Vulcan-Hart VW4D, VW3S, VW1S, VW2DB, VW2S User Manual

...
0 (0)
Vulcan-Hart VW4D, VW3S, VW1S, VW2DB, VW2S User Manual

INSTALLATION &

OPERATION MANUAL

VW SERIES DRAWER WARMERS

MODELS

 

VW1S

ML-126500

VW2S

ML-126502

VW3S

ML-126504

VW4S

ML-126506

VW1SB

ML-126501

VW2SB

ML-126503

VW3SB

ML-126505

VW4SB

ML-126507

VW1D

ML-126508

VW2D

ML-126510

VW3D

ML-126512

VW4D

ML-126514

VW1DB

ML-126509

VW2DB

ML-126511

VW3DB

ML-126513

VW4DB

ML-126515

VW1C

ML-126516

VW2C

ML-126518

VW1CB

ML-126517

VW2CB

ML-126519

VULCAN-HART COMPANY,

P.O. BOX 696, LOUISVILLE, KY 40201-0696, TEL. (502) 778-2791

FORM 31086 Rev. A (12-98)

– 1 –

TABLE OF CONTENTS

 

GENERAL.............................................................................................................................................

3

INSTALLATION ....................................................................................................................................

3

Unpacking .................................................................................................................................

3

Location ....................................................................................................................................

4

Installation Codes and Standards ...........................................................................................

4

Electrical Connections .............................................................................................................

4

Wiring Diagrams .......................................................................................................................

6

OPERATION ........................................................................................................................................

9

Controls ....................................................................................................................................

9

Before First Use .......................................................................................................................

9

Operating Drawer Warmer.....................................................................................................

10

Cleaning ..................................................................................................................................

11

MAINTENANCE .................................................................................................................................

11

Service and Parts Information ...............................................................................................

11

© VULCAN-HART COMPANY, 1998

– 2 –

Installation, Operation and Care of

MODEL VW SERIES DRAWER WARMERS

PLEASE KEEP THIS MANUAL FOR FUTURE USE

GENERAL

Vulcan-Hart Drawer Warmers are produced with quality workmanship and material. Proper installation, usage, and maintenance of your drawer warmer will result in many years of satisfactory performance.

It is suggested that you thoroughly read this entire manual and carefully follow all of the instructions provided.

The VW Series Drawer Warmers provide an efficient means of holding a variety of prepared hot food products at proper temperatures until serving.

VW-S and VW-SB series have a large 15x20" (38x51cm) over-sized drawer insert.

VW-D, VW-C, VW-CB, and VW-DB series have a standard 12x20x4" (30x51x10 cm) steam table pan insert.

INSTALLATION

Before installing, verify that the electrical service agrees with the specifications on the rating plate located on the lower rear corner of the drawer warmer. If the supply and equipment requirements do not agree, do not proceed with the installation. Contact your Vulcan-Hart office immediately.

UNPACKING

This drawer warmer was inspected before leaving the factory. The transportation company assumes full responsibility for safe delivery upon acceptance of the shipment. Immediately after unpacking, check for possible shipping damage to the drawer warmer. If the drawer warmer is found to be damaged, save the packaging material and contact the carrier within 15 days of delivery.

Carefully unpack drawer warmer and place in a work-accessible area.

1.Remove banding material holding the carton to the pallet.

2.Remove cardboard carton and plastic bag covering drawer warmer.

3.Carefully lift drawer warmer off carton bottom and place it on the floor or table.

4.Remove legs from the drawer of the drawer warmer.

5.Secure legs to the bottom of the drawer warmer by screwing legs into the holes provided.

6.Remove any and all packaging materials in drawers.

3 –

LOCATION

For efficient drawer warmer operation, choose a location that will provide easy loading and unloading without interfering with the final assembly of food orders.

The installation location must allow adequate clearances for servicing and proper operation.

INSTALLATION CODES AND STANDARDS

The drawer warmer must be installed in accordance with:

In the United States of America:

1.State and local codes.

2.National Electrical Code, ANSI/NFPA-70 (latest edition). Copies may be obtained from The National Fire Protection Association, Batterymarch Park, Quincy, MA 02269.

In Canada:

1.Local codes.

2.Canadian Electrical Code, CSA C22.1 (latest edition). Copies may be obtained from The Canadian Standard Association, 178 Rexdale Blvd., Etobicoke, Ontario, Canada M9W 1R3.

ELECTRICAL CONNECTIONS

WARNING: ELECTRICAL AND GROUNDING CONNECTIONS MUST COMPLY WITH THE APPLICABLE PORTIONS OF THE NATIONAL ELECTRICAL CODE AND/OR OTHER LOCAL ELECTRICAL CODES.

WARNING: DISCONNECT ELECTRICAL POWER SUPPLY AND PLACE A TAG AT THE DISCONNECT SWITCH TO INDICATE YOU ARE WORKING ON THE CIRCUIT.

WARNING: THIS APPLIANCE IS EQUIPPED WITH A FLEXIBLE ELECTRIC SUPPLY CORD PROVIDED WITH A THREE-PRONG GROUNDING PLUG. THIS PLUG MUST BE CONNECTED INTO A PROPERLY GROUNDED THREE-PRONG RECEPTACLE. IF THE RECEPTACLE IS NOT THE PROPER GROUNDING TYPE, CONTACT AN ELECTRICIAN. DO NOT REMOVE THE GROUNDING PRONG FROM THIS PLUG.

All VW-S, VW-SB, VW-D, VW-DB are equipped with a 6 foot cord.

All VW-C are equipped with an 8 foot cord.

Refer to wiring diagrams in this manual (see pages 6-8).

– 4 –

Loading...
+ 8 hidden pages