JL Audio Stealthbox SB-F-SUPRCC-13TW5-DG User Manual

Size:
1.1 Mb
Download

I n s t a l l a t i o n G u i d e for the

SB-F-SUPRCC/13TW5

SKU#94414

2008+

Thank you for choosing a JL Audio Stealthbox® for your automotive sound system. With proper installation, your newvehicle-specificenclosed subwoofer system will deliver years of listening pleasure.

We strongly recommend that you have your new Stealthbox® installed by your authorized JL Audio dealer. The installation professionals employed by your dealer have the necessary tools and experience to disassemble and reassemble your vehicle properly. Also, keep in mind that your warranty coverage extends to 2 years if your system is installed or approved by your authorized JL Audio dealer. If you prefer to perform your own installation, please read this installation guide completely

before beginning the process.

SB-F-SUPRCC/13TW5INSTR_SKU# 011275

If you choose to perform the installation yourself, it is absolutely vital that the Stealthbox® be properly mounted to the vehicle according to these instructions. Failure to mount the enclosure properly presents two problems:

1)The sub-bassperformance will suffer due to the movement of the enclosure caused by the force exerted by the woofer(s).

2)A loose enclosure presents a serious safety hazard in the event of a collision or sudden deceleration.

INSTALLATION D I F F I C U LT Y:

1OUT OF

5

Estimated TIME:

1 HOUR

S T E P 1

Remove any contents in the backseat area and flip the seat up.

Remove the 6 Torx® T40 bolts that hold in the floortray as indicated by the circles on the picture to the left. This tray will not be used, remove it from the truck and, store it for reinstallation if the truck needs to return to OEM configuration. set aside 4 of the T40 Torx® bolts, they will be used to install the Stealthbox®.

S T E P 2

There are four brackets that need to be installed on the enclosure, two on each end. the short end of the bracket attaches to the enclosure using the supplied hardware (see DETAIL below). Do not tighten hardware down at this point, just get it in place.

STEALTHBOX WALL

D e t a i l

 

MOUNTING BRACKET

 

LOCK WASHER

 

HEX BOLT

THREADED INSERT

FLAT WASHER

 

Continued on Next Page

S T E P 3

Set the enclosure in place with the terminal cup towards the center of the truck. Now is an excellant time to test the Stelthbox® for proper operation. After performance has been ensured, align the holes in the brackets with the threaded inserts that originally mounted the Floor tray that was removed in STEP 1.

S T E P 4

4 of the T40 Torx® bolts that were removed in STEP 1 will be used to secure the Stealthbox® to the truck. Get all 4 bolts started before tightening any hardware. Tighten the 4 bolts that secure the mounting brackets to the Stealthbox® first.

S T E P 5

Tighten the T40 Torx® bolts that secure the mounting brackets to the truck.

S T E P 6

Step back and admire your work, flip the rear seat back down,

C O N G R A T U L A T I O N S !

You have completed the installation for this model!

Enjoy your new Stealthbox®!

Please refer to the Power Recommendation section for an amplifier recommendation and basic set-uphelp.

SB-F-SUPRCC/13TW5INSTR_SKU# 011275

I N C L U D E D H A R D W A R E

4) 1/4”-20x1” Hex Head Bolt

4) 1/4” Flat Washer

4) 1/4” Split Lock Washer

4) 1/4” Flat Washer

4) Mounting Bracket

S P E C I F I C A T I O N S

Enclosure Type: Acoustic Suspension (sealed)

Driver Type: 13TW5

Nominal Impedance: 3Ohms

Continuous Power Handling: 600Watts

P o w e r R e c o m m e n d a t i o n

JL Audio recommends using a high quality amplifiers such as the JL Audio 500/1v2. The diagram below shows the recommended crossover, infrasonic filter and equalizer settings for the 500/1v2 when being used to power your Stealthbox®.

 

Preamp Output Section

 

 

 

Infrasonic Filter

 

"Q"

Center Freq.

Boost (dB)

 

Amp LP Filter

 

Amplifier Input Section

 

Subwoofer Output

 

 

 

 

 

 

 

 

Output Mode

 

Filter Slope

 

 

 

 

 

 

 

1.6

 

 

 

45

 

 

+10

 

 

Mode / Slope

Input Voltage

Input Sens. Signal Sensing

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

1.1

 

2.7

35

 

55

 

+4

 

+13

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

0.7

 

 

 

25

 

 

 

70

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

12dB / 24dB

 

 

 

 

Off / 30Hz

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Off / 12dB / 24dB

 

Low / High

 

 

Off / On

 

 

 

 

 

Full Range / Amp Filter / Out Filter

 

 

 

 

0.5

4.3

20

85

 

0

 

+15

 

 

 

 

 

 

 

_

_

+12VDC Ground Remote

 

 

 

65

 

 

Filter Mode

 

 

30

 

Bass EQ

 

 

 

 

 

 

 

 

 

 

 

65

 

 

 

 

 

 

 

 

 

 

 

+

+

 

 

 

55

 

85

 

 

 

25

40

 

 

 

 

 

 

Advanced

 

55

 

85

 

 

 

 

 

 

 

 

 

 

 

 

 

 

45

 

 

120

 

 

 

18

 

50

 

 

 

 

 

 

 

 

 

 

 

45

 

120

 

 

 

 

 

 

 

 

 

 

 

 

JL AUDIO 500/1

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Bass

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

40

 

200

LP / HP

 

15

60

 

Off / On

 

 

 

 

 

 

Control

 

40

 

200

 

 

 

 

 

 

 

 

 

 

MONO OUTPUT ONLY

five-channelsystem amplifier

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

Left Ch.

 

Right Ch.

Filter Freq. (Hz)

 

 

 

Infrasonic Freq. (Hz)

 

 

 

 

Remote Bass Port

 

 

 

 

Filter Freq. (Hz)

 

Left Ch.

Right Ch.

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

The JL Audio 500/1v2 is a very versatile audio component. Please consult the owner’s manual for even more detailed information about installing and tuning this amplifier.

M I D / H I G H F r e q u e n c y D r i v e r F I T M E N T

A variety of JL Audio coaxial and component systems will fit in the factory speaker locations of you vehicle.

Front Speaker Size / Location: 5”x 7” / 6”x 8”- Front Doors

Fits JL Audio Models: TR570-CXi,C5-570,C5-570x&ZR570-CSi

Rear Speaker Size / Location: 5”x 7” / 6”x 8”- Rear Door

Fits JL Audio Models: TR570-CXi,C5-570x

(954) 443-1100

 

www.jlaudio.com

 

 

 

All specifications are subject to change without notice. “JL Audio®” and the JL Audio logo, “Stealthbox” and the Stealthbox logo are registered

 

 

 

 

trademarks of JL Audio, Inc. “Ahead of the Curve” and its respective logo is a trademark of JL Audio, Inc.

 

 

 

 

JLA-SKU#01127509-24-2008• Printed in USA • ©2008 JL Audio, Inc. • U.S. PATENTS: #5,734,734 #5,949,898 #6,118,884 #6,229,902 #6,243,479

 

 

 

 

#6,294,959 #6,501,844 #6,496,590 #6,441,685 #5,687,247 #6,219,431 #6,625,292 #D472,891 #D480,709 Other U.S. & Foreign patents pending.

 

 

 

 

For more detailed information please visit us online at www.jlaudio.com.

 

 

 

 

 

 

1 0 3 6 9 N O R T H C O M M E R C E P A R K W A Y

M I R A M A R , F L O R I D A

3 3 0 2 5

U S A

Page 2 • JL Audio, Inc 2008