Graham Field JB0160-015B, JB0160-015, JB0160-010B, JB0160-010-220, JB0160-010 User Manual

...
5 (1)
OXYGEN CONCENTRATOR
USER MANUAL
Model Numbers JB0160-010B, JB0160-010,
JB0160-010B-220, JB0160-010-220
and
JB0160-015B, JB0160-015, JB0160-015B-220,
JB0160-015-220 with O
Sensor
Important: Do not operate this concentrator without
rst reading and understanding this manual!
Save this manual for future use.
2 John Bunn O2 Premier Oxygen Concentrator
All specications and product congurations are subject to
change without notication.
CONTENTS
1 SAFETY ................................................................................... 3
Important Information .................................................................. 3
Before Installation......................................................................... 3
Placement ......................................................................................4
Fire Warning & Explosion ............................................................. 4
Maintenance .................................................................................. 5
Radio Frequency Interference ..................................................... 5
Additional Safety Warnings ..........................................................6
2 FEATURES .............................................................................. 8
Summary........................................................................................ 8
Characteristics .............................................................................. 8
3 HANDLING .............................................................................. 9
GF Health Products, Inc. Freight Policy ......................................9
Unpacking .....................................................................................9
Inspection .................................................................................... 10
Storage ........................................................................................10
4 OPERATION AND INSTALLATION ...................................... 11
Preparing the Concentrator ....................................................... 11
Turning the Concentrator On .....................................................12
Turning the Concentrator Off..................................................... 12
5 MAINTENANCE .................................................................... 13
Cleaning the Cabinet .................................................................. 13
Cleaning or Replacing the Filters (3 Types) .............................. 13
Cleaning the Optional Humidier Bottle ................................... 15
Replacing the Battery ................................................................. 15
6 TROUBLESHOOTING GUIDE .............................................. 16
7 BILL OF MATERIALS ...........................................................
18
Replacement Parts and Optional Accessories ........................ 18
8 SPECIFICATIONS ................................................................. 19
Normal Operation Conditions .................................................... 19
9 LIMITED WARRANTY ......................................................... 20
10 INDEX.................................................................................... 22
11 PRODUCT REGISTRATION ................................................
24
3John Bunn O2 Premier Oxygen Concentrator
1 SAFETY
The John Bunn O2 Premier oxygen concentrator is intend-
ed for use as an oxygen supplement device in a home or
care facility. Use the concentrator only as prescribed by a
physician. This user manual serves as a reference for your
oxygen concentrator.
Important Information
Please note the following special statements, used
throughout this manual, and their signicance:
Note: Explanatory information.
s
Damage: Action could result in damage to equipment.
ATTENTION: Action could result in personal injury.
CAUTION: Action could result in electric shock.
WARNING: Action could result in fire and explosion.
Before Installation
s
Damage: During transport, always keep the concentrator
upright to prevent damage.
s
Damage: Only use stable and safe electrical power
sources.
Federal Law (USA) restricts this device to sale by or
on the order of a physician. This product should not
be used unless the operator has been instructed by a
qualified health care professional.
WARNING: Users who require continuous oxygenation
must plan for alternate reserve sources of power and
oxygen in the event of a failure or loss of power and
oxygen. This device is to be used ONLY as an oxygen
supplement device and is NOT intended to be a life-
supporting or life-sustaining device.
4 John Bunn O2 Premier Oxygen Concentrator
s
Damage: If the electrical power source becomes
unstable, discontinue use and find an alternate source.
s
Damage: The oxygen concentrator cabinet contains no
serviceable parts! The oxygen concentrator cabinet
should ONLY be opened by an authorized equipment
provider.
Placement
ATTENTION: The oxygen concentrator is intended to
be rolled from room to room. Do not place the oxygen
concentrator in surroundings where its airflow is
obstructed.
ATTENTION: Be certain to place the unit so that all sides
are at least 12 inches (30 cm) away from walls, draperies,
furniture, or other obstructions. Do not place the unit in a
confined area.
ATTENTION: The oxygen concentrator MUST be kept
away from heat, fire and excessive water sources and
conditions.
ATTENTION: Do not place items on top of the
concentrator.
ATTENTION: NEVER block the concentrator’s air openings.
ATTENTION: Always place the concentrator on a hard
surface. Never place the concentrator on a surface such
as bed or couch, where the concentrator may tip or fall.
ATTENTION: Keep the concentrator openings free from
lint, hair, etc.
Fire Warning & Explosion
WARNING: Keep the concentrator away from flammable
and explosive areas.
5John Bunn O2 Premier Oxygen Concentrator
WARNING: To reduce the risk of fire, special care must
be taken when using oxygen concentrators. DO NOT
SMOKE while using this device. Keep all matches, lighted
cigarettes or other sources of ignition out of the room in
which this concentrator is located. In public settings or
when used in hospital or long-term care environments,
prominently display NO SMOKING signs.
WARNING: Textiles and other materials that normally
would not easily burn, can ignite and burn with great
intensity in oxygen enriched air.
WARNING: A spontaneous and violent ignition may occur
if oil, grease or greasy substances come in contact with
oxygen under pressure. ALWAYS keep these substances
away from the oxygen concentrator and all other
oxygen equipment. DO NOT use any lubricants unless
recommended by manufacturer.
WARNING: Failure to observe these warnings can result in
severe fire, property damage and cause physical injury or
DEATH.
Maintenance
CAUTION: The oxygen concentrator was specifically
designed to minimize routine preventive maintenance.
Only an authorized equipment provider or factory-trained
personnel should perform preventive maintenance or
adjustments to the oxygen concentrator.
Radio Frequency Interference
Most electronic equipment is inuenced by Radio Fre-
quency Interference (RFI). ALWAYS exercise CAUTION with
regard to the use of portable communications equipment
in the area around such equipment.
6 John Bunn O2 Premier Oxygen Concentrator
Additional Safety Warnings
WARNING: TO REDUCE THE RISK OF BURNS,
ELECTROCUTION, FIRE OR INJURY TO PERSONS, avoid
using while bathing. If continuous usage is required by
the direction of a physician, the concentrator must be
located in another room at least 9 feet (2.8m) from the
bath.
WARNING: DO NOT reach for a concentrator that has
fallen into water. UNPLUG IT IMMEDIATELY.
WARNING: In certain circumstances, oxygen therapy can
be hazardous. Graham-Field recommends that you seek
medical advice before using this product.
WARNING: Avoid creation of any spark near medical
oxygen equipment. This includes sparks from static
electricity created by any type of friction.
ATTENTION: DO NOT come in contact with the concentrator
when you are wet.
ATTENTION: DO NOT place or store the concentrator where
it can drop into water or other liquid.
ATTENTION: NEVER leave the concentrator unattended
when plugged in.
ATTENTION: This device is to be used only in accordance
with the prescription of a physician and this user manual.
If at any time the patient or attendant concludes that
the patient is receiving an insufficient amount of oxygen,
contact the provider and/or physician immediately.
NEVER make adjustments to the flow rate unless
prescribed by a physician.
7John Bunn O2 Premier Oxygen Concentrator
ATTENTION: ALWAYS supervise closely when this
product is used near children or those who require close
supervision.
ATTENTION: Only use this device as intended and
described in this manual.
ATTENTION: DO NOT use parts, accessories or adapters
other than those authorized by manufacturer.
ATTENTION: DO NOT connect the concentrator in parallel
or series with other oxygen concentrators or oxygen
therapy devices.
ATTENTION: JB0160-015B, JB0160-015, JB0160-015B-220
and JB0160-015-220 only: Discontinue concentrator use
immediately if O
2
sensor red warning light illuminates;
oxygen concentration is too low for safe use. Contact
your Graham-Field equipment provider immediately.
8 John Bunn O2 Premier Oxygen Concentrator
2 FEATURES
Summary
The John Bunn O
2
Premier oxygen concentrator is intend-
ed for use as an oxygen supplement device in a home or
care facility. Use the concentrator only as prescribed by a
physician.
The concentrator separates oxygen from ambient air,
providing the user a high concentration of oxygen. Oxygen
concentrator usage is therapeutically equivalent to other
types of oxygen delivery systems.
Characteristics
Reliable, safe, complete plastic outer shell.
Display screen shows total elapsed working hours.
Pressure safety valve helps ensure operating pressure.
Power loss alarm function.
High and low pressure alarm function.
Heat protection to ensure the safety of the compressor
and concentrator.
JB0160-015B, JB0160-015, JB0160-015B-220, and
JB0160-015-220 only: O2 sensor (electro-chemical de-
vice): Yellow fault light illuminates when O
2
concen-
tration is greater than 71% and less than 82%; system
works. Red warning light illuminates when O
2
concen-
tration is less than 71%; system shuts off.
9John Bunn O2 Premier Oxygen Concentrator
3 HANDLING
GF Health Products, Inc. Freight Policy
For Your Protection, Read Carefully
The carrier accepted this merchandise “in good condition”
and is responsible for safe delivery.
Before signing the freight bill, inspect the shipment care-
fully for damage or missing pieces.
Apparent Loss or Damage
Should visual inspection show loss or damage, this MUST
be noted on the freight bill and signed by the carrier’s
agent. Failure to do so may result in the carrier failing to
honor the claim. Please contact the carrier to obtain the
paperwork necessary to le a claim.
Concealed Loss or Damage
If damage is discovered after delivery is made, a concealed
damage claim must be entered with the freight carrier.
When this occurs, make a written request to the carrier
for inspection. This request for inspection must be made
within 15 days of delivery. The carrier will provide all
paperwork necessary to le a concealed damage or loss
claim, since such damage or loss is the carrier’s responsi-
bility.
Unpacking
Note: Unless the oxygen concentrator is to be used
immediately, retain containers and packing materials
for storage until concentrator use is required.
1. Check for obvious damage to the carton or its contents.
If damage is evident, please notify the carrier and your
Graham-Field equipment provider.
2. Remove all loose packing from the carton.
3. Carefully remove all the components from the carton.
Loading...
+ 19 hidden pages