Page 1
SEMICONDUCTOR TECHNICAL DATA
Order this document
by MBR2535CTL/D
. . . employing the Schottky Barrier principle in a large metal–to–silicon power
diode. State–of–the–art geometry features epitaxial construction with oxide
passivation and metal overlay contact. Ideally suited for use in low voltage, high
frequency switching power supplies, free wheeling diodes, and polarity
protection diodes.
• Very Low Forward Voltage (0.55 V Maximum @ 25 Amps)
• Matched Dual Die Construction (12.5 A per Leg or 25 A per
Package)
• Guardring for Stress Protection
• Highly Stable Oxide Passivated Junction (125°C Operating
Junction Temperature)
• Epoxy Meets UL94, VO at 1/8″
Mechanical Characteristics
• Case: Epoxy, Molded
• Weight: 1.9 grams (approximately)
1
• Finish: All External Surfaces Corrosion Resistant and Terminal
Leads are Readily Solderable
3
• Lead Temperature for Soldering Purposes: 260°C Max. for 10
Seconds
• Shipped 50 units per plastic tube
• Marking: B2535L
2, 4
SCHOTTKY BARRIER
RECTIFIER
25 AMPERES
35 VOLTS
4
1
2
3
CASE 221A–06
(TO–220AC)
MAXIMUM RATINGS (PER LEG)
Rating Symbol Value Unit
Peak Repetitive Reverse Voltage
Working Peak Reverse Voltage
DC Blocking Voltage
Average Rectified Forward Current (Rated VR) TC = 110°C I
Peak Repetitive Forward Current, Per Leg
(Rated VR, Square Wave, 20 kHz) TC = 95°C
Nonrepetitive Peak Surge Current
(Surge applied at rated load conditions, halfwave, single phase, 60 Hz)
Peak Repetitive Reverse Surge Current (2.0 µs, 1.0 kHz) I
Operating Junction Temperature T
Storage Temperature T
Voltage Rate of Change (Rated VR) dv/dt 10,000 V/µs
Controlled Avalanche Energy W
V
RRM
V
RWM
V
F(AV)
I
FRM
I
FSM
RRM
R
J
stg
aval
35
35
35
12.5 Amps
25 Amps
150 Amps
1.0 Amp
–65 to +125 °C
–65 to +150 °C
20 mJ
THERMAL CHARACTERISTICS
Thermal Resistance — Junction to Case R
θJC
2.0 °C/W
ELECTRICAL CHARACTERISTICS
Maximum Instantaneous Forward Voltage (1)
(IF = 25 Amps, TJ = 25°C)
(IF = 12.5 Amps, TJ = 25°C)
(IF = 12.5 Amps, TJ = 125°C)
Maximum Instantaneous Reverse Current (1)
(Rated dc Voltage, TJ = 25°C)
(Rated dc Voltage, TJ = 125°C)
(1) Pulse Test: Pulse Width = 300 µs, Duty Cycle ≤ 2.0%.
V
F
I
R
0.55
0.47
0.41
5.0
500
Volts
Volts
mA
SWITCHMODE is a trademark of Motorola, Inc.
Rev 1
Rectifier Device Data
Motorola, Inc. 1996
1
Page 2
MBR2535CTL
50
20
TJ = 125°C
10
5
TJ = 25°C
2
1
F
I , INSTANEOUS FORWARD CURRENT (AMP)
0.5
0.2
0.1
0 0.1 0.2 0.3 0.4 0.5 0.6 0.7 0.8 0.9 10
vF, INSTANTANEOUS VOLT AGE (VOLTS)
Figure 1. T ypical Forward Voltage, Per Leg
1000
TJ = 125°C
100
TJ = 100°C
10
1
R
I , REVERSE CURRENT (mA)
0.1
0
TJ = 25°C
5101520253035
VR, REVERSE VOLTAGE (VOLTS)
Figure 2. T ypical Reverse Current, Per Leg
40
TJ = 125°C
35
30
25
20
15
10
5
0
0 5 10 15 20 25 30 35 40
I
F(AV)
P , AVERAGE FORWARD POWER DISSIPATION (WATTS)
F(AV)
SINE WAVE
(RESISTIVE LOAD)
, AVERAGE FORW ARD CURRENT (AMPS)
Figure 3. Forward Power Dissipation, Per Leg
SQUARE
dc
WAVE
32
28
24
20
16
12
8
4
0
F(AV)
85 95 105 115 125
I , AVERAGE FORWARD CURRENT (AMPS)
TC, CASE TEMPERATURE (°C)
SQUARE
(RATED Vr APPLIED)
R
= 2.0
θ
JC
dc
Figure 4. Current Derating
2
°
C/W
20
18
16
14
12
10
8
6
4
2
0
F(AV)
0 25 50 75 100 125
I , AVERAGE FORWARD CURRENT (AMPS)
SQUARE
WAVE
TA, AMBIENT TEMPERATURE (°C)
dc
R
θ
= 16°C/W
JA
Figure 5. Current Derating Ambient, Per Leg
Rectifier Device Data
Page 3
P ACKAGE DIMENSIONS
MBR2535CTL
SEATING
–T–
PLANE
B
4
Q
123
F
T
A
U
C
S
H
K
Z
L
V
R
J
G
D
N
CASE 221A–06
(TO–220AB)
ISSUE Y
NOTES:
1. DIMENSIONING AND TOLERANCING PER ANSI
Y14.5M, 1982.
2. CONTROLLING DIMENSION: INCH.
3. DIMENSION Z DEFINES A ZONE WHERE ALL
BODY AND LEAD IRREGULARITIES ARE
ALLOWED.
DIM MIN MAX MIN MAX
A 0.570 0.620 14.48 15.75
B 0.380 0.405 9.66 10.28
C 0.160 0.190 4.07 4.82
D 0.025 0.035 0.64 0.88
F 0.142 0.147 3.61 3.73
G 0.095 0.105 2.42 2.66
H 0.110 0.155 2.80 3.93
J 0.018 0.025 0.46 0.64
K 0.500 0.562 12.70 14.27
L 0.045 0.060 1.15 1.52
N 0.190 0.210 4.83 5.33
Q 0.100 0.120 2.54 3.04
R 0.080 0.110 2.04 2.79
S 0.045 0.055 1.15 1.39
T 0.235 0.255 5.97 6.47
U 0.000 0.050 0.00 1.27
V 0.045 ––– 1.15 –––
Z ––– 0.080 ––– 2.04
STYLE 6:
PIN 1. ANODE
2. CATHODE
3. ANODE
4. CATHODE
MILLIMETERSINCHES
Rectifier Device Data
3
Page 4
MBR2535CTL
Motorola reserves the right to make changes without further notice to any products herein. Motorola makes no warranty , representation or guarantee regarding
the suitability of its products for any particular purpose, nor does Motorola assume any liability arising out of the application or use of any product or circuit, and
specifically disclaims any and all liability, including without limitation consequential or incidental damages. “T ypical” parameters which may be provided in Motorola
data sheets and/or specifications can and do vary in different applications and actual performance may vary over time. All operating parameters, including “Typicals”
must be validated for each customer application by customer’s technical experts. Motorola does not convey any license under its patent rights nor the rights of
others. Motorola products are not designed, intended, or authorized for use as components in systems intended for surgical implant into the body, or other
applications intended to support or sustain life, or for any other application in which the failure of the Motorola product could create a situation where personal injury
or death may occur. Should Buyer purchase or use Motorola products for any such unintended or unauthorized application, Buyer shall indemnify and hold Motorola
and its officers, employees, subsidiaries, affiliates, and distributors harmless against all claims, costs, damages, and expenses, and reasonable attorney fees
arising out of, directly or indirectly, any claim of personal injury or death associated with such unintended or unauthorized use, even if such claim alleges that
Motorola was negligent regarding the design or manufacture of the part. Motorola and are registered trademarks of Motorola, Inc. Motorola, Inc. is an Equal
Opportunity/Affirmative Action Employer.
How to reach us:
USA/EUROPE/Locations Not Listed: Motorola Literature Distribution; JAPAN: Nippon Motorola Ltd.; Tatsumi–SPD–JLDC, 6F Seibu–Butsuryu–Center,
P.O. Box 5405, Denver, Colorado 80217. 303–675–2140 or 1–800–441–2447 3–14–2 Tatsumi Koto–Ku, Tokyo 135, Japan. 81–3–3521–8315
Mfax: RMFAX0@email.sps.mot.com – TOUCHTONE 602–244–6609 ASIA /PACIFIC: Motorola Semiconductors H.K. Ltd.; 8B Tai Ping Industrial Park,
INTERNET: http://Design–NET.com 51 Ting Kok Road, Tai Po, N.T., Hong Kong. 852–26629298
4
◊
Mfax is a trademark of Motorola, Inc.
MBR2535CTL/D
Rectifier Device Data
Loading...