Drying Tumblers
25 Pound Capacity
30 Pound Capacity
35 Pound Capacity
55 Pound Capacity
Starting Serial No. 0602004144
Refer to Page 3 for Model Numbers
Keep These Instructions for Future Reference.
(If this machine changes ownership, this manual must accompany machine.)
|
|
|
www.comlaundry.com |
Part No. 70400001R4 |
|
|
|
||
|
|
|
August 2008 |
Operation/Maintenance
Installation must conform with local codes or in the absence of local codes with:
In the U.S.A., installation must conform to the latest edition of the American National Standard Z223.1/ NFPA 54 “National Fuel Gas Code” and Standard ANSI/NFPA 70 “National Electric Code.”
In Canada, installation must comply with Standards CAN/CSA-B149.1 or Natural Gas and Propane Code CSA C22.1, latest edition, Canadian Electric Code, Part I.
In Australia, installation must comply with the Australian Gas Association Installation Code for Gas Burning Appliances and Equipment.
WARNING
FOR YOUR SAFETY, the information in this manual must be followed to minimize the risk of fire or explosion or to prevent property damage, personal injury or death.
W033
•Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
•WHAT TO DO IF YOU SMELL GAS:
–Do not try to light any appliance.
–Do not touch any electrical switch; do not use any phone in your building.
–Clear the room, building or area of all occupants.
–Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.
–If you cannot reach your gas supplier, call the fire department.
•Installation and service must be performed by a qualified installer, service agency or the gas supplier.
W052
FOR YOUR SAFETY
Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
W053
MISE EN GARDE
POUR VOTRE SÉCURITÉ, les informations de ce guide doivent être respectées afin de réduire les risques d’incendie, d’explosion ou d’éviter les dommages matériels, personnels ou blessures mortelles.
W033R3QU
•Ne pas entreposer ou utiliser d’essence ou toutes autres vapeurs et liquides inflammables à proximité de cette machine ou de tout autre appareil.
•QUE FAIRE EN CAS D’ODEUR DE GAZ :
–Ne pas mettre d’appareil en marche.
–Ne pas toucher aux interrupteurs électriques ; ne pas utiliser le téléphone des lieux.
–Évacuer la pièce, le bâtiment ou la zone de tous les occupants.
–Appeler immédiatement le fournisseur de gaz de la maison d’un voisin. Respecter les instructions communiquées par le fournisseur.
–Si vous ne pouvez pas joindre le fournisseur de gaz, appeler le service d’incendie.
•L’installation et l’entretien doivent être effectués par un installateur, service d’entretien qualifiés ou par le fournisseur de gaz.
W052R5QU
POUR VOTRE SÉCURITÉ
Ne pas entreposer ou utiliser d’essence ou toutes autres vapeurs et liquides inflammables à proximité de cette unité ou de tout autre appareil.
W053R2QU
IMPORTANT: Information must be obtained from a local gas supplier on instructions to be followed if the user smells gas. These instructions must be posted in a prominent location. Step-by-step instructions of the above safety information must be posted in a prominent location near the tumbler for customer use.
70400001 |
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT |
1 |
Table of
Contents
Introduction......................................................................................... |
3 |
Model Identification ............................................................................. |
3 |
Customer Service.................................................................................. |
4 |
Serial Plate Location............................................................................. |
4 |
Wiring Diagram .................................................................................... |
4 |
Safety Information.............................................................................. |
5 |
Explanation of Safety Messages........................................................... |
5 |
Important Safety Instructions ............................................................... |
6 |
Operating Instructions ....................................................................... |
8 |
Emergency Stop Button on CE Models................................................ |
8 |
Operating Instructions .......................................................................... |
8 |
Control Instructions .............................................................................. |
9 |
Dual Digital Timer Control.............................................................. |
9 |
Single Drop Control......................................................................... |
11 |
Preliminary Control Information ..................................................... |
11 |
Diagnostic Microprocessor Control................................................. |
13 |
DMP Coin ........................................................................................ |
14 |
DMP OPL Models ........................................................................... |
16 |
Ignition Control Operation ................................................................... |
19 |
Maintenance ........................................................................................ |
21 |
Daily ..................................................................................................... |
21 |
Monthly................................................................................................. |
23 |
Quarterly ............................................................................................... |
23 |
Bi-Annually .......................................................................................... |
23 |
Annually ............................................................................................... |
23 |
Before You Call for Service ............................................................... |
27 |
Customer Service.................................................................................. |
27 |
© Copyright 2008, Alliance Laundry Systems LLC
All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher.
2 |
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT |
70400001 |
Introduction
Model Identification
Information in this manual is applicable to these models:
|
|
Gas |
Steam |
Electric |
|
|
|
|
|
|
|
|
CHD25G2-CA025L |
DR25G2-BA025N |
CHD25S2-CT025S |
CHD25E2-CT025E |
|
|
CHD25G2-CA025N |
DR25G2-BT025L |
CHD25S2-CU025S |
CHD25E2-CU025E |
|
|
CHD25G2-CT025L |
DR25G2-BT025N |
DR25S2-BT025S |
DR25E2-BT025E |
|
25 Pound |
CHD25G2-CT025N |
DR25G2-BU025L |
DR25S2-BU025S |
DR25E2-BU025E |
|
|
CHD25G2-CU025L |
DR25G2-BU025N |
IPD25S2-IT025S |
IPD25E2-IT025E |
|
|
CHD25G2-CU025N |
IPD25G2-IT025L |
|
|
|
|
DR25G2-BA025L |
IPD25G2-IT025N |
|
|
|
|
|
|
|
|
|
|
CHD30G2-CA030L |
DR30G2-BT030D |
CHD30S2-CT030S |
CHD30E2-CT030E |
|
|
CHD30G2-CA030N |
DR30G2-BT030L |
CHD30S2-CU030S |
CHD30E2-CU030E |
|
|
CHD30G2-CT030L |
DR30G2-BT030N |
DR30S2-BT030S |
DR30E2-BT030E |
|
30 Pound |
CHD30G2-CT030N |
DR30G2-BU030L |
DR30S2-BU030S |
DR30E2-BU030E |
|
CHD30G2-CU030L |
DR30G2-BU030N |
IPD30S2-IT030S |
IPD30E2-IT030E |
||
|
|||||
|
CHD30G2-CU030N |
IPD30G2-IT030L |
|
|
|
|
DR30G2-BA030L |
IPD30G2-IT030N |
|
|
|
|
DR30G2-BA030N |
|
|
|
|
|
|
|
|
|
|
|
CHD35G2-CA035L |
DR35G2-BA035N |
CHD35S2-CT035S |
CHD35E2-CT035E |
|
|
CHD35G2-CA035N |
DR35G2-BT035L |
CHD35S2-CU035S |
CHD35E2-CU035E |
|
|
CHD35G2-CT035L |
DR35G2-BT035N |
DR35S2-BT035S |
DR35E2-BT035E |
|
35 Pound |
CHD35G2-CT035N |
DR35G2-BU035L |
DR35S2-BU035S |
DR35E2-BU035E |
|
|
CHD35G2-CU035L |
DR35G2-BU035N |
IPD35S2-IT035S |
IPD35E2-IT035E |
|
|
CHD35G2-CU035N |
IPD35G2-IT035L |
|
|
|
|
DR35G2-BA035L |
IPD35G2-IT035N |
|
|
|
|
|
|
|
|
|
|
CA055L |
CU055L |
|
CT055E |
|
55 Pound |
CA055N |
CU055N |
Not Applicable |
CU055E |
|
CT055L |
IPD55G2-IT055L |
IPD55E2-IT055E |
|||
|
|
||||
|
CT055N |
IPD55G2-IT055N |
|
|
|
|
|
|
|
|
Includes the following control suffixes:
3O |
– DX4 OPL |
DO – DMP OPL |
QT – dual digital timer |
3V |
– DX4 vended |
DV – DMP vended |
SD – single drop |
3X |
– DX4 prep for coin |
DX – DMP prep for coin |
SX – single drop, prep for coin |
70400001 |
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT |
3 |
Introduction
Customer Service
If literature or replacement parts are required, contact the source from which the machine was purchased or contact Alliance Laundry Systems at (920) 748-3950 for the name and address of the nearest authorized parts distributor.
For technical assistance, call (920) 748-3121.
Serial Plate Location
Model and serial numbers are found on serial plate on rear of machine, and inside the loading door hinge. Refer to Figure 1.
Wiring Diagram
The wiring diagram is located inside the junction or contactor box. The wiring diagram part number is in the lower portion of the electrical data on the serial plate.
1
TMB2098N
1 Serial Plate
Figure 1
4 |
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT |
70400001 |
Safety Information
Explanation of Safety Messages
Precautionary statements (“DANGER,” “WARNING,” and “CAUTION”) followed by specific instructions, are found in this manual and on machine decals. These precautions are intended for the personal safety of the operator, user, servicer, and those maintaining the machine.
DANGER
Indicates an imminently hazardous situation that, if not avoided, will cause severe personal injury or death.
WARNING
Indicates a hazardous situation that, if not avoided, could cause severe personal injury or death.
CAUTION
Indicates a hazardous situation that, if not avoided, may cause minor or moderate personal injury or property damage.
Additional precautionary statements (“IMPORTANT” and “NOTE”) are followed by specific instructions.
IMPORTANT: The word “IMPORTANT” is used to inform the reader of specific procedures where minor machine damage will occur if the procedure is not followed.
NOTE: The word “NOTE” is used to communicate installation, operation, maintenance or servicing information that is important but not hazard related.
IMPORTANT: Warranty is void unless tumbler is installed according to instructions in the Installation Manual. Compliance with minimum specifications and requirements detailed herein, and with applicable local gas fitting regulations,
municipal building codes, water supply regulations, electrical wiring regulations, and any other relevant statutory regulations. Because of varied requirements, applicable local codes should be thoroughly understood and all pre-installation work arranged for accordingly.
WARNING
Failure to install, maintain, and/or operate this machine according to manufacturer’s instructions may result in conditions which can produce serious injury, death and/or property damage.
W051R1
NOTE: The WARNING and IMPORTANT instructions appearing in this manual are not meant to cover all possible conditions and situations that may occur. It must be understood that common sense, caution and carefulness are factors which CANNOT be built into this tumbler. These factors MUST BE supplied by the person(s) installing, maintaining or operating the tumbler.
Always contact your dealer, distributor, service agent or the manufacturer on any problems or conditions you do not understand.
70400001 |
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT |
5 |
Safety Information
Important Safety Instructions
Save These Instructions
WARNING
Hazardous Voltage. Can cause shock, burn or cause death. Allow machine power to remain off for two minutes prior to working in and around AC inverter drive.
W359
1.Read all instructions before using the tumbler.
2.Refer to the GROUNDING INSTRUCTIONS for the proper grounding of the tumbler.
3.Do not dry articles that have been previously cleaned in, washed in, soaked in, or spotted with gasoline, dry cleaning solvents, other flammable or explosive substances as they give off vapors that could ignite or explode.
4.Do not allow children on or in the tumbler. This appliance is not intended for use by young children or infirm persons without supervision. Young children should be supervised to ensure that they do not play with the appliance.
5.Before the tumbler is removed from service or discarded, remove the door to the drying compartment and the door to the lint compartment.
6.Do not reach into the tumbler if the cylinder is revolving.
7.Do not install or store the tumbler where it will be exposed to water and/or weather.
8.Do not tamper with the controls.
9.Do not repair or replace any part of the tumbler, or attempt any servicing unless specifically recommended in the user-maintenance instructions or in published user-repair instructions that you understand and have the skills to carry out.
10.Do not use fabric softeners or products to eliminate static unless recommended by the manufacturer of the fabric softener or product.
11.To reduce the risk of fire, DO NOT DRY plastics or articles containing foam rubber or similarly textured rubberlike materials.
12.Always clean the lint filter daily.
13.Keep area around the exhaust opening and adjacent surrounding area free from the accumulation of lint, dust and dirt.
14.The interior of the tumbler and the exhaust duct should be cleaned periodically by qualified service personnel.
15.If not installed, operated and maintained in accordance with the manufacturer’s instructions or if there is damage to or mishandling of this product’s components, use of this product could expose you to substances in the fuel or from fuel combustion which can cause death or serious illness and which are known to the State of California to cause cancer, birth defects or other reproductive harm.
16.Tumbler will not operate with the loading door open. DO NOT bypass the door safety switch to permit the tumbler to operate with the door open. The tumbler will stop tumbling when the door is opened. Do not use the tumbler if it does not stop tumbling when the door is opened or starts tumbling without pressing or turning the START mechanism. Remove the tumbler from use and call for service.
17.Tumbler will not operate with lint panel open. DO NOT bypass lint panel safety switch to permit the tumbler to operate with the lint panel open.
18.Do not put articles soiled with vegetable or cooking oil in the tumbler, as these oils may not be removed during washing. Due to the remaining oil, the fabric may catch on fire by itself.
19.To reduce the risk of fire, DO NOT put clothes which have traces of any flammable substances such as machine oil, flammable chemicals, thinner, etc. or anything containing wax or chemicals such as in mops and cleaning cloths, or anything dry-cleaned at home with dry-cleaning solvent in the tumbler.
20.Use the tumbler only for its intended purpose, drying fabrics.
21.ALWAYS disconnect and lockout the electrical power to the tumbler before servicing. Disconnect power by shutting off appropriate breaker or fuse.
22.Install this tumbler according to the INSTALLATION INSTRUCTIONS. All connections for electrical power, grounding, and gas supply must comply with local codes and be made by licensed personnel when required.
6 |
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT |
70400001 |
23.Remove laundry immediately after tumbler stops.
24.Always read and follow manufacturer’s instructions on packages of laundry and cleaning aids. Heed all warnings or precautions. To reduce the risk of poisoning or chemical burns, keep them out of reach of children at all times (preferably in a locked cabinet).
25.Do not tumble fiberglass curtains and draperies unless the label says it can be done. If they are dried, wipe out the cylinder with a damp cloth to remove particles of fiberglass.
26.Always follow the fabric care instructions supplied by the garment manufacturer.
27.Never operate the tumbler with any guards and/or panels removed.
Safety Information
28.DO NOT operate the tumbler if it is smoking, grinding, has missing or broken parts.
29.DO NOT bypass any safety devices.
30.Solvent vapors from dry-cleaning machines create acids when drawn through the heater of the drying unit. These acids are corrosive to the tumbler as well as to the laundry load being dried. Be sure make-up air is free of solvent vapors.
31.Failure to install, maintain, and/or operate this machine according to the manufacturer’s instructions may result in conditions which can produce bodily injury and/or property damage.
WARNING
To reduce the risk of serious injury, install lockable door(s) to prevent public access to rear of tumblers.
W055
70400001 |
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT |
7 |