilt/Recline (2GTR)
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
19
Base Frame Interface Hardware
Recline Only (2GR)
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
20
Base Frame Interface Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1082873-NLA NLA - Pivot Assembly, Rear 1 11
1030949 Screw, Hex Head (1/4-20 x 1-1/2") 1 62
1086943-NLA NLA - Bar, Spacer, Black 1 23
1095481-NLA NLA - Plate, Wedge 1 24
1086944 Screw, Socket Head (5/16-18 x 3/4") 1 65
1095479-NLA NLA - Wedge, Seat Mounting, Black 1 26
1074133 Washer, Steel (5/16 x 3/4 x 1/16") 1 27
7930337 Package, Screw, Hex Head w/ Patch (5/16-18 x
1-1/4")
25 18
1061922-NLA NLA - Screw, Hex Head w/ Patch (5/16-18 x 1/2") 1 49
1082872-NLA NLA - Bracket, Pivot, Front, Black 1 110 A
1069724 T-Nut (5/16-18) 1 411
A - Front pivot bracket made before 5/20/02 is no longer available. For seating systems manufactured before 5/20/02, see
Front Pivot Bracket and Links Kit page and order Kit part number 1112693.
NOTE:
Recline Only (2GR)
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
21
Side Frames
NOTE: A new cross beam may be required when changing seat width for a Recline Only or Tilt/Recline
system. See center seat frame assembly page.
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
22
Side Frames
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1087002-NLA NLA - Hardware, Side Frame Mounting 1 11 A
7930333 Locknut (1/4-20) 25 12
1047449 Spacer (1/4 x 3/8 x 3/16") 1 43
1026099 Spacer, Coved (1/4 x 11/16 x 1/2") 1 44
1037610 Screw, Hex Head (1/4-20 x 1-5/8") 1 45
1086976 Side Frame w/ Arm Lock Assembly - Right (16 - 17"
D)
1 16
1086977 Side Frame w/ Arm Lock Assembly - Left (16 - 17"
D)
1 16
1086978 Side Frame w/ Arm Lock Assembly - Right (18 - 19"
D)
1 16
1086979 Side Frame w/ Arm Lock Assembly - Left (18 - 19"
D)
1 16
1086980 Side Frame w/ Arm Lock Assembly - Right (20 - 21"
D)
1 16
1086981 Side Frame w/ Arm Lock Assembly - Left (20 - 21"
D)
1 16
1086982 Side Frame w/ Arm Lock Assembly - Right (22" D) 1 16
1086983 Side Frame w/ Arm Lock Assembly - Left (22" D) 1 16
7930347 Package, Pin, Roll (5/64 x 5/8") 25 17 B
47471X074 Spring, Arm Lock 1 27 B
1028594 Pin, Arm Lock, Black 1 27 B
1090768 Kit, Lock Handle w/Rivets (Pair) 2 17 B
A - Includes Items 2-5
B - Arm Lock Assembly
NOTE:
NOTE: A new cross beam may be required when changing seat width for a Recline Only or Tilt/Recline
system. See center seat frame assembly page.
Form No. 99-150
23
To order call toll free 1-800-333-6900, or www.invacare.com
Center Seat Frame Attaching Hardware
(RWD and FWD)
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
24
Center Seat Frame Attaching Hardware
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1026158 Locknut (5/16-18) 1 41
1031665 Screw, Shoulder Hex Socket Head (3/8 x 1-1/2",
5/16-18)
1 42
1070411 Bolt, Shoulder (3/8 x 2-1/2") 1 23
1098646-NLA NLA - Bushing, Black (7/16 x 1/2 x 11/16") 1 24
1098645-NLA NLA - Block, Black Tilt Angle 1 25
(RWD and FWD)
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
25
Center Seat Frame Assembly
Tilt Only (2GT)
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
26
Center Seat Frame Assembly
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1087010-NLA NLA - Center Seat Frame Assembly, Short (16 - 19"
D)
1 11 A
1087011 Center Seat Frame Assembly, Long (20 - 22" D) 1 11 A
1082874-NLA NLA - Center Seat Frame, Short (16 - 19" D) 1 12
1082875-NLA NLA - Center Seat Frame, Long (20 - 22" D) 1 12
1086590-NLA NLA - Tilt Pivot Assembly, Right 1 13
1086591-NLA NLA - Tilt Pivot Assembly, Left 1 13
1012371 Washer, Nylon (3/8 x 7/8 x 1/16") 1 84
1061922-NLA NLA - Screw, Hex Head w/ Patch (5/16-18 x 1/2") 1 25
1082876-NLA NLA - Spacer (3/8 x 3/4 x 3/8") 1 26
1086595-NLA NLA - Link, Tilt, Black 1 27
1065214 Washer, Flat (3/8 x 11/16 x 1/16") 1 48
1086930-NLA NLA - Ring, Retaining (3/8") 1 49
1091502-NLA NLA - Guide, Tilt Rail 1 410
A - Includes Items 2-10
NOTE:
Tilt Only (2GT)
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
27
Center Seat Frame Assembly
Recline Only (2GR)
Form No. 99-150
To order call toll free 1-800-333-6900, or www.invacare.com
28
Center Seat Frame Assembly
Item
Number
Part Number
DescriptionNote
Quantity Per
Package Assembly
1086944 Screw, Socket Head (5/16-18 x 3/4") 1 61
1082878-NLA NLA - Bracket, Acutator Support, Black - Right 1 12
1082879-NLA NLA - Bracket, Actuator Support, Black - Left 1 12
1026158 Locknut (5/16-18) 1 73
1031665 Screw, Shoulder Hex Socket Head (3/8 x 1-1/2",
5/16-18)
1 14
1082750 Actuator Motor Assembly, Recline 1 15
1012371 Washer, Nylon (3/8 x 7/8 x 1/16") 1 146
1087022-NLA NLA - Link, Recline - Right 1 17 A,A1,B
1087023-NLA NLA - Link, Recline - Left 1 17 A,A1,B
1110497-NLA NLA - Link, Recline 0 and 5 Degree Seat Tilt, Black
- Right
1 17 C
1110498-NLA NLA - Link, Recline 0 and 5 Degree Seat Tilt, Black
- Left
1 17 C
1110499-NLA NLA - Link, Recline 10 and 15 Degree Seat Tilt,
Black - Right
1 17 C
1110500-NLA NLA - Link, Recline 10 and 15 Degree Seat Tilt,
Black - Left
1 17 C
1065214 Washer, Flat (3/8 x 11/16 x 1/16") 1 48
1086930-NLA NLA - Ring, Retaining (3/8") 1 49
1082876-NLA NLA - Spacer (3/8 x 3/4 x 3/8") 1 210
1025704 Washer, Flat (5/16 x 5/8 x 1/16") 1 211
1079203 Decal, Warning Pinch Point 1 212
1091500-NLA NLA - Kit, Connecting Slide Bracket w/ Decal, Black
- Right
1 113
1091501-NLA NLA - Kit, Connecting Slide Bracket w/ Decal, Black
- Left
1 113
1098944-NLA NLA - Screw, Socket Head w/ Patch (1/4-20 x 3/4") 1 414
1095352-NLA NLA - Block, Gear Hold Down Upper 1 215
1091503-NLA NLA - Bushing (1/4 x 1/2 x 7/16") 1 416
1026035-NLA NLA - Locknut (#10-24) 1 417
1000212 Screw, Shoulder Hex Socket (1/4 x 1-1/4", #10-24) 1 418
1095476-NLA NLA - Dual Roller Assembly - Right 1 119 D
1095477-NLA NLA - Dual Roller Assembly - Left 1 119 D
A - Front pivot bracket made before 5/20/02 is no longer available. For seating systems manufactured before 5/20/02, see
Front Pivot Bracket and Links Kit page and order Kit part number 1112693.
A1 - To maintain an existing, 5, 10, or 15 degree seat tilt, only recline links made after 5/19/02 are required.
B - Before 5/20/02
C - After 5/19/02
D - Includes 2 each of items 16-18
NOTE:
Recline Only (2GR)
Form No. 99-150
29
To order call toll free 1-800-333-6900, or www.invacare.com
Loading...