GAS
COOKER
ZCG 640
ZCG 641
INSTRUCTION BOOKLET
Please read this instruction booklet before using the appliance
GB
Important Safety Information
You MUST read these warnings carefully before installing or using the hob. If you need assistance, contact our Customer Care Department on 08705 727727
Installation
•This appliance must be installed and serviced by a competent person as stated in the Gas Safety ( Installation and Use) Regulations Current Editions and the IEE Wiring Regulations.
•For appliances installed in the Republic of Ireland please refer to NSAI-Domestic Gas Installations I.S.813 Current Editions and the ETCI Rules for Electrical Installations.
•This cooker is heavy. Take care when moving it.
•Remove all packaging before using the cooker.
•Ensure that the gas and electrical supply complies with the type stated on the rating plate, located near the gas supply pipe.
•Do not attempt to modify the cooker in any way.
•Unstable or misshapen pans should not be used on the hob burners as unstable pans can cause an accident by tipping or spillage.
•Never leave the cooker unattended when cooking with oil and fats.
•This cooker should be kept clean at all times. A build-up of fats or foodstuffs could result in a fire.
•Never use plastic dishes in the oven or on the hob burners. Never line any part of the oven with aluminium foil.
•Always ensure that the oven vent which is located at the centre back of the hob is left unobstructed to ensure ventilation of the oven cavity.
•Perishable food, plastic items and areosols may be affected by heat and should not be stored above the cooker.
Child Safety
•This cooker is designed to be operated by adults. Do not allow children to play near or with the cooker.
•The cooker gets hot when it is in use. Children should be kept away until it has cooled.
•Children can also injure themselves by pulling pans or pots off the cooker.
During Use
•This cooker is intended for domestic cooking only. It is not designed for commercial or industrial purposes.
•When in use a gas cooker will produce heat and moisture in the room in which it has been installed. Ensure there is a continuous air supply, keeping air vents in good condition or installing a cooker hood with a venting hose.
•When using the cooker for a long period of time, the ventilation should be improved, by opening a window or increasing the extractor speed.
•Do not use this cooker if it is in contact with water. Do not operate the cooker with wet hands.
•Ensure the control knobs are in the ‘OFF’ position when not in use.
•During use the appliance becomes hot. Care should be taken to avoid touching heating elements inside the oven.
•When using other electrical appliances, ensure the cable does not come into contact with the hot surfaces of the cooker.
Service
•This cooker should only be repaired or serviced by an authorised Service Engineer and only genuine approved spare parts should be used.
Environmental Information
•After installation, please dispose of the packaging with due regard to safety and the environment.
•When disposing of an old appliance, make it unusable, by cutting off the cable.
Keep this instruction book for future reference and ensure it is passed on to any new owner.
This appliance is manufactured according to the following EEC directives:
73/23 EEC - 90/683 EEC - 93/68 EEC - 89/336 EEC - 90/396 EEC,
current edition.
These instructions are only valid in the countries whose symbols appear on this booklet's cover.
2
Contents
For the User |
|
For the Installer |
|
Important Safety Information |
2 |
Guarantee Conditions |
13 |
Control Panel |
4 |
Important Safety Requirements |
14 |
The Gas Hob Controls |
5 |
Instructions for the Installer |
14 |
The Gas Oven and Electric Grill Control |
5 |
Installation |
15 |
Before the First Use of the Cooker |
6 |
Electrical Connections |
17 |
Using the Oven |
6 |
Commissioning |
18 |
The Minute Minder |
7 |
Conversion from Natural to LPG Gas |
18 |
Using the Gas oven |
7 |
|
|
Gas Oven Cooking Chart |
8 |
|
|
Grilling |
9 |
|
|
Maintenance and Cleaning |
10 |
|
|
Cleaning the Oven |
10 |
|
|
Something Not Working |
12 |
|
|
Service and Spare Parts |
12 |
|
|
Customer Care |
13 |
|
|
Guide to Use the Instructions
The following symbols will be found in the text to guide you throughout the Instructions:
Safety Instructions
Step by step instructions for an operation
Hints and Tips
Environmental Information
3
Control Panel
1
2 |
3 |
4 |
5 |
6 |
7 |
8 |
9 |
1.Electric ignition button
2.Oven Light button
3.Back left burner control knob (semi-rapid)
4.Front left burner control knob (rapid)
5.Front right burner control knob (auxiliary)
6.Back right burner control knob (semi-rapid)
7.Gas Oven and Electric Grill control knob
8.Minute Minder
9.Grill function Pilot Light
The Oven Cavity |
Accessories |
|
|
Grill/roasting pan |
Grill trivet |
||
|
|||
|
|
||
Electric Grill |
Oven Light |
|
Removable
handles
2 anti-tip
Gas Oven shelves Bottom
Plate
4
The Gas Hob Controls
To light a burner:
-Push the electric ignition button which is marked with a little spark (
).
-At the same time push in and turn the relevant control knob anticlockwise to maximum position.
-Then adjust the flame as required.
If the burner does not ignite, turn the control knob to zero, and try again.
When switching on the mains, after installation or a power cut, it is quite normal for the spark generator to be activated automatically.
To ensure maximum burner efficiency, you should only use pots and pans with a flat bottom fitting the size of the burner used (see table).
Burner |
minimum |
maximum |
|
diameter |
diameter |
|
|
|
Large(rapid) |
180 mm. |
260 mm. |
Medium(semi-rapid) |
120 mm. |
220 mm. |
Small (Auxiliary) |
80 mm. |
160 mm. |
|
|
|
If you use a saucepan which is smaller than the recommended size, the flame will spread beyond the bottom of the pan, causing the handle to overheat.
As soon as a liquid starts boiling, turn down the flame so that it will barely keep the liquid simmering.
Take care when frying food in hot oil or fat, as the overheated splashes could easily ignite.
If the control knobs become difficult to turn, please contact your local Service Force Centre.
Gas Oven and Electric Grill Control
Oven Function Control Knob
Oven switched off
150-240 Range of temperature regulation for gas oven
Grill - The heat comes only from the top element
Grill function pilot light
The grill function pilot light will come on when the oven function control knob is turned to 
.
Oven light push button 
This button will turn the oven light on.
5
The Minute Minder
The minute minder will mark the end of a timed period with an acoustic alarm. The maximum timing is 60 minutes.
Turn the Minute Minder knob clockwise to the maximum time position, then turn it back to the required time. The Minute minder will not affect in any way the oven operation, if it is in use.
Before the First Use of the Cooker
Remove all packaging, both inside and outside the cooker, before using it.
Before first use, the oven should be heated without food. During this time, an unpleasant odour may be emitted. This is quite normal.
1.Ignite the gas oven burner and set the gas oven control knob to "240".
2.Open a window for ventilation.
3.Allow the oven to run empty for approximately 45 minutes.
This procedure should be repeated with the grill 
function for approximately 5-10 minutes.
Do not clean the oven while it is still warm.
Using the Oven
Always cook with the oven door closed.
Stand clear when opening the drop down oven door. Do not allow it to fall open - support the door using the door handle, until it is fully open.
The oven has four shelf levels, and is supplied with two shelves.
The shelf positions are counted from the bottom of the oven as shown in the diagram.
It is important that these shelves are correctly positioned.
Do not place cookware directly on the oven base.
4 |
3 |
2 |
1 |
6
Loading...