Care & Use Manual
for
Thermador
Char Glo® Outdoor Barbecues
Models:
CGB30CZLP • CGB36FZLP • CGB48FZLP • CGB48FSZLP
CGB30CZLP |
CGB36FZLP |
CGB48FSZLP
A Special Message to Our Customers
Thank you for selecting the Thermador Char Glo® outdoor barbecue. We recommend that you take time to read this entire booklet before using your new appliance for the first time.
This booklet contains suggestions we believe will be helpful as well as directions for using all the features of your appliance. Keep it in a handy place as it has the answers to questions that may occur when you start to cook.
Let us know if we can help you. When you write please include the model and serial numbers of your barbecue.
Sincerely,
Thermador Test Kitchen Consumer Scientists
TABLE OF CONTENTS |
|
Warnings for Safe Gas Installations .......................................................... |
2 |
For Your Safety ........................................................................................................... |
2 |
What To Do If You Smell Gas ................................................................................. |
2 |
Important Information ............................................................................................. |
3 |
Warnings for Safe Gas Installations ....................................................................... |
3 |
Warning: California Proposition 65 B .................................................................. |
3 |
Section 1: Safety Practices to Avoid Personal Injury ....................... |
4 |
Important Safety Instructions .......................................................................... |
4 – 5 |
Section 2: Model and Parts Identification ............................................. |
6 |
Model CGB48FSZLP ................................................................................................. |
6 |
Model CGB48FZLP ................................................................................................... |
7 |
Model CGB30CZLP .................................................................................................. |
8 |
Model CGB36FZLP ................................................................................................... |
9 |
Installation of LP (Propane) Gas Tank ................................................................. |
10 |
LP Lighting Instructions .......................................................................................... |
10 |
Section 3: UsingYour Char Glo® Barbecue......................................... |
11 |
Before The First Use ............................................................................................... |
11 |
Lighting Instructions with Automatic Ignition ................................................... |
12 |
Lighting Instructions for Manual Lighting ........................................................... |
13 |
Section 4: The Grill ........................................................................................ |
14 |
General Grill Information ...................................................................................... |
14 |
Using the Grill .......................................................................................................... |
14 |
General Smoker Information ................................................................................ |
15 |
Using the Smoker .................................................................................................... |
15 |
Grilling Chart ................................................................................................. |
16 – 17 |
Section 5: The Rotisserie ............................................................................. |
18 |
Using the Rotisserie ................................................................................................ |
18 |
General Rotisserie Information ........................................................................... |
18 |
Rotisserie Assembly ................................................................................................ |
18 |
Trussing Poultry ....................................................................................................... |
19 |
Rotisserie Chart ...................................................................................................... |
20 |
Thermometer Gauge .............................................................................................. |
20 |
Section 6: Extra Features ........................................................................... |
21 |
General Side Burner Information ........................................................................ |
21 |
Using the Side Burners ....................................................................................... |
21 |
Side Shelf.................................................................................................................... |
21 |
Section 7: Care And Maintenance ........................................................... |
22 |
Quick Clean Method for Grates ......................................................................... |
22 |
Quick Clean Method for the Grill....................................................................... |
22 |
Quick Clean Method for the Drip Tray .............................................................. |
22 |
Cleaning Chart ......................................................................................................... |
23 |
Section 8: Service ............................................................................................ |
24 |
Before Phoning for Service ................................................................................... |
24 |
Troubleshooting ....................................................................................................... |
24 |
Section 9: Warranty ....................................................................................... |
25 |
Page 1
WARNINGS FOR SAFE GAS INSTALLATIONS
Installer: Please leave these instructions with the unit for the owner. Owner: Please retain these instructions for future reference.
! |
WARNING: If the information in this manual is not followed exactly, a fire or |
▲ |
explosion may result causing property damage, personal injury or death. |
FOR YOUR SAFETY
Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS
•Shut off gas to the appliance.
•Extinguish any open flame.
•Open Lid.
•If odor continues, immediately phone your gas supplier.
•If you cannot reach your gas supplier, call the fire department.
AVERTISSEMENT
Ne pas entreposer ni utiliser de l‘essence ni d’autres vapeurs ou liquides inflammables dans le voisinage de l’appareil, ni de tout autre appareil.
S’ILY A UNE ODEUR DE GAZ:
•Coupez l’admission de gaz de l’appariel.
•Ènteindre toute flamme nue.
•Ouvrir le couvercle.
•Si l’odeur peraiste, appeler immediatement votre compagnie de gaz ou votre departement des incendies.
Installation and service must be performed by a qualified installer, service agency or the gas supplier.
TESTED IN ACCORDANCE WITH ANSI Z21.58-1998, STANDARD FOR OUTDOOR COOKING GAS APPLIANCES AND CAN/CGA 1.6-M98, STANDARD FOR OUTDOOR COOKING GAS APPLIANCES.
This unit is for outdoor use only in a well-ventilated area. Not to be used in a building, garage or any other enclosed area.
Check your local building codes for the proper method of installation. In the absence of local codes this unit should be installed in accordance with the National Fuel Gas Code No. Z223.1 Current Issue and National Electrical Code ANSI/NFPA No. 70 Current Issue or the CAN/CGA - B149.1 Natural Gas Installation Code or CAN/CGA - B149.2 Propane Gas Installation Code and C22.1 Canadian Electrical Code Part 1.
Page 2
WARNINGS FOR SAFE GAS INSTALLATIONS
IMPORTANT INFORMATION
This outdoor gas cooking appliance is not intended to be installed in or on recreational vehicles and/or boats.
Always inspect the natural gas or LP gas hose assembly before each use of the appliance. If there is evidence of excessive abrasion or wear, or if the hose is cut, it must be replaced prior to the appliance being put into operation. Replacement hose assemblies can be purchased at barbecue supply stores, or ordered through Thermador® (see the rear cover for contact information). If purchased at a retail outlet, the hose assembly must be identical to the one supplied with the unit. To inspect the hose assembly inside the unit, open the left door on model CGB30CZLP or slide out the left storage drawer on models CGB36FZLP, CGB48FSZLP and CGB48FZLP.
Keep the area around the appliance clear and free from combustible materials, gasoline and other flammable vapors and liquids.
Do not place any items in front of the unit while in use. This could obstruct the proper flow of air needed for proper combustion and ventilation.
Keep the ventilation opening(s) of the LP cylinder enclosure free and clear of obstructions and debris.
Keep any electrical supply cord and the fuel supply hose away from any heated surfaces.
Do not leave the grill unattended while cooking.
The appliance shall not be located under overhead unprotected combustible construction.
WARNING: CALIFORNIA PROPOSITION 65 B
The burning of gas cooking fuel generates some byproducts that are on the list of substances which are known by the State of California to cause cancer or reproductive harm. California law requires businesses to warn customers of potential
exposure to such substances. To minimize exposure to these substances, always operate this unit according to the instructions contained in this booklet and provide good ventilation when cooking with gas.
Page 3
SECTION 1: SAFETY PRACTICESTO AVOID PERSONAL INJURY
IMPORTANT SAFETY INSTRUCTIONS
READ ALL INSTRUCTIONS BEFORE USING YOUR BARBECUE
SAFETY PRECAUTIONS
When properly cared for, your new Thermador Char Glo® barbecue has been designed to be a safe and reliable appliance. However, extreme care must be used as the grill produces intense heat and can increase the potential for accidents or injury. When using this appliance, basic safety precautions must be followed, including the following:
•Read this manual carefully before using the barbecue to reduce the risk of fire, electric shock, or injury to persons.
•Insure proper installation.Follow the instructions in Sections 3 through 5 in the Installation Instructions. Have the installer show you where the gas supply shutoff valve is located, and how to shut off the gas to the barbecue. Always adhere to the minimum clearances to combustible materials as specified in Section 3.
•Do not repair or replace any part of this appliance unless specifically recommended in this manual. All other servicing should be referred to a qualified service technician.
•If you smell gas when the unit is not in use, have the unit checked for leaks as defined in Section 4 and Section 5 of the Installation Instructions. Finding a gas leak is not a do-it-yourself procedure as some leaks can only be found with the burner control in the ON position. This must be done by a qualified technician.
•If you smell gas when the unit is in use, immediately shut off all controls. Open the lid and let the gas dissipate for at least five minutes. Relight the burner(s) and verify that they are operating properly. If the burner(s) fail to relight or are not operating properly, shut of the gas to the unit and have the unit checked by a qualified service technician. See Section 9.
•Children should not be left unattended in the area where the barbecue is being used. Never allow children to sit, stand or play on or around the barbecue at any time. When in use, portions of the grill get hot enough to cause severe burns. Children should never be allowed to crawl inside the cart or enclosure.
•To avoid the potential for a grease fire,frequently clean the drip tray. Be sure to let the unit cool completely before removing the tray for cleaning.
•This appliance is equipped with a three-prong (grounding) plug for your protection against shock hazard and should be plugged directly into a properly grounded three-prong receptacle. Do not cut or remove the grounding prong from this plug.
•Be aware that spiders and insects can nest in the burners of this barbecue. This can obstruct the proper flow of gas into the burner and cause improper operation, fire hazard and potential damage to the unit. Inspect the burners periodically, or immediately if any of the symptoms denoted in Section 8 exist.
•The top cover (hood) is to be closed during the outdoor cooking gas appliance preheat period.
•Never move barbecue with hood raised.
•Keep hands and fingers away from all edges of the hood when it is in raised position.
▲! WARNING
Never block vent opening at rear of hood. Use with the vent opening blocked will result in damage to the unit and may cause a fire or injury.
▲! CAUTION
Always use wood chips that have been soaked in water. Place the chips in the back half of the smoker tray. Failure to soak chips may result in a fire and damage the unit.
Wood Chip
Smoker
Tray
Page 4
FORYOUR SAFETY
• The gas supply must be turned off at the LP-gas supply tank when this outdoor cooking gas appliance is not in use.
AVERTISSEMENT
• L’alimentation du gaz doit étre fennée a la bouteille de gaz de pétrole liquéfié, lorsque cet appareil de cuisson extérieur n’ est pas utilisé.
LP TANK REQUIREMENTS
All free-standing units are provided with an LP tank from the factory. All other units can be converted for use with an LP tank which can be purchased locally at a barbecue supply store or other retail outlet. The maximum tank capacity for use with Thermador® Char Glo® barbecues is twenty pounds (five gallons). The tank must be constructed and marked in accordance with the specifications for LP-gas tanks of the U.S. Department of Transportation (DOT) or the National Standard of Canada, CAN/CSAB339, tank, Spheres and Tubes for the Transportation of Dangerous Goods. To minimize the potential for fire or an explosion, the following precautions should be observed when using, filling or storing an LP tank:
•Never use a dented or rusty LP tank. If there is any question as to the soundness of the tank, have it checked by your LP supplier.
•Never use a tank with a damaged or defective shut off valve.
•Always close the tank shut off valve after use.
•Do not overfill the LP tank. Never fill the LP tank beyond eighty percent (80%) of its capacity. Overfilling will cause the pressure relief valve on the tank to vent excess gas vapor. This vapor is combustible and can ignite, causing a fire.
•When transporting an LP tank, insure it is in an upright position and away from any sources of high heat.
•Do not store additional LP tanks inside the cart of the unit. Tanks must be stored outdoors in a wellventilated area out of direct sunlight and/or sources of high heat, and out of the reach of children. Disconnected cylinders must have threaded valve plugs tightly installed and must not be stored in a building, garage or any other enclosed area.
•LP tank supply system must be arranged for vapor withdrawal.
•LP tank used must include a collar to protect the tank valve.
FORYOUR SAFETY
An LP tank not connected for use shall not be stored in the vicinity of this or any other appliance.
AVERTISSEMENT
Une bouteille de propane qui n’est pas raccordée en vue de son utilisation,ne doit pas etre entreposée dans le voisinage de cet appareil ou de tout autre appareil.
•The LP tank must be disconnected and removed from the appliance if the appliance is to be stored indoors.
•Always check for leaks after every tank change.
See Section 5 of Installation Instructions.
FORYOUR SAFETY
For Outdoor Use Only. If stored indoors, detach and leave tank outdoors.
AVERTISSEMENT
Pour utlilisation a la l’extérieur seulement. Si l’appareil est entreposé à l’intérieur, enlever les bouteilles et les laisser a l’extérieur.
CAUTION
Simultaneous operation of rotisserie burners,smoker burner and grill burners on the HI setting is not recommended. Excessive temperatures could result.
Page 5
SECTION 2: MODEL AND PARTS IDENTIFICATION MODEL CGB48FSZLP
2
Front of hood
1
3
4
6
8
13 |
19 |
20
16
5
17
9
11
10
15 12
14
1.Hood / Lid with Handle
2.Thermometer Gauge and Thermador Nameplate
3.Infrared Rotisserie Burner (1)
4.Rotisserie Motor
5.Rotisserie Glow Igniter
6.Grill Grates:
6 on Model CGB36FZLP and CGB48FSZLP
8 on Model CGB48FZLP
7.Radiants (heating baffles shown Page 7)
8.Burners: 3 on CGB36FZLP and CGB48FSZLP
4 on CGB48FZLP
9.Drip Pan
10.Smoker Tray
11.Control Knobs
12.Ignition Switch
13.Lighting Instructions on control panel
14.LP Container / Storage Cabinet
15.Storage Drawers
16.Side Burners (cover shown in close up)
17.Sure-Lock™ shelves (2)
19.Data Rating Label (left side, under the chassis floor)
20.Front Caster with Lock.
Page 6
MODEL AND PARTS IDENTIFICATION MODEL CGB48FZLP
1 |
Rotisserie Glow |
|
|
Ergo |
5 |
Igniters (2) |
3 |
|
|
||
|
|
|
|
(2)
Literature Pack Contents:
Product Registration Card – Please
|
complete and return. Thank You. |
20 |
|
User's Manual: |
|
|
Care & Use Recommendations |
|
|
Grill /Rotisserie Cooking Charts |
|
|
Installation Instructions |
|
Orifices for Natural Gas Conversion
AGA and CGA Approved
Page 7
Loading...