JL Audio C5-570x User Manual

Size:
288.38 Kb
Download

I n s t a l l a t i o n G u i d e for the

SB-GM-SLVEXT2/10W1v2

SKU#94465,94467,94468,94469,94470,94472

2007+

Thank you for choosing a JL Audio Stealthbox® for your automotive sound system. With proper installation, your newvehicle-specificenclosed subwoofer system will deliver years of listening pleasure.

We strongly recommend that you have your new Stealthbox® installed by your authorized JL Audio dealer. The installation professionals employed by your dealer have the necessary tools and experience to disassemble and reassemble your vehicle properly. Also, keep in mind that your warranty coverage extends to 2 years if your system is installed or approved by your authorized JL Audio dealer. If you prefer to perform your own installation, please read this installation guide completely

before beginning the process.

SB-GM-SLVEXT2/10W1v2INSTR_SKU# 011300

If you choose to perform the installation yourself, it is absolutely vital that the Stealthbox® be properly mounted to the vehicle according to these instructions. Failure to mount the enclosure properly presents two problems:

1)The sub-bassperformance will suffer due to the movement of the enclosure caused by the force exerted by the woofer(s).

2)A loose enclosure presents a serious safety hazard in the event of a collision or sudden deceleration.

INSTALLATION D I F F I C U LT Y :

2OUT OF

5

Estimated TIME:

1 HOUR

S T E P 1

Empty out the area under the back seat so that you have a

Clean area to work in.

S T E P 2

Measure 14” in from the insdie of the rear sill trim as shown, this should be the center of the 3” x 3” Wax Square.

14”

S T E P 3

Thread the Mounting Stud into the bottom of the

Stealthbox® so that only 1/4”- 3/8” is exposed.

Continued on Next Page

S T E P 4

Line up the Stealthbox® so that the seat belt anchor bolt is centered in the recess in the enclosure. Press down on the Stealthbox making and imprint in the 3” x 3” wax square with the Mounting Stud. Remove the Stealthox® and drill a 1/2” hole through the floor where the mark was made.

Before drilling, always make sure that you are not going to be drilling into any gas lines, brake lines, tires, transmission lines, electrical wiring, exhaust systems or anything else that might cause a reduction in your weekly pay.

Always wear eye protection when drilling!

S T E P 5

Back the Mounting Stud out of the Stealthbox® so that approximately 1-1/4”is exposed, set the Stealthbox® back into place, with the Mounting Stud going through the freshly drilled hole.

S T E P 6

Install the included Fender Washer, Split Lock Washer and Hex Nut as shown, tighten them down.

S T E P 7

C O N G R A T U L A T I O N S !

You have completed the installation for this model!

Enjoy your new Stealthbox®!

Please refer to the Power Recommendation section for an amplifier recommendation and basic set-uphelp.

SB-GM-SLVEXT2/10W1v2INSTR_SKU# 011300

I N C L U D E D H A R D W A R E

1)

3/8-16x ***” Mounting Stud

1)

3/8 x 1-1/4”Fender Washer

1)

3/8” Split Lock Washer

1)

3/8-16Hex Nut

S P E C I F I C A T I O N S

Enclosure Type: Acoustic Suspension (sealed)

Driver Type: (2) 10W1v2-8

Nominal Impedance: 4 ohms

Continuous Power Handling: 600 watts

P o w e r R e c o m m e n d a t i o n

JL Audio recommends high quality amplifiers such as the JL Audio HD900/5, 500/1v2 or J2 500.1. The diagram below shows the recommended crossover, infrasonic filter and equalizer settings for the 500/1v2. If another amplifier is being used, please reference this illustration and use similar settings on that amplifier.

+12VDC

Ground

Remote

Preamp Output Section

 

Infrasonic Filter

“Q”

 

Center Freq.

Boost (dB)

Amp LP Filter

Amplifier Input Section

Subwoofer Output

 

 

 

Output Mode

Filter Slope

 

 

Mode

1.6

 

 

40

+10

 

Mode | Slope

Input Voltage

Input Sens.

Signal Sensing

 

 

 

 

 

 

1.

.7

30

60

+4

+13

 

 

 

 

 

 

 

 

 

 

0.7

 

25

75

 

 

 

 

 

 

 

 

 

 

 

Full Range | Amp Filter | Out Filter

12dB | 24dB

 

 

Off | On

0.

.3

 

80

 

+15

Off | 12dB | 24dB

Low | High

 

Off | On

 

 

 

 

 

 

65

Filter Mode

 

30

Bass EQ

 

 

 

 

 

 

65

 

 

 

 

 

 

 

 

55

80

22

45

 

 

 

Advanced

55

80

 

 

 

 

 

500/1v2

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

45

100

 

18

55

 

 

 

 

Bass

 

45

100

 

 

 

MONO OUTPUT ONLY

Monoblock Subwoofer Amplifier

 

 

200

LP | HP

 

60

Off | On

 

 

 

Control

 

 

200

 

 

 

Left Output Right Output

Filter Freq. (Hz)

Infrasonic Freq. (Hz)

Remote Bass Port

Filter Freq. (Hz)

Left Ch.

Right Ch.

All JL Audio amplifiers are very versatile audio components. Please consult the owner’s manual for even more detailed information about installing and tuning your amplifier.

C o n n e c t i o n s

Using quality power, signal and speaker wire is essential in ensuring the performance of your Stealthbox®. JL Audio recommends using a 4 AWG power kit such as the XC-PCS4-1Bfor your Stealthbox® amplifier, other kits are available should you be using more than one amplifier. Signal wire such as the JL Audio Premium

Audio Interconnect Cables should be used that will provide signal for both channels of the amplifier. JL Audio reccommends using 12AWG speaker wire for subwoofers such as our XC-BCS12-25.

M I D / H I G H F r e q u e n c y D r i v e r F I T M E N T

A variety of JL Audio coaxial and component systems will fit in the factory speaker locations of you vehicle.

Front Speaker Size / Location: 5”x 7” / 6”x 8”- Front Doors

Fits JL Audio Models: TR570-CXi,C2-570x,C3-570,C5-570,C5-570x&ZR570-CSi

Rear Speaker Size / Location: 5”x 7” / 6”x 8”- Rear Door

Fits JL Audio Models: TR570-CXi,C2-570x,C3-570,C5-570,C5-570x&ZR570-CSi

(954) 443-1100www.jlaudio.com

All specifications are subject to change without notice. “JL Audio®” and the JL Audio logo, “Stealthbox” and the Stealthbox logo are registered trademarks of JL Audio, Inc. “Ahead of the Curve” and its respective logo is a trademark of JL Audio, Inc.

JLA-SKU#**********-**-2009• Printed in USA • ©2008 JL Audio, Inc. • U.S. PATENTS: #5,734,734 #5,949,898 #6,118,884 #6,229,902 #6,243,479 #6,294,959 #6,501,844 #6,496,590 #6,441,685 #5,687,247 #6,219,431 #6,625,292 #D472,891 #D480,709 Other U.S. & Foreign patents pending. For more detailed information please visit us online atwww.jlaudio.com.

Page 2 • JL Audio, Inc 2009

1 0 3 6 9 N O R T H C O M M E R C E P A R K W A Y • M I R A M A R , F L O R I D A • 3 3 0 2 5 • U S A