GE ZGU36L6, ZGU48L6R, ZGU36N4D, ZGU48L6D, ZGU48N6R User Manual

Installation

Instructions

If you have questions, call 800.GE.CARES or visit our website at: www.monogram.com

Professional Gas Cooktops

48" Natural Gas Models ZGU48N4G

ZGU48N6R

ZGU48N6D

48" LP Gas Models ZGU48L4G ZGU48L6R ZGU48L6D

36" Natural Gas Models ZGU36N6

ZGU36N4R

ZGU36N4D

36" LP Gas Models ZGU36L6 ZGU36L4R ZGU36L4D

Installation Instructions

BEFORE YOU BEGIN

Read these instructions completely and carefully.

• IMPORTANT – Save these instructions for local inspector’s use.

• IMPORTANT – Observe all governing codes and ordinances.

•Note to Installer – Be sure to leave these instructions with the Consumer.

•Note to Consumer – Keep these instructions for future reference.

•Skill Level – Installation of this cooktop requires basic mechanical and electrical skills.

•Completion time – 1 to 3 hours.

•Proper installation is the responsibility of the installer.

•Product failure due to improper installation is not covered under the Warranty.

WARNING:

This appliance must be properly grounded. See “Electric Supply”, page 6.

AVERTISSEMENT :

Cet appareil doit être mis à la terre adéquatement. Voir la section « Alimentation électrique » à la page 6.

For Monogram local service in your area, 1.800.444.1845.

For Monogram Service in Canada, call 1.888.880.3030.

For Monogram Parts and Accessories, call 1.800.626.2002.

If you received a damaged cooktop, you should contact your dealer.

In the Commonwealth of Massachusetts:

•This product must be installed by a licensed plumber or gas fitter.

•When using ball type gas shut off valves, they shall be T-handle type.

•A flexible gas connector, when used, must not exceed 3 feet.

CAUTION:

THESE COOKTOPS SHOULD BE INSTALLED IN CONJUNCTION WITH A SUITABLE

OVERHEAD VENT HOOD. Due to the high heat capacity of this unit, particular attention should be paid to the hood and duct work installation to assure it meets local building codes.

MISE EN GARDE :

CES CUISINIÈRES DOIVENT ÊTRE MONTÉES CONJOINTEMENT AVEC UNE

HOTTE À ÉVACUATION DE PLAFOND APPROPRIÉE. Étant donné la grande capacité thermique de cet appareil, une attention particulière doit être portée au montage de la hotte et du système de gaines pour s’assurer qu’il est conforme aux codes du bâtiment locaux.

Standard countertop and island installations:

A 1200 CFM hood is recommended for 48" cooktops. A 600 CFM hood is recommended for 36" cooktops. Hoods should be 24" min. deep and the same width as the cooktop.

Island installations:

Check local building codes for the proper method of gas cooktop installation. Local codes vary. Installation, electrical connections and grounding must comply with applicable codes. In the absence of local codes, the cooktop should be installed in accordance with the National Fuel Gas Code ANSI 223.1-1990 and National Electrical Code ANSI/NFPA 70-1990.

CAUTION:

These cooktops are extremely heavy. Due to the weight and size of the cooktop and to reduce the risk of personal injury or damage to the

product, TWO PEOPLE ARE REQUIRED FOR PROPER INSTALLATION.

MISE EN GARDE :

Ces cuisinières sont extrêmement lourds. Tout démontage réduira considérablement

leur poids. En raison du poids et de la taille de la cuisinière, dont la manipulation risque d’entraîner des lésions corporelles ou des dommages au produit, DEUX PERSONNES SONT NÉCESSAIRES POUR PROCÉDER À UN MONTAGE ADÉQUAT.

2

Design Information

CONTENTS
Design Information
Models Available ..............................................................	3
Accessory Requirements ................................................	3
Product Dimensions and Clearances ............................	4
Installation Options ..........................................................	5
Advance Planning ..........................................................	5
Installation Preparation
Tools and Materials Required ........................................	6
Power Supply Locations ..................................................	6

Installation Instructions
Step 1, Remove Packaging ..............................................	7
Step 2, Cut the Countertop Opening ..............................	7
Step 3, Install the Cooktop ..............................................	8
Step 4, Connect Cooktop to Gas......................................	8
Step 5, Connect Electrical ................................................	9
Step 6, Assemble Burners, Check Ignition....................	9
Finalize Installation ..........................................................	10
Installation Checklist ......................................................	10
Install the Cooktop Backsplash Accessory ................	11

MODELS AVAILABLE

These cooktops are factory set for either natural gas or liquid propane gas. Order the model for your installation situation.

48" Natural Gas Models:

ZGU48N4G – 4 gas burners, grill and griddle

ZGU48N6R – 6 gas burners and grill

ZGU48N6D – 6 gas burners and griddle

48" Liquid Propane Gas Models:

ZGU48L4G – 4 gas burners, grill and griddle ZGU48L6R – 6 gas burners and grill ZGU48L6D – 6 gas burners and griddle

36" Natural Gas Models:

ZGU36N4D – 4 gas burners and griddle

ZGU36N4R – 4 gas burners and grill

ZGU36N6 – 6 gas burners

36" Liquid Propane Gas Models:

ZGU36L4D – 4 gas burners and griddle

ZGU36L4R – 4 gas burners and grill

ZGU36L6 – 6 gas burners

BACKSPLASH ACCESSORIES

All models require 12" min. clearance to a vertical combustible surface at the rear. A backsplash accessory is available for installations with less than 12" clearance to the back wall. Order a 12" high backsplash or 22" high backsplash with warming shelf.

Backsplash for 48" Models:

ZX12B48HSS – 12" high backsplash

ZX22B48HSS – 22" high backsplash with warming shelf (2 piece)

Backsplash for 36" Models:

ZX12B36HSS – 12" high backsplash

ZX22B36HSS – 22" high backsplash with warming shelf (2 piece)

High Backsplash With

Warming Shelf

12" High Backsplash

INSTALLATION NOTE:

A custom backspash may be constructed of non-combustible back wall materials such as ceramic tile, brick, marble or other stone.

3

48" Wide Hood

	Refer to Hood	12" Min. to
18" Min.	InstallationInstructions
		Combustible

	13" Max.17"	Material
		Each Side36" Min. to
		Combustible
		Material From
		22-3/4" Min.Electric/GasSupply46-1/8"7/
		Cooking
		Surface

	36" Wide Hood
	Refer to Hood	13" Max.	36" Min. to
	Installation	12" Min. to	Combustible
18" Min.	Instructions		Material From
		Combustible	Cooking
2"	7"	Material	Surface
		Each Side

1/2"

35"

Cooking Surface

2-1/2"

22-3/4" Min.

Electric/Gas

Supply

8"

26-5/8"

	9-1/2"
	3/4"
		22" High	36" Min.
	22"		to Combustibles
		Backsplash

	12"	with Shelf
		12" High Backsplash

4728REARFRONTHAllowgrAdditionalmFMon35BoxGas6-"8"NT7/16-ONTA7/8"5WideRforTINGConn"theMctiRegulatorOdelsns Clearanceand Below the Cooktop Burner	-	7	/	1	Cooking Surface	6	"
REAR