Dixon Ztr 44, Speedztr 44-968999538, Ztr 36, Ztr 42, Speedztr 36 968999539 User Manual

...

0 (0)

SPEEDZTR™ ZTR®

Safety Instructions

and

Operator’s Manual

Models ZTR®44/968999538

ZTR®36/968999539

ZTR®42/968999546

ZTR®44/968999547

IMPORTANT - READ CAREFULLY

The Dixon ZTR mower is both easy and fun to operate. However, any power mower must be operated properly to be safe. It is not a toy or a recreational vehicle. Before you use the mower, read this Operator’s Manual carefully. It contains valuable information that is necessary for the safe operation of the machine. Observe all safety rules and become completely familiar with the controls.

The information contained in this manual applies to all Dixon ZTR SpeedZTR™ mowers.

See your authorized Dixon dealer for warranty service, parts and repairs or to answer questions you have about your new Dixon ZTR.

TABLE OF CONTENTS
SAFETY AND WARNINGS ............................................................	4-13
General Operation .............................................................	6-7
Slope Operation ................................................................	8-9
Fire Hazards ..................................................................	11-11
Children, Bystanders And Pets ..........................................	12
Service ...............................................................................	13
WARRANTY .....................................................................................	14
SPECIFICATIONS .......................................................................	15-18
CONTROLS .................................................................................	21-24
Control Levers ....................................................................	19
Park Brake ..........................................................................	20
Transmission Drive System ...............................................	20
Blade Drive .........................................................................	21
Throttle Control Lever ........................................................	21
Choke Control ....................................................................	21
Circuit Breaker ....................................................................	21
Cut Height Lift Lever ..........................................................	22
OPERATION INSTRUCTIONS ....................................................	23-33
Starting ...............................................................................	24
Towing ................................................................................	25
Testing Safety Systems .....................................................	26
Mowing with Attachments .............................................	28-31
Side discharge ...................................................................	32
Grass height .......................................................................	33
CARE AND MAINTENANCE .......................................................	34-45
Cutter blades ......................................................................	35
Engine ................................................................................	36
Battery ................................................................................	36
Tires ...................................................................................	37
Lubrication .....................................................................	37-38
Belts ...................................................................................	39
Neutral adjustment .............................................................	40
Deck leveling ......................................................................	41
Deck removal ....................................................................	42
Cleaning .............................................................................	43
TROUBLESHOOTING .................................................................	44-45
STANDARD SERVICE PARTS LIST ...............................................	46

SpeedZTR™ 36/42/44

Part Number 539 121042R1

Dixon Ztr 44, Speedztr 44-968999538, Ztr 36, Ztr 42, Speedztr 36 968999539 User Manual

SAFETY

! WARNING Riding lawn movers, if improperly operated, can cause serious injury or death.

Pictured below are the most common causes of injury to the operator or bystander. Please read and understand this manual to prevent injuries.

Blade Contact

Tip Over

Run Over

Back Over

SAFETY

Safety Alert Symbol

When you see this symbol, BE ALERT to the potential for injury.

Follow the recommended safety precautions and safe operating practices.

DANGER

(highlighted in red) indicates an imminently hazardous

situation which, if not avoided, will result in death or serious injury.

WARNING

(highlighted in orange) indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury.

CAUTION

(highlighted in yellow) indicates a potentially hazardous situation which,

if not avoided, may result in minor or moderate injury. It may also be used to alert against

unsafe practices.

WARNINGS

WARNING Failure to observe the following instructions ! could result in serious injury or death.

GENERAL OPERATION

Read, understand, and follow all instructions in this manual and on the mower before starting.

In this operator’s manual, left and right, backward and forward are used in relation to the machine’s normal driving direction.

Only allow responsible adults, who are familiar with the instructions, to operate the mower.

Clear the area of objects such as rocks, toys, wire, etc., which could be picked up and thrown by the blade.

Be sure the area is clear of bystanders before mowing. Stop mower if anyone enters the area.

Never direct discharged material toward anyone. Avoid discharging against a wall or obstruction. Material may ricochet back toward the operator. Stop the blade(s) when crossing gravel surfaces.

Do not operate the mower without either the entire grass catcher or the deflector in place. This will decrease the possibility of injury from objects being thrown by the mower blades.

Never carry passengers.

Do not mow in reverse unless absolutely necessary. Always look down and behind before and while backing.

Never leave a running mower unattended. Always turn off blades, set Park Brake, stop engine and remove key before dismounting.

WARNINGS

WARNING Failure to observe the following instructions ! could result in serious injury or death.

GENERAL OPERATION (continued)

Do not put hands or feet near rotating parts or under the machine. Keep clear of the discharge opening at all times.

Disengage blade(s) when not mowing. Shut off engine and wait for all parts to come to a complete stop before cleaning the machine, removing the grass catcher, or unclogging the discharge guard.

Mow only in daylight or good artificial light.

Do not operate the mower while under the influence of alcohol or drugs.

Slow down before turning to reduce the risk of tip-over.

Watch for traffic when operating near or crossing roadways.

Use extra care when loading or unloading the mower into a trailer or truck.

Always wear eye protection when operating machine.

Data indicates that operators, age 60 years and above, are involved in a large percentage of riding mower-related injuries. These operators should evaluate their ability to operate the riding mower safely enough to protect themselves and others from serious injury.

Follow the manufacturer’s recommendation for wheel weights and counterweights.

WARNINGS

WARNING Failure to observe the following instructions ! could result in serious injury or death.

SLOPE OPERATION

Slopes are a major factor related to loss-of- control and tip-over accidents, which can result in severe injury or death.

All slopes require extra caution. If you feel unsure on any slope, do not mow it!

Mow across the slope with your Dixon ZTR -- never up or down. This will decrease the risk of tip-over.

Remove obstacles such as rocks, tree limbs, wires and other foreign objects that can be thrown by mower blades.

Watch for holes, ruts, roots and bumps and uneven terrain that could overturn the mower. Tall grass can hide such obstacles.

Use slow speed. Tires may lose traction on slopes even though the brakes are functioning properly.

Avoid starting or stopping on a slope. If tires lose traction, disengage the blades and proceed slowly down the slope.

Keep all movement on the slopes slow and gradual. Do not make sudden changes in speed or direction.

Use extreme caution when operating the mower with attachments to prevent tip-over or roll-over.

If front wheels lift off the ground, pull levers back to stabilize the mower. Discontinue mowing the slope!

WARNINGS

WARNING Failure to observe the following instructions ! could result in serious injury or death.

SLOPE OPERATION (continued)

DO NOT

Do not turn on slopes unless necessary, and then, turn slowly and gradually downhill, if possible. Rapid uphill turns may cause tip-over.

Do not mow near drop-offs, ditches, or embankments. Unstable ground may cause loss of control.

Do not mow on wet grass. Reduced traction could cause sliding.

Do not try to stabilize the mower by putting your foot on the ground.

Do not use grass catcher or other attachments on steep slopes. The added weight may change the stability of the mower thus creating the potential for tip-over.

WARNINGS

WARNING Failure to observe the following instructions ! could result in serious injury or death.

FIRE HAZARDS

Use extra care when handling gasoline and other fuels. They are flammable and vapors are explosive.

Store all fuel in approved containers specifically designed for that purpose.

Allow engine to cool before refueling. Never remove fuel cap or add fuel with engine running.

Do not smoke while refueling or operating the mower.

To reduce fire hazard, keep mower free of grass, leaves and other debris buildup.

If gasoline is spilled, do not attempt to start the

engine. Move mower away from the area of the spill. Do not create any source of ignition until gas vapors have dissipated. Wipe up spilled fuel and dispose of waste properly.

If fuel is spilled on clothing, change clothing immediately.

Before storing, allow mower to cool. Clean fuel and oil spillage.

Never store the mower or fuel container inside a building where there is an open flame.

WARNINGS

WARNING Failure to observe the following instructions ! could result in serious injury or death.

FIRE HAZARDS (continued)

To prevent fire or explosion, keep sparks and open flames away from battery.

Keep electrical connections clean and tight. Inspect them often. Loose connections and corrosion increase fire risk.

Before disconnecting the negative ground cable, make sure all switches are off. This decreases the chance of sparking and fire.

Use care when backing to avoid pushing the grass bags into the frame or “hot” exhaust muffler of the engine. Fire could result.

To prevent fire and explosion caused by static electricity:

Never fill containers inside a vehicle or on a truck or trailer bed with a plastic liner. Always place containers on the ground away from your vehicle before filling.

When practical, remove fuel powered equipment from the truck or trailer and refuel it on the ground. If this is not possible, refuel such equipment on a trailer with a portable container, rather than from a fuel dispenser nozzle.

If a fuel dispenser nozzle must be used, keep the nozzle in contact with the rim of the fuel tank or container opening at all times until fueling is complete. Do not use a nozzle lock-open device.

WARNINGS

WARNING Failure to observe the following instructions ! could result in serious injury or death.

CHILDREN, BYSTANDERS AND PETS

Tragic accidents can occur if the operator is not alert to the presence of children, bystanders and pets.

Children are attracted to lawn mowers and the mowing activity.

NEVER assume children, bystanders and pets will stay where they were last seen.

Be alert to avoid accidents.

Keep bystanders and pets out of the mowing area and keep children under the watchful care of another responsible adult.

Be alert and turn mower off if bystanders, children or pets enter the area.

Before and during backing look BEHIND and DOWN for small children.

Never carry children as passengers. They may fall off and be seriously injured or interfere with safe mower operation.

Never allow children to operate the mower.

Use extra care when approaching blind corners, shrubs, trees, or other objects that may obscure vision.

WARNINGS

WARNING Failure to observe the following instructions ! could result in serious injury or death.

SERVICE

Never run a mower inside a closed area or without proper ventilation.

Keep nuts and bolts tight, especially blade attachment bolts, and keep equipment in good condition.

Never tamper with safety devices. Check their proper operation regularly.

Stop and inspect the equipment if you strike an object. Repair, if necessary, before restarting.

Never make adjustments or repairs with the engine running unless otherwise specified.

Grass catcher components are subject to wear, damage and deterioration that could expose moving parts or allow objects to be thrown. Frequently check components. Replace with original equipment parts when necessary.

When servicing blades, wrap blades or wear gloves, and use extra caution.

Batteries contain sulfuric acid. To prevent burns, avoid contact with skin, eyes and clothing.

DIXON® ZTR® RESIDENTIAL WARRANTY POLICY

SpeedZTR™ & RAM 42 - Residential Mowers

DIXON® WARRANTS ITS ZTR® MOWERS AGAINST DEFECTS IN MATERIAL AND WORKMANSHIP FOR THE PERIODS SET FORTH BELOW. THE SOLE REMEDY UNDER THIS WARRANTY IS REPLACEMENT OR REPAIR OF PARTS INCLUDING LABOR COSTS.

THIS WARRANTY IS SUBJECT TO THE FOLLOWING CONDITIONS AND LIMITATIONS:

1.RESIDENTIAL APPLICATION - (used only at owner’s primary place of residence):

a.Two Years - 100% parts and labor subject to the conditions and limitations described herein for a period of two years from date of purchase by the original owner.

b.Third year - limited to 100% parts cost as shown in the current Dixon® Parts Price List and subject to the conditions and limitations as described herein.

c.Attachments marketed through or approved by Dixon are warranted for two years parts and labor in residential use applications.

2.NOT APPROVED FOR COMMERCIAL USE.

3.Lifetime warranty on all frames and leading edge of all fabricated (welded) decks (SPEEDZTR™ 36 & 44 only).

4.All Dixon® warranty must be accomplished by authorized Dixon® dealers and in accordance with Dixon® warranty policy and allowances. All warranty claims must be submitted to Dixon for approval.

5.Warranty applies to new mowers.

6.Warranty labor reimbursement to dealers based on published Dixon® flat rate schedule.

7.Warranty does not apply to damage in transit or incidents of misuse, negligence, accidents, or alteration. The use of parts or components other than those supplied by Dixon VOIDS ALL WARRANTY.

8.Battery warranty is limited to 1 year from mower manufacture date.

9.The following items are not covered by this warranty policy:

(a)Routine maintenance or adjustments to include any oils, filters or other fluids used.

(b)Belts, blades, tires and cosmetic appearance (paint, seat fade, etc.)

(c)Pick up and delivery charges for transportation of mower to and from an authorized Dixon® dealer’s place of business.

(d)Engines. These are covered under a separate warranty by each individual engine manufacturer. Consult engine manual for warranty details.

(e)Any costs or expense of providing substitute equipment while repair work is being performed on a warranted mower.

10.THERE IS NO OTHER EXPRESS WARRANTY. TO THE EXTENT PERMITTED BY LAW, ALL IMPLIED WARRANTIES, INCLUDING THOSE OF MERCHANTABILITY AND FITNESS FOR A PARTICULAR PURPOSE ARE EXCLUDED, OTHERWISE, ALL SUCH IMPLIED WARRANTIES ARE LIMITED TO THE SAME DURATION AND REMEDIES AS THE EXPRESS WARRANTY. ALL LIABILITIES FOR CONSEQUENTIAL DAMAGES UNDER ANY EXPRESS OR IMPLIED WARRANTY ARE EXCLUDED.

Chassis:

Body:

Mower Deck:

Blade Drive:

Transmission:

Engine:

Starting

System:

Tires:

Capacities:

Dimensions:

SPECIFICATIONS

SpeedZTR™ 36 Model 968999539

1½" x 2" rectangle tubular side frame

Body parts are made of steel

36" (91cm) 11 gauge fabricated construction with reinforced ribs.

Electric clutch

Each rear wheel is independently driven by a Hydro Gear EZT hydrostatic drive with cooling fan.

16.5 HP Briggs & Stratton Intek, 4-cycle, single cylinder, overhead valve, air-cooled, gasoline, vertical shaft, cast iron cylinder, full pressure lube with spin-on filter

Electric-key switch operation with safety interlocks on park brake, steering levers and blade drive.

Front 11 x 4.00-5 smooth tread	16-21 PSI
	(110-145 kPa)
Rear 18 x 7.50-8 4-ply turf tread	8-14 PSI
	(55-97 kPa)

Fuel	4.5 gallon (17 liters)
Engine Oil	1.3 quarts (1.3 liters)
Width	43" (109 cm) maximum track width
Height	43" (109 cm) to top edge of seat
Length	69" (175 cm) hitch tab to front
Weight	574 lbs. (260 kg)

Additional information may be provided elsewhere in this manual.

SPECIFICATIONS SUBJECT TO CHANGE WITHOUT NOTICE

+ 33 hidden pages