Loading...
STAINLESS STEEL LP GAS GRILL
MODEL NO.: 720-0163 ITEM NO: 18852
Jenn-Air is a Trademark of the Maytag Corporation and is used under license to Lowe’s Companies, Incorporated.
FOR OUTDOOR USE ONLY
PLEASE CONTACT 1-800-554-5799 FOR ASSISTANCE DO NOT RETURN TO PLACE OF PURCHASE
TABLE OF CONTENTS
SECTION ONE |
|
|
Safety Instructions…………………………… |
1-5 |
|
Placement of the Grill ……………………… |
5 |
|
SECTION TWO |
|
|
Side Burner & Side Shelf Assembly……….. |
6 |
|
Side Burner Hose Quick-Connect Assembly |
7 |
|
Side Shelf Handle Assembly & Battery |
|
|
Installation……………………………………... |
8 |
|
Braking System Operations…………………. |
9 |
|
Liquid Propane Cylinder Retention System |
9 |
|
Slide-Out Tray Locking System……………... |
10 |
|
Propane Regulator Hook-up………………… |
10 |
|
SECTION THREE |
|
|
Gas Hook Up |
…………………………….. |
11 |
Leak Testing…………………………………… |
12 |
|
Installer Final Check…………………………. |
13 |
|
SECTION FOUR |
|
|
Operating Instructions……………………… |
14 |
|
Lighting Instructions……………………….. |
15 |
|
To Match Light the Grill…………………….. |
16 |
|
Lighting Illustrations………………………… |
17 |
|
Using the Side Burner……………………… |
18 |
|
Care & Maintenance of Side Burner……… |
18 |
|
Care & Maintenance of Grill………………. |
19 |
|
Troubleshooting |
……………………….. |
20 |
WARNING
To reduce the risk of fire, burn hazard or other injury, read this Care and Use Manual carefully and completely before using your grill.
SECTION FIVE
Exploded View………………………………21
Parts List…………………………………… 22
SECTION SIX
Grilling Hints……………………………….. 23
Grill Cooking Chart………………………….23-25
Grill Recipe Suggestions…………………. 26-27
SECTION SEVEN
Limited Warranty……………………………28
SAFETY INSTRUCTIONS
RECOGNIZED SAFETY SYMBOLS, WORDS AND LABELS
|
|
|
WARNING |
|
WARNING |
|
|
|
|
Do not try lighting this appliance without first reading |
|
|
|
|
the “LIGHTING INSTRUCTIONS” section of this |
|
|
|
|
WARNING – Hazards or unsafe |
manual. |
||
practices which COULD result in severe |
|
||
|
|||
personal injury or death. |
|
||
|
|||
|
|
|
WARNING |
|
|
CAUTION |
|
Spiders and insects can nest inside the burners of |
|
|
|
the grill and disrupt gas flow. This very dangerous |
||
|
|
|
||
|
|
|
condition could cause a fire behind the valve panel, |
|
CAUTION – Hazards or unsafe practices |
||||
thereby damaging the grill and making it unsafe for |
||||
which COULD result in minor personal |
operation. |
|||
injury. |
Inspect the grill at least twice a year. |
|||
WARNING
1.Do not store spare liquid propane cylinders under or near this appliance.
2.Never fill the cylinder beyond 80 percent capacity.
3.If the information above is not followed exactly, a fire resulting in death or serious injury could occur.
WARNING
Never attempt to use damaged or obstructed equipment. See your local liquid propane dealer for repair.
WARNING
Check all gas supply fittings for leaks before each use. Do not use the grill until all connections have been checked and do not leak.
Do not smoke while leak testing. Never leak test with an open flame.
|
CAUTION |
|
|
|
|
|
|
|
|
|
When using the rotisserie burner, remove the |
|
|
WARNING |
|
warming rack. High heat from the burner |
|
|
1. Attach the coupling half (socket) to |
|
may cause the warming rack to bend. |
|
|
the gas supply line in accordance |
|
|
|
|
with NFPA54/ANSI Z223.1FUEL gas |
|
|
|
|
code. |
|
WARNING |
|||
|
|
2. Prior to inserting the plug, test the |
||
|
The rotisserie motor is equipped with a plug and should |
|
connection for leaks following the |
|
|
be plugged directly into a properly grounded receptacle. |
|
leak test instructions on page 10. |
|
|
DO NOT cut or remove the grounding prong from this |
|
After the leak test is completed, rinse |
|
|
plug. |
|
||
|
|
the connection with clean water to |
||
|
Keep the rotisserie motor electric cord away from the |
|
||
|
|
remove any corrosive residue. |
||
|
heated surfaces of the grill. When not in use remove and |
|
||
|
|
3. Do not use open flame to test for |
||
|
store the motor in a dry location |
|
||
|
|
|
|
leaks. |
|
|
|
|
|
1
SAFETY INSTRUCTIONS
WARNING
Do not use the grill if the odor of gas is present. Contact customer service at 1-800-554-5799.
WARNING
When lighting, keep your face and hands as far away from the grill as possible.
WARNING
If you smell gas:
1.Shut off gas to the appliance.
2.Extinguish any open flame.
3.Open lid.
4. If odor continues, immediately call your gas supplier or your fire department.
WARNING
Storage of an outdoor cooking gas appliance indoor is permissible only if the cylinder is disconnected and removed from the outdoor cooking gas appliance.
CAUTION
When using a match to light the grill make sure to use the attached lighting rod.
CAUTION
Before cleaning, make sure the gas supply and control knobs are in the “OFF” position and the burners have cooled.
WARNING
Failure to properly place the burner over the orifice could cause a fire to occur behind and beneath the valve panel, thereby damaging the grill and making it unsafe to operate.
WARNING
Do not leave the grill unattended while cooking.
WARNING
Cylinder must be stored outdoors out of the reach of children and must not be stored in a building, garage or any other enclosed area.
2
SAFETY INSTRUCTIONS
WARNING
Do not attempt to light the grill if gas odor is present. Contact customer service at 1-800- 554-5799.
When lighting, keep your face and body as far away from the burner as possible.
BEFORE LIGHTING
Inspect the gas supply hoses prior to turning on the gas. If there is evidence of cuts, wear, or abrasion, it must be replaced prior to use.
Only the pressure regulator and hose assembly supplied with the unit should be used. Never substitute regulators for those supplied with the grill. Contact customer service for proper replacement.
Screw the regulator (type QCC1) onto the cylinder. Leak check the hose and regulator connections with a soap and water solution before operating the grill (See “Leak Testing” instructions on page 12).
Do not turn “ON” the gas at the LP gas cylinder unless the Quick-Connect gas hose is properly connected to the side burner gas pipe system and all burner valves are in the “OFF” position.
LP GAS CYLINDER WARNING
1.Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
2.A liquid propane cylinder not connected for use should not be stored in the vicinity of this or any other appliance.
3.Do not store spare liquid propane gas cylinders under or near this appliance.
4.Never fill the cylinder beyond 80 percent capacity.
5.Liquid propane cylinders must be fitted with an Overfill Protection Device (OPD).
6.If the information above is not followed exactly, a fire resulting in death or serious injury could occur.
3
USING THE SIDE BURNER
Inspect the gas supply hose prior to turning on the gas. If there is evidence of cuts, wear or abrasion, it must be replaced prior to use. Do not use the side burner if gas odor is present.
Keep a spray bottle of soapy water near the gas supply valve and check the connections before each use.
ROTISSERIE DRIVE MOTOR
To ensure continued protection against electric shock:
Connect to properly grounded outlets only.
Keep extension cord connections dry and off the ground.
Do not expose to rain.
Do not use indoors.
WARNING
If you smell gas:
1.Shut off gas to the grill.
2.Open the top cover or lid.
3.Extinguish any open flames.
4.If the odor continues, immediately call your gas supplier or local fire department.
SAFETY INSTRUCTIONS
WARNING
Do not try lighting this appliance without first reading the “LIGHTING INSTRUCTIONS” section of this manual.
TESTED IN ACCORDANCE WITH ANSI Z21.58 LATEST STANDARD and CSA 1.6 LATEST STANDARD FOR OUTDOOR COOKING GAS APPLIANCES.
Check your local building codes for the proper method of installation. In the absence of local codes, this unit should be installed in accordance with the National Fuel Gas Code ANSI Z223.1/NFPA 54, Storage and Handling of Liquefied Petroleum Gases, ANSI/NFPA 58 or CSA B149.1 Natural Gas and Propane Installation Code, and the National Electrical Code, ANSI/NFPA 70.
CALIFORNIA PROPOSITION 65-WARNING
The burning of gas fuel generates some byproducts, which are known by the State of California to cause cancer or reproductive harm. To minimize exposure to these substances, always operate this unit according to the care and use manual, ensuring you provide good ventilation when cooking with gas.
SAFETY PRACTICES TO AVOID INJURY
When properly cared for, your grill will provide safe, reliable service for many years. However, extreme care must be used as the grill produces intense heat that can increase accident potential.
When using this appliance basic safety practices must be followed, including the following:
Do not repair or replace any part of the grill unless specifically recommended in this manual. All other service should be referred to a qualified technician.
The grill is for outdoor use only.
4
The grill is not intended to be installed in or on recreational vehicles and/or boats.
Children should not be left alone or unattended in an area where the grill is being used. Do not allow children to sit, stand or play on or around the grill at any time.
Do not store items of interest to children around or below the grill or cart. Do not allow children to crawl inside the cart.
Never let clothing, pot holders or other flammable materials come in contact with or too close to any grate, burner or hot surface until it has cooled.
The fabric could ignite, causing serious personal injury.
For personal safety, wear proper apparel. Loose fitting garments or sleeves should never be worn while using this appliance. Some synthetic fabrics are highly flammable and should not be worn while cooking.
Only certain types of glass, ceramic, earthenware, or other glazed utensils are suitable for grill use. Other types of materials may shatter with sudden temperature changes. Use only on low or medium heat settings in accordance with the manufacturer’s guidelines.
Do not heat unopened food containers as a buildup of pressure may cause the containers to burst.
Use a covered hand when opening the grill lid. Never lean over an open grill.
When lighting a burner, always pay close attention to what you are doing. Make certain you are aware of which burner you are lighting so that your body and clothing remain clear of open flames.
SAFETY INSTRUCTIONS 
When using the grill, do not touch the grill rack, burner grate or immediate surroundings as these areas become extremely hot and could cause burns. Use only dry potholders. Moist or damp potholders on hot surfaces may cause steam burns. Do not use a towel or bulky cloth in place of potholders. Do not allow potholders to touch hot portions of the grill rack.
Grease is flammable. Let hot grease cool before attempting to handle it. Do not allow grease deposits to collect in the grease tray at the bottom of the grill’s firebox. Clean the grease tray often.
Do not use aluminum foil to line the grill racks or grill bottom. This can severely upset combustion air flow or trap excessive heat in the control area.
For proper lighting and performance of the burners, keep the burner ports clean. It is necessary to clean them periodically for optimum performance. The burners will only operate in one position and must be mounted correctly for safe operation.
Clean the grill with caution. To avoid steam burns, do not use a wet sponge or cloth to clean the grill while it is hot. Some cleaners produce noxious fumes or can ignite if applied to a hot surface.
INSECT WARNING
Spiders and other insects can nest inside the burners of this and other grills, which could disrupt gas flow. This dangerous condition could cause a fire behind and beneath the valve panel, damaging the grill and making it unsafe for operation.
Inspect the grill at least twice a year.
Never use a dented or rusty propane cylinder.
Turn off all control knobs and make certain the grill is cool before using any type of aerosol cleaner on or around it. The chemical that produces the spraying action could, in the presence of heat, ignite or cause metal parts to corrode.
Do not use the grill to cook excessively fatty meats or other products that promote flare-ups.
Do not operate the grill under unprotected combustible constructions. Use only in well ventilated areas. Do not use in buildings, garages, sheds, breezeways or other such enclosed areas.
This unit is intended for outdoor use only.
Keep the areas surrounding the grill free from combustible materials including, fluids, trash, and vapors such as gasoline or charcoal lighter fluid. Do not obstruct the flow of combustion and ventilation air. If the unit is stored indoors, make sure it is cool.
Do not use briquettes of any kind in the grill.
The 720-0163 liquid propane gas grill is designed for optimum performance without the use of briquettes. Do not place briquettes on the flame tamers, as this will block the vent to the grill burners. Adding briquettes can damage ignition components and knobs, thus voiding the warranty.
Keep the back of the cart free and clear from debris. Keep electrical supply cords and the rotisserie motor cord away from heated areas of the grill.
Never use the grill in extremely windy conditions. If located in a consistently windy area (oceanfront, mountaintop, etc.), a windbreak will be required. Always adhere to the clearance specifications.
PLACEMENT OF THE GRILL
CLEARANCE Non-Combustible Construction
A minimum of 3 inches clearance from the back of the grill to non-combustible materials are required for the lid to open fully.
WARNING
Do not install this unit into combustible enclosures. There should be a minimum clearance of 24 inches from all sides to combustible materials.
LOCATION
When determining a suitable location take into account concerns such as exposure to wind, proximity to traffic paths, and keeping gas supply lines as short as possible.
Place the grill in well-ventilated areas. Never place the grill in a building, garage, breezeway, shed or other such enclosed areas. During heavy use, the grill will produce a lot of smoke.
5
SIDE BURNER & SIDE SHELF ASSEMBLY 
Estimated Assembly Time: Approximately 10 minutes
Required Tools: Phillips Screwdriver (not included)
1.Remove both side burner and side shelf from inside grill cart.
2.The screws used to attach the side shelf and side burner are already screwed into the side of the grill cart. Remove the screws from the side panels.
3.Align the holes of the left side shelf with those in the grill cart, insert the screws and tighten. Note: The top two screws insert from inside the fire box while the bottom two screws insert from under the left side shelf.
4.Repeat steps 2 and 3 to install the right side burner to the right side panel.
Secure top two screws from inside the fire box.
Secure bottom two screws from below the side shelf.
6
Secure bottom screw from below the side shelf front panel and side burner control panel.
SIDE BURNER HOSE QUICK-CONNECT ASSEMBLY
Estimated Assembly Time: Approximately 5 minutes
No Tools Required
1.Insert the side burner hose with female sleeve through side panel of cart (Top drawing).
2.Push the sleeve of the female socket back and insert male end of the connector. Release the sleeve.
3.Push the socket until the female sleeve snaps forward to lock the fitting.
4.To disconnect the fitting, push the female sleeve back and pull the socket off the plug (bottom drawing).
WARNING
1. Attach the coupling half (socket) to the gas supply line in accordance with NFPA54/ANSI Z223.1FUEL gas code.
2.Prior to inserting the plug, test the connection for leaks following the leak test instructions on page 12.
After the leak test is completed, rinse the connection with clean water to remove any corrosive residue.
3.Do not use open flame to test for leaks.
7
Loading...