Essick Air DP3 600, DP3 200 User Manual

0 (0)

READ AND SAVE THESE INSTRUCTIONS

2 in 1 Air

Purifier &

Humidifier

OWNERS

CARE

&

USE

MANUAL

Model:

DP3 200 Granite & Blue 3-speed

Multiroom Evaporative

Humidifier and Air Purifier

DP3 600 Granite & Smoke 3-speed

Multiroom Evaporative

Humidifier and Air Purifier

French and Spanish instructions included.

Se incluyen instrucciones en Español y Francés.

Directives en français et en espagnol comprises.

 

C

U

U

 

® L

® L

 

SAVE THE ENVIRONMENT

 

RECYCLE APPROPRIATE MATERIALS

 

Patents: 5,037,583; 5,110,511; 5,133,904

 

Other Patents Pending

 

Printed in U.S.A

To order parts and accessories call 1-800-547-3888

586 4080 Rev. 5/04

Important Safeguards

READ BEFORE USING YOUR 2IN1 AIR PURIFIER & HUMIDIFIER

1)This appliance has a polarized plug (one blade is wider than the other). To reduce the risk of electric shock, this plug is intended to fit into a polarized 120-volt AC, 15-amp outlet, only one way. If the plug does not fit fully in the outlet, reverse the plug. If it still does not fit, contact a qualified electrician. Do not attempt to defeat this safety feature. If an extension cord must be used, it should also accept the wide blade plug and meet this electrical rating.

2)Do not place the cord under rugs, in traffic areas, or near heat sources.

3)Do not use the 2 in 1 air purifier & humidifier if the cord is damaged.

4)Always unplug the power cord before cleaning, servicing, or when the unit is not in use.

5)Unplug the unit and remove the water bottles before moving the unit.

6)Do not place the unit near loose drapes, combustible materials, or heatproducing objects.

7)Always place the unit on a hard, level surface where it will not be accidentally bumped or tipped. Do not place on soft carpet.

8)DO NOT OPERATE THE 2 IN 1 AIR PURIFIER & HUMIDIFIER WITHOUT THE BASE ATTACHED.

9)This 2 in 1 air purifier & humidifier is UL listed with the Bemis by Essick Air brand air filter and evaporative wicks in place. To maintain your UL rating, see your service center for all repairs. To maintain your certified rating, use only Bemis by Essick Air brand replacement air filters, wicks and chemicals. To order air filters, parts, wicks and chemicals call 1- 800-547-3888.

10)Regular cleaning is recommended. Refer to the CARE & MAINTENANCE section in the manual.

Introduction

This 2 in 1 air purifier and humidifier adds clean, invisible moisture to your home while at the same time reducing the airborne contaminants in the air that you breath. During the winter months, the 2 in 1 unit functions as a humidifier and as an air purifier simultaneously. During the summer months, when no humidity is needed, the unit may be operated solely as an air purifier. By turning the humidistat fully clockwise, to its “lock-on” position, the unit will continue to operate as an air purifier even though no more humidity is needed. If operating only as an air purifier do not add water to the water bottles.

Functioning as a humidifier, this 2 in 1 unit is designed to provide relief from dry air discomfort in localized areas, such as bedrooms, dens and other areas up to 750 square feet where humidity is needed. This product is not intended to humidify a whole house.

Functioning as an air purifier, this 2 in 1 unit reduces the amount of airborne particles that may be circulating in our homes. These particles may include:

Smoke

Fireplace Fumes

Dust

Household Cleaners

Pollen

Pesticides

Mold

Detergents

Pet Hair/Dander

Cooking Odors

Repeated long-term exposure to contaminants, such as those listed, as well as bacteria and viruses, may result in respiratory disorders and other health problems. Room air purifiers have been proven to reduce these airborne contaminants so that the air you breathe is healthier.

Benefits of Your 2 in 1 Air

Purifier and Humidifier

It is important that any humidifier or air purifier that you are considering has its performance certified by an independent test lab. This way you will know exactly what you are buying. This unit has been tested and has it's humidification and air purification performance certified by the Association of Home Appliance Manufacturers (AHAM).

AHAM Certification

Program

This information is provided to assist consumers in comparing room air cleaners. These values represent performance that can be expected within the first 72 hours of operation. Subsequent performance may vary with use.

125

90 110

This air cleaner is suggested for use in a single closed room up to 155 square feet.

Room size ratings conform to the AHAM Certification Program criteria of 80% smoke reduction. Higher Clean Air Delivery Rates (CADRs) provide improved performance in all room sizes. Portable air cleaners will be much more effective in rooms where all doors and windows are closed.

This information is provided to assist consumers in comparing portable humidifiers. These values represent performance that can be expected within the first 72 hours of operation. Subsequent performance may vary with use.

WATER OUTPUT & AREA HUMIDIFIED

Water Output Per 24 Hours - 3.30 Gallons

Square Feet Humidified - 750

AHAM HU - 1 - 1997

This humidifier can provide appropriate humidity comfort levels for an area up to 750 square feet.

Certified humidifier performance is verified by independent laboratory product testing in compliance with AHAM standard HU - 1 - 1997. Certified product performance is based on average residential construction. Further program details are available from the AHAM website at http:llwww.aham.org. and AHAM, Chicago, IL

2 in 1 units which have been certified will have the AHAM seal, listing the gallons per day water output as well as the CADR (Clean Air Delivery Ratings) on the package. The CADR rating is the single most important thing to know about an air purifiers. CADR is the amount of clean air (in cubic feet) the machine, with its air filter in place, will deliver into a room. It measures the net effect of the filter material and the air flow of the unit.

No other measurement tells you how well a unit works in your home. The higher the CADR rating on a specific particulate matter, the more efficient the unit is at removing that particulate. It is also good to know exactly what area or room size your unit will clean. Air Purifiers may be used in any room in the house. Typically , they are used in room where people spend the most time—the bedroom and the family room.

The chart below will indicate the time required to clean the air in various sized rooms in your home. Remember, every time a door or window is opened, more particulates are introduced, which will increase the cleaning time.

Room Size

14 x 16

12 x 14

9 x 15

10 x 11

Square Ft.

224

168

135

110

Air Changes/Hr. 3

4

5

6

Also certified as an evaporative humidifier, your 2 in 1 unit adds invisible moisture to your home by moving dry inlet air through a saturated wick. As air moves through the wick, the water evaporates into the air, leaving behind any white dust, minerals, or dissolved and suspended solids. Because the water is evaporated, there is no messy mist or spray and no white dust, just clean and invisible moist air. As the wick traps accumulated materials from the water, its ability to absorb and evaporate water decreases. We recommend changing the wick at least once a year, preferably disposing of the used wick at the end of the humidifying season and starting with a new wick at the beginning of the next humidifying season. In hard water areas, more frequent replacement may be necessary to maintain your humidifier’s efficiency.

CAUTION - We recommend Bemis by Essick Air Bacteria Treatment whenever you refill the water bottles to eliminate bacteria growth. Follow the directions to determine the proper amount to be added to the 1.6-gal. water bottles.

The wick does not require the use of chelating agent-type water treatments that are intended for use in Rotobelt or waterwheel-type humidifiers.

Tips for Best Performance

1)Do not block airflow inlets or outlets. Keep the grille areas clean.

2)Place the 2 in 1 air purifier & humidifier at least four inches away from any walls and in an area away from heat registers.

3)Regular cleaning of the unit is recommended. Follow the CARE AND MAINTENANCE instructions in this manual.

4)Replace the air filter regularly, preferably once a year. You can determine when to change your filter by the color of the white media. When it becomes dark brown or gray, it is time to replace the filter. If the highspeed air flow reduces considerably, it is also time to change the air filter.

5)Change the evaporative wicks at least once a year. In extremely hard water areas, more frequent replacement may be necessary. Only Bemis by Essick Air wicks guarantee the rated output of your 2 in 1 air purifier & humidifier.

6)Use a bacteriostat, such as Bemis by Essick Air #1970 EPA Registered Bacteria Treatment or Bemis by Essick Air #1970CN Environment Protection Branch registered Bacteria Treatment (in Canada), whenever you fill the water bottles to eliminate bacteria growth. To order air filters, evaporative wicks or Bacteria Treatment call 1-800-547-3888 or use the convenient order form in the back of this manual.

7)Do not use water treatment products designed for Water Wheel, Rotobelt, drum type, or ultrasonic humidifiers. These products may cause the wicks to become inefficient.

Controls and Operation

1) Remove all packaging materials before operation.

2)Before proceeding, make sure the evaporative wicks are resting all the way into the water channel (see diagram). Refer to the CARE AND MAINTENANCE section for instructions on removing the wicks for cleaning and service. The wicks and air filter must be in position for proper operation as a humidifier and/or air purifier.

Evaporative

Wicks

FRONT

3)This model also features an air purification filter which rests between the evaporative wicks and cleans the air as it provides humidity. Refer to the CARE AND MAINTENANCE section for instructions on installing and removing the air purification filter.

4)Remove a water bottle, observe the water

bottle cap (A), and locate the valve stem mechanism (B).

A

 

The cap may be removed for filling and to provide easy

 

access for cleaning with a long soft brush. The valve

 

supplies a regulated amount of water to the water chan-

 

nel and wick. Do not attempt to increase water flow by

 

modifying this valve or adding additional holes to the

B

 

bottle. Doing so will invalidate your warranty and may cause water damage to your home. NOTE: The water level can easily be observed through the tinted water bottle. It is time to refill the bottle when there is an inch or less of water remaining in the water bottle.

5)Take the water bottles to a sink, laundry basin, or bath tub. Use care in handling the water bottles. Do not drop the bottles. They will break. Turn bottle upside down and remove screw cap. Empty any remaining water in bottle, rinse the bottle thoroughly, and wipe outside clean with a cloth before adding fresh water.

6) To add water, place a soft cloth in sink and place the bottle on it. Turn on the cold water tap and

steady the bottle while filling. Each bottle holds 1.6 gallons. Do not over

fill. When full, replace the screw cap and tighten securely. Place the

bottle carefully on a protected flat surface and wipe it dry with a soft

cloth.

7) Return the bottle to its upright

position using the handle on the top

of the bottle. Slowly set the bottle in the recessed area, the top of the bottle flush with the top of the 2 in 1 air

purifier & humidifier.

8) When positioned properly, the valve will open and water will flow

into the water channel. The water level will automatically remain at the

height of the pin in the water channel until water bottle is empty.

9)Refer to the operating controls. Your unit has three motor speeds. Rotate the speed control knob on the right to select the desired operating mode. The faster the motor speed, the more airflow and the greater the amount of humidification and air purification. The running time per filling varies with humidity of the room, speed setting, and condition of the evaporative wick.

10)2 in 1 air purifier and humidifier has a quiet LOW setting which reduces the airflow for overnight operation in a bedroom or when conditions may not require full output.

 

III

 

II

 

I

Humidistat

Speed Control

Low humidity

Off

Medium humidity

Low

High humidity

Medium

Lock-on for

High

air purification only

 

 

 

11)This model also has an automatic humidistat. (The humidistat control knob is located on the left.) The humidistat will turn the humidifier on when the relative humidity in your home is below the humidistat setting and will turn the humidifier off when the relative humidity reaches the humidistat setting. For initial operation, set the humidistat at its midpoint and adjust up or down from there to achieve the desired humidity level.

During summer months, when no humidity is needed, the product may be operated only as an air purifier, by turning the humidistat as far as it will go in the clockwise direction to its lock-on position. Having the humidistat knob in the lock-on position will prevent the product from turning off if the humidity is high. The air purifier is designed to operate with BOTH wicks AND air filter in place, with or without water. Do not operate the unit in the lock-on position during the humidifying season. Essick Air will not be liable for water damage to your home due to excess humidity.

12)The 2 in 1 air purifier & humidifier should be placed at least FOUR inches away from any walls and away from heat registers. Do not place on soft carpet. Unrestricted airflow into the unit will result in the best efficiency and performance.

13)Extend the power cord and inspect it for any damage. Do not use the product if the cord has been damaged. Plug the cord into a polarized 120-volt AC outlet.

Caution: Under certain conditions, cold objects in the room, such as windows and outside walls, may cause moisture to condense. Severe condensation on window sills and walls may result in water damage. When these conditions exist, a lower speed setting is recommended. Note: The unit will not shut off when the water bottles are empty; however, this will not damage the 2 in 1 air purifier & humidifier.

Care and Maintenance

Humidifiers provide comfort by adding moisture to dry, heated, indoor air. To get the most benefit from the product and avoid misuse, follow all instructions carefully, specifically the operation, care and maintenance guidelines. Please note this is an electrical appliance and requires careful attention when in use.

In addition, if you do not follow the recommended care and maintenance guidelines, microorganisms may be able to grow in the water within the humidifier’s reservoir.

CLEANING THE TRAY AND REPLACING THE (MODEL #1040) WICKS

CAUTION: Disconnect the power cord before cleaning or servicing the unit.

IMPORTANT: We recommend cleaning your 2 in 1 air purifier & humidifier at least once a week. Follow instructions.

When carrying your 2 in 1 air purifier & humidifier, it must be kept level to avoid spilling the water from the tray. ALWAYS carry the unit using the recessed handles on the bottom of both sides of the tray. Remove and carry water bottles separately from the tray.

Cleaning the unit regularly helps eliminate odors and bacterial and fungal growth. Ordinary household bleach is a good disinfectant and can be used in the humidifier tray and bottle after cleaning.

1)Turn off unit and unplug the cord.

2)Remove the water bottles from the 2 in 1 air purifier & humidifier, empty and place them in a secure location.

3)Locate the two internal spring latches on the bottom center of each side of the cover. Press inward while lifting up on the cover to release the latch. Releasing these latches will allow removal of the top housing. Place the top housing on a flat surface.

4)Remove the air cleaning filter from the inside of the unit. See CLEANING AND REPLACING THE AIR PURIFICATION FILTER.

Essick Air DP3 600, DP3 200 User Manual

Spring Latches

REMOVING SCALE

5) Remove the two evaporative water

wicks from the tray allowing excess water to drain into the tray. Rinse the wicks under fresh water only. Do not use soap, detergent, or any other cleaners on the wicks. Leave

in the sink to drain.

6) Empty the water from the tray. Fill the water tray and each water bottle with one 8-oz. cup of undiluted

white vinegar. Let stand 20 minutes in supported upright position.

7)Swish the vinegar solution in the bottles, wetting all surfaces. Dampen a soft cloth with undiluted white vinegar and wipe out the water tray to remove scale. Do not use abrasive cleaners or cloths. Rinse the water bottles and water tray thoroughly with fresh water to remove dissolved scale and cleaning solution before disinfecting.

8)Clean dust from all interior surfaces with a soft dry brush. Clean the top housing gently with a soft, dry cloth. Never use abrasive cleaners. Inspect the air inlet and outlet grills. Clean the grille vents with a soft, dry cloth or brush if they show accumulated dust.

DISINFECTING UNIT

9)Fill the water bottles and water tray with a solution of 1 teaspoon bleach in 1 gallon of water. Let solution stand 20 minutes, swishing every few minutes. Wet all surfaces.

10)Empty water bottles and water tray after 20 minutes. Rinse with water until bleach smell is gone.

11)The outside of the water bottles may be wiped with a soft cloth dampened with fresh water.

RE-ASSEMBLY

12)Position the tray with the arrows on the inside of the tray pointing toward you. Replace the wicks into the tray water channel. See CONTROLS AND OPERATION section. Note: Both wicks and air filter must be in position for proper operation of the unit.

13)Replace the air filter in the area between the evaporative wicks. The notches in the black filter frame must be facing the front of the water tray.

14)Pick up the top housing with the control knobs facing toward you. Next, position the top housing directly above the tray lowering it carefully onto the tray and aligning the tray and top housing walls. The top housing latches should snap into the shelf inside the tray and attach firmly to the tray. With the latch on both sides of the cover in place, press down firmly on top of the cover to secure the top housing latches to the tray. Lift the housing slightly to be sure it is attached securely to the base. Failure to do so may result in water damage to your home.

15)Return the unit to its desired location.

16)Refill and replace the water bottles. (Refer to the CONTROLS AND OPERATIONS section.)

Under certain conditions, water impurities may accelerate bacteria growth in the water bottle. We recommend using Bemis by Essick Air Bacteria Treatment when the water bottles are filled. Follow directions on the bacteriostat container.

17)Plug the unit in and turn it on.

REPLACING EVAPORATIVE WICKS

We recommend replacing the wicks at least once a season, more often in hard water areas. When the wicks appear excessively clogged with mineral deposits, discard them and restore your 2 in 1 air purifier & humidifier’s efficiency with new wicks. Model #1040 is the replacement evaporative water wick. (Call 1-800-547-3888 to order.)

Only Bemis by Essick Air filters and wicks guarantee the certified output of your 2 in 1 air purifier & humidifier. Use of evaporative wicks or filters other than Bemis by Essick Air evaporative wicks or filters will void your warranty as well as the certification of output and may reduce the efficiency and output of your 2 in 1 air purifier & humidifier.

CLEANING AND REPLACING THE AIR CLEANING FILTER (MODEL #1202)

The air cleaning filter continuously removes particles and odor as the air in the room is circulated during the normal operation of the 2 in 1 air purifier & humidifier. The pleated white media is an electrostatic charged particulate filter for removing dust and small particles. Over a period of time, all the air in the room passes through and is cleaned by the air filter.

Caution: Disconnect power before cleaning or servicing.

1)Turn the unit off and unplug the cord.

2)Remove the water bottles from the 2 in 1 air

purifier & humidifier and lay bottles on their backs.

3) Remove the top housing from the tray. See Item 3 "CLEANING THE TRAY."

4) Locate the air filter mounted between the evaporative wicks. Lift out the air filter.

5) Inspect the air filter, as a clean filter is

important to maintain performance. Observe the amount of contaminate on the outside of the filter. If

there is a visible layer of dust accumulation, the filter should be cleaned by lightly vacuuming the outside of the filter. If the filter is discolored to a dark brown or gray appearance, we recommend replacement.

6)Replace the air cleaning filter at the conclusion of each humidifying season, or as needed during the air purification only season. Frequent cleaning will lengthen the life of the air filter.

7)To replace the air filter, position the air filter, with the notches facing the front, over the tray and drop in place between the evaporative wicks. See Item #14 in the RE-ASSEMBLY section. Note: The FRONT of the air filter goes toward the FRONT of the tray (as marked).

END-OF-HUMIDIFICATION-SEASON MAINTENANCE

Caution: Disconnect power before cleaning or servicing.

1)Follow weekly cleaning instructions when 2 in 1 air purifier & humidifier will not be used for at least one week or more.

2)At the end of the humidification season, discard used evaporative wicks and air cleaning filters.

3)Clean, disinfect and dry completely before running the unit solely as an air purifier. Do not store with water inside water bottles or water tray. If used wicks are not being replaced, run unit without water to dry wicks completely before storage.

4)Store in cool, dry location.

5)Install a new air filter, install new evaporative wicks, and clean the unit before the next humidification season begins. Use only Bemis by Essick Air evaporative wicks and filters to ensure the manufacturer’s rated output for your 2 in 1 air purifier & humidifier. Use of an evaporative wick or filter other than a Bemis by Essick Air evaporative wick or filter will void your warranty and may reduce the efficiency and output of your 2 in 1 air purifier & humidifier. Call 1-800-547-3888 to order. Alternatively, an order form is located in the back of this manual.

Troubleshooting

1.Unit does not operate at any speed setting:

Polarized cord must be fully inserted in wall outlet. Turn the humidistat control fully clockwise, then return to the desired setting.

For use as an air purifier only, turn the humidistat fully clockwise to the lock-on position.

Check the airflow path. Are there any obstructions preventing movement of the fan blade?

The motor contains a temperature-sensing fuse. If the motor becomes overheated, the fuse may trip. Unplug the unit and contact the nearest authorized service station. DO NOT ATTEMPT to repair the motor yourself.

2.The air does not seem to be any cleaner:

This unit removes airborne particulates which are, in some cases, too small to be seen by the naked eye. Verify the filter is installed properly and motor is turning the fan blade. If so, the air is being cleaned.

3.The filter doesn't look real dirty. Can I continue to use it or try to clean it:

The filter may be gently vacuumed to remove loose dust, etc.

4.Not enough humidity:

This is an evaporative humidifier. The humidity is invisible.

The four open holes on the front of the cover are required for proper humidistat operation. They must be kept unobstructed and clean.

Check the condition of the evaporative wicks and the air cleaning filters. The evaporative wicks should be damp. If they are dry, refer to the “Controls and Operation” section for the correct position of the wicks. If the wicks are clogged, replace them.

The water bottles may be empty – refill.

The humidistat control may be set too low. Adjust the humidistat control clockwise to a higher setting.

5.Too much humidity:

When condensation becomes heavy on cold surfaces in the room, turn the unit to a lower speed setting, turn down the humidistat (rotate counter-clockwise), or increase the room temperature.

6.Water does not flow out of the bottles:

After refilling the water bottles and placing them in the 2 in 1 air purifier & humidifier, water may not flow into the tray if the 2 in 1 air purifier & humidifier was run dry. Lift one of the bottles several times so the valve opens and closes. This will start the flow of water.

7.Water bottle leaks:

If the cap leaks after filling, remove the cap and inspect the bottle rim and gasket. Wipe any mineral deposits off the bottle rim and the cap gasket. Tighten the cap securely.

If the water valve leaks around the rubber stopper after filling, empty the water bottle and inspect the stopper. Mineral particles may prevent full closure. Clean the stopper. If leaking persists, stopper replacement may be necessary. Contact your service center or Bemis by Essick Air Consumer Service for assistance.

NOTE: The water bottle must be AIR TIGHT. The water channel will overflow if air leaks into the bottle during use from a loose cap or cracked bottle. A leaking stopper will not affect the proper function of the water bottle after it is installed in the 2 in 1 air purifier & humidifier.

CAUTION: Disconnect power before cleaning or servicing.

WARNING: The top housing assembly contains no consumerserviceable parts. To reduce the risk of electrical shock, do not attempt to open the wiring cover.

Electrical repair must be made by an authorized service center. Attempts to repair or replace electrical components will void your warranty.

Accessories

EVAPORATIVE WICK

Model 1040 (contains two wicks)

Replaceable evaporative wicks continuously draw up moisture as they filter out mineral deposits and reduce scale build-up in the unit. Only Bemis by Essick Air wicks are UL and AHAM certified to provide the rated performance from your Bemis by Essick Air 2 in 1 air purifier & humidifier.

AIR FILTER

Model 1202

Replaceable Advanced Air Purifier Filter. Removes dust, pollen, and other allergens and irritants from the air. Only Bemis by Essick Air filters are UL listed and AHAM certified to provide the rated performance from your Bemis by Essick Air 2 in1air purifier & humidifier

BACTERIA TREATMENT

No. 1970 – 32-oz. Bacteria Treatment

No. 1970CN - 32-oz. Bacteria Treatment (in Canada)

Controls bacteria growth in humidifiers. Helps eliminate unpleasant odors. This solution should not be used to clean the humidifier chassis/power pak. Improper use of this solution can cause a serious electrical malfunction of the humidifier.

HUMIDIFIER DESCALER/CLEANER

No. 1961 – 32-oz. Descaler/Cleaner

Bemis by Essick Air Humidifier Descaler will clean and prepare your humidifier for efficient operation by removing any lime scale build-up or sediment in the water channel. This solution should not be used to clean the humidifier chassis/power pak. Improper use of this solution can cause a serious electrical malfunction of the humidifier.

Need accessories: Use the convenient order form in

this booklet or call 1-800-547-3888 for fast home delivery of original equipment Bemis by Essick Air replacement parts.

HOME COMFORT DIVISION

TWO-YEAR LIMITED WARRANTY

The Bemis by Essick Air 2 in 1 air purifier and humidifier warranty covers defects in materials and workmanship for a period of two years from date of retail purchase. This warranty applies only to the original purchaser of the product.

Within the first two years from date of purchase, Essick Air will repair or replace, at its discretion, any defective part of the 2 in 1 air purifier & humidifier covered by this warranty.

This warranty gives you specific legal rights, and you may also have other rights which vary from state to state or province to province.

This warranty does not cover damage resulting from misuse or abuse of the 2 in 1 air purifier & humidifier, accidents or alterations to the product, commercial use or damage during shipment. Misuse includes malfunctions caused by negligence in cleaning or parts fouled with mineral deposits due to hard-water conditions. Alterations to the product include the substitution of non-Bemis by Essick Air brand components including, but not limited to, evaporative wicks and air filters.

If service becomes necessary, take or send the product to any Bemis by Essick Air service center.

Essick Air Products, Inc.

5800 Murray Street

Little Rock, AR 72209

501.562.1094

Loading...
+ 36 hidden pages