Operator's Manual
REAR ENGINE RIDING MOWER SERIES 24
Reproduction |
|
Not |
for |
|
Model No. Description
7800784 2811524BV
7800785 2812524BVE
7800786 3014524BVE
7800787 3317524BVE
!
Manual No. 7104742 (Rev. ‘-’)
Thank You for purchasing this quality-built Snapper product. We’re pleased that you placed your confidence in the Snapper brand. When operated and maintained according to the instructions in this manual, your Snapper product will provide many years of dependable service.
This manual contains safety information to make you aware of the hazards and risks associated with the machine and how to avoid them. This machine is designed and intended only for finish cutting of established lawns and is not intended for any other purpose. It is important that you read and understand these instructions thoroughly before attempting to start or operate this equipment. Save these original instructions for future reference.
Complete the following information on your purchase.
Date of Purchase__________________________________________________________________
Retailer_________________________________________________________________________
|
|
Reproduction |
||
Retailer's Phone Number___________________________________________________________ |
||||
Equipment |
|
for |
|
|
|
Model Number______________________________________________________________ |
|||
|
|
Not |
|
|
|
Serial Number ______________________________________________________________ |
|||
Engine |
|
|
|
|
|
Model_________________________Type |
Code___________________ |
SNAPPER is a trademark of
Briggs & Stratton Power Products Group, LLC
Milwaukee, WI, USA.
Copyright © 2011, Briggs & Stratton Corporation
Milwaukee, WI, USA. All Rights Reserved.
Table of Contents
Operator Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4
Features and Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
Before Starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
Operator Seat Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10
Starting Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
Engaging Mower Blade . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13
Engaging Wheel Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13
Stopping Engine, Wheel Drive, Blade . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14
Setting Park Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15
Cutting Height Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15
Reverse Lockout Mechanism . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Maintenance Chart . . . . . . . . . . . . .for. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Engine Adjustments and Repairs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mower Deck and Component Adjus ments . . . . . . . . . . . . . . . . . . . . . . . .
Rear Engine Rider Drive C mp nen s . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mower Blade Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Mower Drive Belt Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Troubleshooting . . |
. Not. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . |
Warranty . . . . . . . |
.Reproduction. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . |
Slope Guide . . . . . |
|
|
. . . . . .17
. . . . . . .17
. . . . . . .18
. . . . . . .23
. . . . . . .24
. . . . . . .24
. . . . . . .27
. . . . . . .28
. . . . . . .29
. . . . . . .30
. . . . . .32
. . . . . .34
. . . . . .35
! |
WARNING |
! |
Battery posts, terminals and related accessories contain lead and lead compounds, chemicals known to the State of California to cause cancer and birth defects or other reproductive harm. Wash hands after handling.
! |
WARNING |
! |
Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals known to the State of California to cause cancer or other reproductive harm.
3
Operator Safety
!WARNING: This powerful cutting machine is capable of amputating hands and feet and can throw objects that can cause injury and damage! Failure to comply with the following SAFETY instructions could result in serious injury or death to the operator or other persons. The owner of the machine must understand these instructions and must allow only persons who understand these instructions to operate machine. Each person operating the machine must be of sound mind and body and must not be under the influence of any substance, which might impair vision, dexterity or judgment. If you have any questions pertaining to your machine which your dealer cannot answer to your satisfaction, contact Customer Service (1-800-935-2967 or www.snapper.com).
Protection for Children |
|
Protection against Tipovers |
|
Tragic accidents can occur if the operator is not alert to the |
(Continued From Previous Column) |
||
presence of children. Children are often attracted to the |
|
6. KEEP A SAFE DISTANCE (at least 3 feet) away from edge |
|
machine and the mowing activity. Children who have been |
of ditches and other drop offs. The machine could turn over |
||
given rides in the past may suddenly appear in the mowing |
if an edge caves in. |
||
area for another ride and be run over or backed over by the |
7. Always begin forward motion slowly and with caution. |
||
machine. Never assume that children will remain where you |
8. Use weights or a weighted load carrier in accordance |
||
last saw them. |
|
with instructions supplied with a grass catcher. DO NOT |
|
1. |
KEEP children out of the mowing area and under the |
|
operate machine on slopes exceeding 10 degrees (18% |
watchful care of a responsible adult other than the operator. |
grade) when equipped with grass catcher. |
||
these affect the handling and the stabilityReproductionof the machine. 3. Data indicates that operators age 60 and above, are |
|||
2. |
DO NOT allow children in yard when machine is operated |
9. DO NOT put your foot on the ground to try to stabilize |
|
(even with the blade OFF). |
for |
||
|
the machine. |
||
3. |
DO NOT allow children or others to ride on machine, |
|
10. DO NOT operate machi e on wet grass. Reduced trac- |
attachments or towed equipment (even with the blades |
|
ti n could cause sl d ng. |
|
OFF). They may fall and be seriously injured. |
|
11. Choose a l w en ugh speed setting so that you will not |
|
4. |
DO NOT allow pre-teenage children to operate machine. |
have to s op or sh ft on a slope. Tires may lose traction on |
|
5. |
ALLOW only responsible adults & teenagers wi h ma ure |
slopes even though the brakes are functioning properly. |
|
judgment under close adult supervision to pera e machine. |
12. DO NOT operate machine under any condition where |
||
6. |
DO NOT operate blades in reverse. STOP BLADES. LOOK |
traction, steering or stability is doubtful. |
|
and SEE behind and down for children, pets and hazards |
|
13. Always keep the machine in gear when going down |
|
before and while backing. |
|
sl pes. DO NOT shift to neutral (or actuate hydro roll |
|
7. |
USE EXTRA CARE when approaching blind corne s, |
|
release) and coast downhill. |
shrubs, trees, or other objects that mayNotobscure vision. |
|
Preparation |
|
Protection against Tipovers |
|
||
|
1. Read, understand, and follow instructions and warnings |
||
Slopes are a major factor related to loss-of-control and tip- |
in this manual and on the machine, engine and attach- |
||
over accidents, which can result in severe injury or ath. |
|
ments. Know the controls and the proper use of the |
|
All slopes require extra CAUTION. If you cannot back up the |
machine before starting. |
||
slope or if you feel uneasy on the slope, DO NOT mow it. |
|
2. Only mature, responsible persons shall operate the |
|
Use extra care with grass catchers or other attachments; |
|
machine and only after proper instruction. |
|
Refer to the Slope Guide at the end of this manual. |
|
involved in a large percentage of mower-related injuries. |
|
1. |
DO NOT operate machine on slopes exceeding 15 |
|
These operators should evaluate their ability to operate the |
degrees (27% grade). |
|
mower safely enough to protect themselves and others |
|
2. |
Exercise EXTREME CAUTION on slopes above 10 |
|
from serious injury. |
degrees (18% grade). Turn blades OFF when traveling |
|
4. Handle fuel with extra care. Fuels are flammable and |
|
uphill. Use a slow speed and avoid sudden or sharp turns. |
vapors are explosive. Use only an approved fuel container. |
||
3. |
DO NOT operate machine back and forth across face of |
|
DO NOT remove fuel cap or add fuel with engine running. |
slopes. Operate up and down. Practice on slopes with |
|
Add fuel outdoors only with engine stopped and cool. Clean |
|
blades off. |
|
spilled fuel from machine. DO NOT smoke. |
|
4. |
AVOID starting, stopping or turning on slopes. If machine |
5. Practice operation of machine with BLADES OFF to learn |
|
stops going uphill or tires lose traction, turn blades OFF and |
controls and develop skills. |
||
back slowly straight down the slope. |
|
6. Check the area to be mowed and remove all objects such |
|
5. |
STAY ALERT for holes and other hidden hazards. Tall |
|
as toys, wire, rocks, limbs and other objects that could |
grass can hide obstacles. Keep away from ditches, |
|
cause injury if thrown by blade or interfere with mowing. |
|
washouts, culverts, fences and protruding objects. |
|
|
4 |
www.snapper.com |
|
|
|
|
|
Operator Safety |
Protection against Tipovers |
|
Operation |
|
|
|
(Continued From Previous Column) |
|
1. Mount and dismount machine from left side. Keep clear |
|||
7. |
Keep people and pets out of mowing area. Immediately |
of discharge opening at all times. |
|||
STOP blades, STOP engine, and STOP machine if anyone |
2. Start engine from operator’s seat, if possible. Make sure |
||||
enters the area. |
|
blades are OFF and parking brake is set. |
|||
8. |
Check shields, deflectors, switches, blade controls and |
3. DO NOT leave machine with engine running. STOP |
|||
other safety devices frequently for proper operation and |
engine, STOP blades, SET brake, and Remove key before |
||||
location. |
|
leaving operators position of any reason. |
|||
9. |
Make sure all safety decals are clearly legible. Replace if |
4. DO NOT operate machine unless properly seated with |
|||
damaged. |
|
feet on feet rests or pedal(s). |
|||
10. Protect yourself when mowing and wear safety glasses, |
5. STOP BLADES and ENGINE and make sure blades have |
||||
a dust mask, long pants and substantial footwear. |
|
stopped before removing grass catcher or unclogging |
|||
11. Know how to STOP blades and engine quickly in prepa- |
mower to prevent loss of fingers or hand. |
||||
ration for emergencies. |
|
6. Blades must be OFF except when cutting grass. Set |
|||
12. Use extra care when loading or unloading the machine |
blades in highest position when mowing over rough |
||||
into a trailer or truck. |
|
ground. |
|
|
|
13. Check grass catcher components frequently for signs of |
7. Keep hands and feet away from rotating blades under- |
||||
wear or deterioration and replace as needed to prevent |
neath deck. DO NOT place foot on ground while BLADES |
||||
injury from thrown objects going through weak or worn |
are ON or machine is in motion. |
||||
then refuel equipment using a portableReproductioncontainer, rather |
|||||
spots. |
|
8. DO NOT operate machi |
e without entire grass catcher or |
||
Safe Handling of Gasoline |
|
gua ds in place and worki |
g. DO NOT point discharge at |
||
|
pe ple, passing cars, wi d |
ws or doors. |
|||
To avoid personal injury or property damage, use extreme |
9. Slow down bef |
re turning. |
|||
care in handling gasoline. Gasoline is extremely flammable |
10. Watch out f r |
raff c when near or crossing roadways. |
|||
|
|
|
11. STOP eng ne |
mmediately after striking an obstruction. |
|
and the vapors are explosive. |
forInspe t ma hine and repair damage before resuming opera- |
||||
1. |
Extinguish all cigarettes, cigars, pipes and ther s |
urces |
tion. |
|
|
of ignition. |
|
|
|
||
2. |
Use only an approved fuel container. |
|
12. Operate machine only in daylight or with good artificial |
||
3. |
DO NOT remove fuel cap or add fuel with the engine run- |
light. |
|
|
|
ning. Allow the engine to cool before refueling. |
|
13. Exercise CAUTION when pulling loads. Limit loads to |
|||
4. |
DO NOT refuel the machine indoors. |
|
those you can safely control and attach loads to hitch plate |
||
5. |
DO NOT store the machine or fuel containerNotinside whe e |
as specified with attachment instructions. |
|||
there is an open flame, spark or pilot light such as on a |
14. On slopes, the weight of the towed equipment may |
||||
water heater or other appliances. |
|
cause loss of traction and loss of control. When towing, |
|||
6. |
DO NOT fill fuel containers inside a vehicle or on a truck |
travel slowly and allow extra distance to stop. |
|||
or trailer bed with a plastic liner. Always place the contain- |
15. DO NOT operate engine in enclosed areas. Engine |
||||
ers on the ground away from the vehicle b fore filling. |
exhaust gases contain carbon monoxide, a deadly poison. |
||||
7. |
Remove gas-powered equipment from the vehicle or |
16. DO NOT discharge material against a wall or obstruc- |
|||
trailer and refuel it on the ground. If this is not possible, |
. Material may ricochet back towards the operator. |
||||
|
|
|
17. Only use accessories approved by the manufacturer. |
||
than a gasoline dispenser nozzle. |
|
See manufacturer’s instructions for proper operation and |
|||
8. |
DO NOT start gas powered equipment in enclosed vehi- |
installation of accessories. |
|
cles or trailers.
9.Keep the nozzle in contact with the rim of the fuel tank or container opening at all times until fueling is complete. DO NOT use a nozzle lock-open device
10.If fuel is spilled on clothing, change clothing immediate-
ly.
11.Never overfill a fuel tank. Replace fuel cap and tighten
securely.
5
Operator Safety
Towing |
|
|
Maintenance |
|
1. |
Tow only with a machine that has a hitch designed for |
(Continued From Previous Column) |
||
towing. DO NOT attach towed equipment except at the hitch |
6. Always provide adequate ventilation when running |
|||
point. |
|
|
engine. Exhaust gases contain carbon monoxide, an odor- |
|
2. |
Follow the manufacturer’s recommendation for weight |
less and deadly poison. |
||
limits for towed equipment and towing on slopes. |
|
7. Disconnect negative (black) cable from battery before |
||
3. |
DO NOT allow children or others on towed equipment. |
performing maintenance or service. Cranking engine could |
||
4. |
On slopes, the weight of the towed equipment may cause |
cause injury. |
||
loss of traction and loss of control. |
|
|
8. DO NOT work under machine without safety blocks. |
|
5. |
Travel slowly and allow extra distance to stop. |
|
9. Service engine and make adjustments only when engine |
|
Maintenance |
|
|
is stopped. Remove spark plug wire(s) from spark plug(s) |
|
|
|
and secure wire(s) away from spark plug(s). |
||
1. |
DO NOT store machine or fuel container inside where |
|
10. DO NOT change engine governor speed settings or |
|
fumes may reach an open flame, spark or pilot light such as |
overspeed engine. |
|||
in a water heater, furnace, clothes dryer or other gas appli- |
11. Lubricate machine at intervals specified in manual to |
|||
ance. Allow engine to cool before storing machine in an |
|
prevent controls from binding. |
||
enclosure. Store fuel container out of the reach of children |
12. Mower blades are sharp and can cut. Wrap the blades |
|||
in a well ventilated, unoccupied building. |
|
or wear heavy leather gloves and use CAUTION when han- |
||
2. |
Keep engine free of grass, leaves or excess grease to |
|
dling them. |
|
reduce fire hazard and engine overheating. |
|
13. DO NOT test for spark by grounding spark plug next to |
||
3. |
When draining fuel tank, drain fuel into an approved con- |
spa k plug hole; spark plug could ignite gas exiting engine. |
||
tainer outdoors and away from open flame. |
|
14. Have machine serviced by an authorized dealer at least |
||
4. |
Check brakes frequently; adjust, repair or replace as |
|
nce a year and have the dealer install any new safety |
|
needed. |
|
|
devices. |
|
5. |
Keep all bolts, nuts and screws properly tight. Check |
hat |
15. Main ain or replace safety and instruction labels as nec- |
|
all cotter pins are in proper position. |
|
foressary. |
||
|
|
Not |
|
|
|
|
Reproduction |
||
|
|
|
|
16. Use only fa tory authorized replacement parts or like |
|
|
|
|
parts when making repairs. |
6 |
www.snapper.com |
Operator Safety
Decal Identification
Remove Battery - 7101109
Before Starting - 7101112
Amputation and thrown objects hazard
• Keep hands and feet away from deck.
WARNING
• Do not operate mower unless discharge |
|
|
|
||
|
|
Reproduction |
|
||
chute or entire grass catcher is in its proper |
for |
Fire Hazard. Operation of this equipment |
|||
place. |
7101110 |
|
|
may create sparks that can start fires around |
|
|
|
|
|
dry vegetation. A spark arrestor may be |
|
Danger Thrown Objects - 7101110 |
|
required. The operator should contact local |
|||
|
|
|
|
f re age cies for laws or regulations relating |
|
|
|
|
|
f re prevention requirements. |
7102746 |
|
|
Not |
|
Spark Arrestor - 7102746 |
|
|
|
|
|
|
|
|
|
|
|
7103440 |
|
Height of Cut - 703440
Safety Panel - 7101111
7
Operator Safety
7104796 |
Reverse Lockout - 7104796
7103219
Parking Brake - 7103219
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
CAUTION |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Fire Hazard |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
• Do not overfill tank. |
|
|
|
|
|
|
|
|
|
|
|
Reproduction |
|
|||||
|
|
|
|
|
|
|
|
|
|
IMPORTANT |
|
|
|
|
|
• Empty tank before |
|
Use only rechargeable valve regulated (sealed) |
|
|
for |
7104797 sta di g unit on end. |
|||||||||||||
non-spillable batteries in this product. Battery |
|
|
|
|
|||||||||||||
must be factory approved part or equivalent. |
7105102 |
|
|
Fuel Ta k - 7104797 |
|||||||||||||
Do not overcharge. |
|
|
|
|
|
||||||||||||
|
|
|
|
Non-Spillable Battery - 7105102 |
|
|
|
|
|||||||||
|
|
|
|
|
|
|
|
|
|
WARNI G |
|
|
|
|
|
||
|
|
|
|
|
|
AVOID SERIOUS INJURY OR DEATH |
|
|
|
|
|
||||||
|
|
|
|
|
|
|
|
|
|
Read Operator’s Manual before |
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
working with battery. |
Not |
|
|
||||
|
|
|
|
|
|
|
|
|
|
|
|||||||
|
|
|
|
|
|
|
|
|
|
Always wear goggles when |
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
working near battery. |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Keep children, open flam s and |
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
sparks away from battery. |
|
|
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
||||
|
|
|
|
|
|
|
|
|
|
Use only constant voltage batt ry |
|
|
|
|
|||
|
|
|
|
|
|
|
|
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|
chargers made for valve r gulat d |
|
|
|
|
|||
|
|
|
|
CV |
|
(sealed) non-spillable batt ri |
s. |
|
|
|
|
||||||
|
|
+ - |
|
|
|
|
|||||||||||
|
|
|
|
|
|
|
|
|
|
(3.6 amps max.) |
|
|
7105103 |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
Battery Warning - 7105103
8 |
www.snapper.com |
Features and Controls
IMPORTANT
The figures and illustrations in this manual are provided for reference only and may differ from your specific model. Contact your dealer if you have questions.
|
|
|
I |
J |
|
|
H |
|
Reproduction |
|
|
|
|
|
|
||
|
G |
|
Not |
for |
|
|
|
|
|
||
F |
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
A |
|
E |
|
|
B |
|
|
|
|
|
|
|
|
|
D |
|
C |
|
|
|
|
|
|
Features and Controls
A. |
Engine Speed Control |
F. |
Blade Pedal |
B. |
Cutting Height Lever |
G. |
Blade Lever |
C. |
Ignition Switch |
H. |
Steering Wheel |
D. |
Clutch/Brake Pedal |
I. |
Transmission Shift Lever |
E. |
Park Brake Latch |
J. |
Fuel Tank |
9
Operation |
|
|
Before Starting |
|
|
Make the following checks and perform the service required |
|
|
before each start-up: |
|
|
1. |
Check the tire pressure; add or release air as needed to |
A |
|
bring pressure to 15 PSI in front and 12 PSI in rear. |
|
2. |
Check guards, deflectors and covers to make sure all are |
|
|
in place and securely tightened. |
|
3. |
Check engine oil and add oil as needed to bring level up |
|
|
to the FULL mark (A, Figure 1). Refer to the engine |
|
|
manual for oil specifications. |
|
|
|
|
|
|
|
|
|
|
|
Figure 2: Fuel filler cap |
|
|
|
||
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
|
A |
|
|
|
Operator Seat Adjustment |
|
|
||||
|
|
|
|
|
|
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
1. With the engine stopped, loosen the two adjusting |
||||||
|
|
|
|
|
|
|
|
|
|
knobs (A, Figure 3) and move the seat to the desired |
|||||
|
|
|
|
|
|
|
|
|
|
position. After adjustment, tighten the knobs securely. |
|||||
|
|
|
|
|
|
|
|
|
NOTE: If the seat d es t move after loosening the knobs, it |
||||||
|
|
|
|
|
|
|
|
|
may be necessary to l sen the 5/16” patch lock screws or |
||||||
|
Figure 1: Engine oil ‘Full’ mark |
|
|
|
|
|
|
||||||||
|
|
|
|
|
|
|
hex nuts (B) loca ed at the rear of the seat. |
|
|
||||||
4. Adjust the seat (A, Figure 3) as needed to the most |
orf |
|
|
|
|
|
|
||||||||
|
|
|
|
|
|
||||||||||
|
|
comfortable position. Refer to the Secti n en i led |
|
|
|
|
|
|
|||||||
|
|
“OPERATOR’S SEAT ADJUSTMENT”. |
|
|
|
|
|
|
|
||||||
|
|
|
|
|
|
|
|
|
|
|
|
|
|||
5. Check the blade control to insure it works freely. If the |
|
|
|
|
|
|
|
||||||||
|
|
blade pedals are depressed, the blade lever can be |
|
|
|
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
A |
|
||||||
|
|
moved manually from “ON” to “OFF” to stop the blade. |
|
|
|
|
|
|
|||||||
|
|
|
|
|
|
|
|
|
|||||||
6. Check the Reverse Lockout Mechanism. With the blade |
|
|
|
|
|
|
|
||||||||
|
|
|
Not |
|
|
|
|
|
|
|
|||||
|
|
pedals depressed, the shift lever must not go into |
|
|
|
|
|
|
|
|
|||||
|
|
reverse. |
|
|
|
|
|
|
|
|
|
|
|
|
|
7. |
Clean the exterior surfaces of the cutting |
ck and |
|
|
|
|
|
|
|
|
|||||
|
|
engine of any accumulation of dirt, grass, oil, |
tc. Keep |
|
|
|
|
|
|
|
|||||
|
|
|
|
|
|
|
|
|
|||||||
|
|
|
|
|
|
B |
|
|
|||||||
|
|
the engine air intake screen and cooling fins cl |
ar at all |
|
|
|
|
|
|
||||||
|
|
times. |
|
|
|
|
|
|
|
|
|
|
|
|
|
8. |
Add fuel to the fuel tank after pushing the |
ear Engine |
|
|
|
|
|
|
|
||||||
|
|
Rider outside where fumes can dissipate. Make sure the |
|
|
|
|
|
|
|
||||||
|
|
|
|
|
|
|
|
|
|||||||
|
|
fuel filler cap (A, Figure 2) is tight after refueling. Refer |
Figure 3: Operator seat adjustment |
|
|
|
|||||||||
|
|
|
Reproduction |
|
|
|
|||||||||
|
|
to the engine manual for fuel specifications. |
|
|
|
|
|
|
|
|
|
IMPORTANT: Do not overfill. (See statement below.)
IMPORTANT
To avoid damaging the emissions system:
•Do not overfill the fuel tank. Stop filling the tank when fuel collects in the filler neck.
•Empty the fuel tank before standing the machine on its rear bumper.
10 |
www.snapper.com |
Operation
Starting and Operation
Engine (Electric Start)
A
IMPORTANT: When the ignition key is turned to “START”, the engine will turn over, but will not start unless the Clutch/Brake pedal is pressed all the way down, and the Blade Lever is in the “OFF” position. The operator should be in the seat.
Start the engine as follows:
1.Move the transmission shift lever to the (N) Neutral position. Refer to the section entitled “Wheel Drive”.
IMPORTANT: DO NOT start the engine with the transmission |
|
|
||||
shift lever in a drive position. |
|
|
Figure 5: Engaging the clutch/brake pedal |
|
||
! |
WARNING |
|
! |
|
|
|
It is possible to start the engine with the transmission |
|
|
|
|
||
down and hold while starting the engine.Reproduction |
|
|||||
shift lever in a drive position. Follow starting instructions |
for |
|
|
|||
carefully. |
|
|
|
|
|
|
2. Make certain the Blade Lever (A, Figure 4) is in the |
|
|
B |
|
||
“OFF” position. |
|
Not |
|
|
||
|
A |
|
|
|
|
|
|
|
|
|
|
A |
|
|
|
|
|
Figure 6: Engine speed control |
|
|
Figure 4: Blade lever (in ‘Off’ position) |
|
|
|
|
A |
|
|
|
|
|
|
|
|
3. Press the Clutch/Brake Pedal (A, Figure 5) all the way |
|
|
|
|||
4. Move the engine speed control (A, Figure 6) to the |
|
|
|
|
||
choke position (B) to start a cold engine. |
|
|
|
|
||
5. Turn the ignition key (A, Figure 7) to the “START” |
|
|
|
|
||
position until the engine starts. |
|
|
|
|
|
NOTE: If after 5 seconds of cranking the engine does not start, release the key, make sure the Clutch/Brake Pedal is
fully depressed, and attempt starting again after waiting for Figure 7: Ignition key approximately 20 seconds.
6.After the engine starts, move the engine speed control to the “FAST” position and allow a brief warm-up until engine runs smooth.
(Continued on Next Page)
11