Char-Broil WILD WEST TRADITION 10201600 User Manual

Size:
2.14 Mb
Download

Product Guide

Model 10201600

Wild West Tradition

Tools needed for assembly:

Pliers

Adjustable wrenches

IMPORTANT: Fill out the product record information below.

Serial Number

Date Purchased

Estimated Assembly Time: 1 Hour

FOR OUTDOOR USE ONLY

CAUTION:WARNING:

Read and follow all safety statements, assembly instructions, and use and care directions before attempting to assemble and cook.

INSTALLER/ASSEMBLER:

Leave this manual with consumer.

CONSUMER:

Keep this manual for future reference.

WARNING:

CARBON MONOXIDE HAZARD

Burning charcoal indoors can kill you. It gives off carbon monoxide, which has no odor. NEVER burn charcoal inside homes, vehicles, or tents.

Failure to follow all manufacturer’s instructions could result in serious personal injury and/or property damage.

CAUTION:

Some parts may contain sharp edges – especially as noted in the manual! Wear protective gloves if necessary.

CAUTION:

THIS UNIT IS HEAVY! DO NOT attempt to assemble without a helper.

The following are trademarks registered by W.C. Bradley Co. in the U.S. Patent and Trademark Office: Caldera®; Charcoal2Go®; Char-Broil®;America's Legendary Barbeque Company®; American Gourmet®; Bandera®; Brush Hawg®; CB 940®;Char-Diamonds®;Char-BroilCharcoal/Gas®; Everybody Grills®; Everybody Outside®; FastStart®; Grill 2 Go®; Grill 2 Go® Express®; Grill Lovers®; Infrared Grilling That’s All About U®; Keepers of the Flame®; New Braunfels Smoker Company®; Patio Bistro®; Patio Caddie®; Patio Kitchen®;Pro-Sear®;RED®; Quantum®; Santa Fe®; Sear and Grill®; Sierra®; Signature Series®; Sure2Burn®; The Big Easy®; Trentino®; U®; Wild West Tradition®; and the following marks:

® ®

The following are trademarks of W.C. Bradley Co.: Advantage Series™; Auto-Clean™;ChefTested™; Commercial Series™; Designer Series™;; Diamond Flame™; Double Chef™; Fireball™; Firenzy™; FlavorMaster™;Front Avenue™; Grill 2 Go® Advantage™; Hog and Yard Bird™; H20 Smoker™; Infrared. Grilling’s Juicy Little Secret™; Incredible Taste. Infallible Results™; Infrared Inside™; Insure™; Let’s Grill Something Together™;Lev-Alert™;Longhorn™; Magneto™; Precision Flame™; Quick2Burn™; QuickSet™; Ready When You Are™; Season, Set, And Savor™; Sizzle On The Grill™; Signature Series™; SureFire™; The Minute Grill™;Torchfork™; Universal Grill Parts™; You Bring the Party™ TEC™ is a trademark of Tec Infrared Grills.

Protected under one or more of the following U.S. Patents: 5,421,319; 5,458,309; 5,579,755; 5,996,573; 6,135,104; 6,279,566; 6,331,108; 6,484,900; 6,526,876; 6,595,197; 6,640,799; 6,640,803; 6,729,873; 6,739,473; 6,749,424; 6,792,935; 6,951,213; 7,047,590; 7,516,693; D364,535; D372,637; D373,701; D377,735; D383,035; D397,910; D405,643; D406,005; D406,009 ; D413,043; D413,229; D414,982; D415,388; D416,164; D416,441; D417,587; D417,588; D422,516; D423,274; D423,876; D428,303; D430,772; D435,396; D436,004; D438,059; D438,060; D438,427; D439,110; D442,505; D443,179; D443,354; D443,464; D447,384; D447,385; D447,909; D448,610; D448,614; D448,615; D448,616; D448,975; D449,492; D450,544; D451,759; D454,028; D454,031; D455,205; D455,206; D456,202; D456,222; D456,223; D457,789; D458,520; D458,760; D458,802; D459,088; D459,148 D459,149; D459,161; D459,163; D459,586; D459,943; D460,312; D460,313; D460,318; D461,359; D465,123; D465,693; D466,307; D466,439; D466,752; D473,414; D474,371; D477,498; D477,501; D477,504; D477,506; D477,746; D478,471; D478,472; D480,914; D491,410; D494,009; D494,413; D498,523; D500,359; D504,048; D530,098; D535,000; Canada:D97,504;D99,355; D102,037; D104,200;D108,377; 2,315,567; France:D010,231;D010,422;D010,590;D010,849; 1,089,646; South Korea: 384,565; United Kingdom: 2,099,402. Other Patents Pending. © 2009 W.C. Bradley Company

TM REVISION 03

If you have questions or need assistance during assembly, please call 1-800-241-7548.

To insure your satisfaction and for follow-upservice, register your appliance online atwww.charbroil.com/register

42804520 - 09/24/09

TABLE OF CONTENTS

Product Record Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1

For Your Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Safety Symbols . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2

Preparing to use your Smoker . . . . . . . . . . . . . . . . . . . . . . . . . . 3

Cooking Tips . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Smoker Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

Limited Warranty. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

Parts List/ Parts Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7

Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-14

Registration Card . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16

WARNING

FAILURE TO READ AND FOLLOW INSTRUCTIONS FOR

LIGHTING CHARCOAL MAY RESULT IN SERIOUS PERSONAL

INJURY AND OR PROPERTY DAMAGE.

WARNING

Most surfaces on this unit are hot when in use. Use extreme caution. Keep others away from unit. Always wear protective clothing to prevent injury.

Keep children and pets away.

Do not move this unit during operation.

Never substitute gasoline, kerosene or alcohol for charcoal starter. In some states, the use of charcoal starter is prohibited by law. In this case, paraffin-basedstarter cubes can be substituted for charcoal starter. Never use charcoal starter fluid with an electric starter.

This instruction manual contains important information necessary for the proper assembly and safe use of the appliance.

Follow all warnings and instructions when using the appliance.

Safety Symbols

The symbols and boxes shown below explain what each heading means. Read and follow all of the messages found throughout the manual.

DANGER

DANGER: Indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury.

WARNING

WARNING: Indicates a potentially hazardous situation which, if not avoided, could result in death or serious injury.

CAUTION

CAUTION: Indicates a potentially hazardous situation or unsafe practice which, if not avoided, may result in minor or moderate injury.

2

WARNING

CALIFORNIA PROPOSITION 65

1.Combustible by-productsproduced when using this product contains chemicals known to the State of California to cause cancer, birth defects, or other reproductive harm.

2.This product contains chemicals, including lead and lead compounds, known to the State of California to cause cancer, birth defects or other reproductive harm.

Wash your hands after handling this product.

WARNING

All surfaces can be hot during use. Use protection as required to prevent burning.

Do not use this unit on or near combustible surfaces or structures such as wood decks, dry leaves or grass, vinyl or wood siding, etc.

SEE OWNERS MANUAL FOR IMPORTANT SAFETY INFORMATION.

CAUTION

For residential use only. Do not use for commercial cooking.

Preparing and Using Your Smoker

Before cooking with your Smoker, the following steps should be closely followed to both cure the finish and season

the interior steel. Failure to properly follow these steps may damage the finish and/or impart metallic flavors to your first foods.

1.Brush all interior surfaces including grills and grates with vegetable cooking oil.

2.Build a small fire on the fire grate, being sure not to lay coals against the walls.

3.Close door. (Position butterfly damper and smokestack damper approximately at one quarter open.) This burn should be sustained for at least two hours, the longer the better. Then, begin increasing temperature by opening the butterfly damper and smokestack damper half-wayand adding more charcoal. Your Smoker is now ready for

use.

Rust can appear on the inside of your smoker. Maintaining a light coat of vegetable oil on interior surfaces will aid in the protection of your unit. Exterior surfaces of smoker may need occasional touch up. We recommend the use of a commercially available black high temperature spray paint. NEVER PAINT THE INTERIOR OF THE UNIT !

GRILLING

Wood is recommended, however charcoal or a combination of both may be used as the fuel source for grilling, with the fuel source placed and ignited on the fire grate. Do not build too large of a fire. We recommend starting a fire with no more than 4 pounds of charcoal (approximately 60 briquets) and adding more as needed during cooking. After allowing the fire to burn down, place the cooking grills in the smoker. Failure to read and follow instructions for lighting charcoal may result in serious personal injury and/or property damage.

SMOKING AND SLOW COOKING

If using the Smoker as a smoker or slow cooker, remove the cooking grill from the firebox and build your fire on top of the fire grate in the firebox. Either charcoal or wood may be used, but wood is the recommended fuel for it’s rate of

burn and the flavor it imparts to the food being cooked. Most seasoned hardwoods are good for smoking such as hickory, mesquite, pecan, oak, and many other fruit woods. The firebox will accommodate most split fireplace size logs (16”). Bark should be avoided or burned off first as it contains a high acid content and imparts an acrid flavor.

After allowing the fire to burn down, close the doors and control the temperature and smoke with the dampers located on the firebox and atop the smokestack. Smoke is contained within the chambers, which will reduce burn while imparting more smoke flavor. Do not operate the Smoker with temperatures exceeding 450 degrees in the smoker chamber. Place the food in the smoker chamber and monitor the temperature. Cooking and smoking are taking place using indirect heat. There is no need to worry about a grease fire flare-upruining the food. Do not place food within 6” of the opening from the firebox into the smoker chamber. A general rule of thumb for cooking is about 1 hour per pound for smoking large cuts of meat. Refer to a cook book for specific cuts of meats. Limit the number of times you open the smoker chamber door as this will allow heat to escape and extend the cooking time.

Grilling with Wood Chips/Wood Chunks

For a more robust smoke flavor while using charcoal briquettes or lump charcoal, try adding wood chips or several wood chunks to the fire. Wood chunks are available in a variety of natural flavors, and can be used alone or in addition to charcoal. As a general rule, any hardwood that bears a fruit or nut is suitable for cooking. However, different woods have very different tastes. Experiment with different woods to determine your personal favorite, and always use well-seasonedwood. Green orfresh-cutwood can turn food black, and tastes bitter.

Our Recommendations:

Chicken - Alder, Apple, Hickory, Mesquite, Sassafras

Beef - Hickory, Mesquite, Oak, Grapevines

Pork - Fruitwoods, Hickory, Oak, Sassafras

Lamb - Fruitwoods, Mesquite

Veal - Fruitwoods, Grapevines

Seafood - Alder, Mesquite, Sassafras, Grapevines

Vegetables – Mesquite

USDA Recommended

Internal Cooking Temperatures

Ground Meat

 

Beef, Pork, Veal, Lamb......................................

160°F

Turkey, Chicken.................................................

165°F

Fresh Beef, Veal, Lamb

 

Medium Rare.......................................................

145°F

Medium................................................................

160°F

Well Done............................................................

170°F

Poultry

 

Chicken & Turkey, whole.....................................

165°F

Poultry Parts.......................................................

165°F

Duck & Goose....................................................

165°F

Fresh Pork

 

Medium..............................................................

160°F

Well Done..........................................................

170°F

3

COOKING TIPS

Building Your Fire

1.) Stack charcoal briquettes or wood into a pyramid-shapedpile on top of the charcoal grate or ash pan. We recommend using 4 pounds (approximately 60 briquettes) to start your fire, adding more as needed.

2.) If using lighter fluid, saturate the charcoal briquettes with lighter fluid and let it soak in for approximately 5 minutes. If using a chimney starter, electric starter, or other type of fire starter, light your fire according to the manufacturer's instructions.

3.) After allowing the lighter fluid to properly soak in, light the pile of briquettes in several locations to ensure an even burn. Always light the fire with the grill lid open.

Leave lid open until briquettes are fully lit. Failure to do this could trap fumes from charcoal lighter fluid in grill and may result in a flash fire when lid is opened.

4.) Never add charcoal lighter fluid to hot or warm coals as flashbacks may occur causing injury.

5.) You are ready to begin cooking when the pile of briquettes ashes over and produces a red glow (approximately 12 – 15 minutes).

6.) Depending on your cooking method, either leave the briquettes in a pile or spread evenly across the charcoal grate using a long-handledpoker.

*Always use caution when handling hot coals to prevent injury.

Know When Your Fire is Ready

Successful charcoal grilling depends on a good fire. The general rule for knowing when your coals are ready for grilling is to make sure that 80 percent or more of the coals are ashy gray. If you have less than that, the coals are not ready, and if all of them are glowing red hot, the fire is probably too hot. Here are a few steps you can take to adjust the temperature of your fire:

-If it is too hot, spread the coals out a bit more, which makes the fire less intense.

-Raise or lower the adjustable charcoal grate.

-Partially close the vents in the grill, which reduces the amount of oxygen that feeds the fire.

-Use the indirect grilling method, with coals to either side of a drip pan and the food over the pan rather than directly over the coals.

-In the event of a severe flare-up,spray the flames with water from a squirt bottle. Be careful, spraying with water tends to blow ashes around and make a mess.

-Add briquettes 2 or 3 at a time to increase the burn time. Allow 10 minutes for coals to ash over before adding more.

THE HEAT OF THE COALS

seconds you can

 

 

 

hold the palm of

 

 

 

your hand 4 inches

 

 

 

above the coals

temperature range (Fº)

visual cues

 

 

 

 

 

HOT COALS

2

400 to 450

 

barely covered with

 

 

 

 

gray ash; deep red glow

MODERATELY HOT

3

375 to 450

thin coating of gray

TO HOT COALS

 

 

 

ash; deep red glow

MODERATELY HOT COALS

4

325 to 375

 

significant coating of

 

 

 

 

gray ash; red glow

MODERATELY COOL COALS 5

300 to 325

 

thick coating of gray

 

 

 

 

ash; dull red glow

4

GRILL MAINTENANCE

Frequency of cleanup is determined by how much your smoker is used. Make sure coals are completely extinguished before cleaning inside of smoker. Inside surfaces may be cleaned with a strong solution of detergent and water applied with a scrub brush. Thoroughly rinse with water and allow to air dry before using again.

If a bristle brush is used to clean any of the grill cooking surfaces, ensure no loose bristles remain on cooking surfaces prior to grilling. It is not recommended to clean cooking surfaces while grill is hot.

HELPFUL HINTS

If food seems to be getting too smoky or brown before the cooking time is finished, cover it loosely with heavy duty aluminum foil.

•Remove the ash after each use.

•Covered side dishes can be warmed in smoker chamber.

•To prevent flare-ups,brush meat lightly with oil before grilling. •Keep a small squirt bottle of water handy for grillingflare-ups.

5

LIMITED WARRANTY

This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indicated below beginning on the date of purchase*. The manufacturer reserves the right to require that defective parts be returned, postage and or freightpre-paidby the consumer for review and examination.

SCOPE OF COVERAGE

PERIOD OF COVERAGE

TYPE OF FAILURE COVERAGE

All Parts

90 days from date of purchase*

PERFORATION, MANUFACTURING,

 

 

AND MATERIAL DEFECTS ONLY

 

 

 

*Note: A dated sales reciept WILL be required for warranty service.

The original consumer-purchaserwill be responsible for all shipping charges for parts replaced under the terms of this limited warranty.

This limited warranty is applicable in the United States and Canada only, is only available to the original owner of the product and is not transferable. Manufacturer requires proof of your date of purchase. Therefore, you should retain your sales slip or invoice. Registering your product is not a substitute for proof of purchase and the manufacturer is not responsible for or required to retain proof of purchase records.

This limited warranty applies to the functionality of the product ONLY and does not cover cosmetic issues such as scratches, dents, corrosions or discoloring by heat, abrasive and chemical cleaners or any tools used in the assembly or installation of the appliance, surface rust, or the discoloration of stainless steel surfaces. RUST is not considered a manufacturing or materials defect.

This limited warranty will not reimburse you for the cost of any inconvenience, food, personal injury or property damage.

ITEMS MANUFACTURER WILL NOT PAY FOR:

1.Shipping cost, standard or expedited, for warranty and replacement parts

2.Service calls to your home.

3.Repairs when your product is used for other than normal, single-familyhousehold or residential use.

4.Damage, failures, or operating difficulties resulting from accident, alteration, careless handling, misuse, abuse, fire, flood,

acts of God, improper installation or maintenance, installation not in accordance with electrical or plumbing codes, or use of products not approved by the manufacturer.

5. Any food loss due to product failures or operating difficulties.

6. Replacement parts or repair labor costs for units operated outside the United States or Canada. 7. Pickup and delivery of your product.

8. Repairs to parts or systems resulting from unauthorized modifications made to the product. 9. The removal and/or reinstallation of your product.

DISCLAIMER OF IMPLIED WARRANTIES and LIMITATION OF REMEDIES

Repair or replacement of defective parts is your exclusive remedy under the terms of this limited warranty. Manufacturer will not be responsible for any consequential or incidental damages arising from the breach of either this limited warranty or any applicable implied warranty, or for failure or damage resulting from acts of God, improper care and maintenance, grease fire, accident, alteration, replacement of parts by anyone other than Manufacturer, misuse, transportation, commercial use, abuse, hostile environments (inclement weather, acts of nature, animal tampering), improper installation or installation not in accordance with local codes or printed manufacturer instructions.

THIS LIMITED WARRANTY IS THE SOLE EXPRESS WARRANTY GIVEN BY THE MANUFACTURER. NO PRODUCT PERFORMANCE SPECIFICATION OR DESCRIPTION WHEREVER APPEARING IS WARRANTED BY MANUFACTURER EXCEPT TO THE EXTENT SET FORTH IN THIS LIMITED WARRANTY. ANY IMPLIED WARRANTY PROTECTION ARISING UNDER THE LAWS OF ANY STATE, INCLUDING IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR A PARTICULAR PURPOSE OR USE, IS HEREBY LIMITED IN DURATION TO THE DURATION OF THIS LIMITED WARRANTY.

Neither dealers nor the retail establishment selling this product has any authority to make any additional warranties or to promise remedies

in addition to or inconsistent with those stated above. Manufacturer'smaximum liability, in any event, shall not exceed the purchase price of the product paid by the original consumer.

NOTE: Some states do not allow an exclusion or limitation of incidental or consequential damages, so some of the above limitations or exclusions may not apply to you. This limited warranty gives you specific legal rights as set foth herein. You may also have other rights which vary from state to state. In the state of California only, if refinishing or replacement of the product is not commercially practicable, the retailer selling this product or the Manufacturer will refund the purchase price paid for the product, less the amount directly attributable to use by the original consumer-purchaserprior to discovery of the nonconformity. In addition, in the state of California only, you may take the product to the retail establishment selling this product in order to obtain performance under this limited warranty.

If you wish to obtain performance of any obligation under this limited warranty, you should

write to:

Consumer Relations

P. O. Box 1240

Columbus, GA 31902-1240

Consumer returns will not be accepted unless a valid Return Authorization is first acquired. Authorized returns are clearly marked on the outside of the package with an RA number and the package is shipped freight/postage pre-paid.Consumer returns that do not meet these standards will be

refused.

WS_1 Rev02

6

PARTS LIST

Key

Qty

Description

Key

Qty

Description

A

1

Axle

K

2

Long Leg Assembly

B

1

Pull Handle

L

2

Wheel Assembly, 13"

C

3

Wire Fire Grate

M

1

Front Shelf Assembly

D

1

Firebox Door Latch

N

1

Butterfly Damper Assembly

E

2

Large Cast Iron Cooking Grate

O

2

Handle Rod

F

1

Small Cast Iron Cooking Grate

P

2

Handle Barrel Spring

G

1

Smoke Chamber Assembly

---

1

Hardware Pack

H

1

Firebox Assembly

---

1

Assembly Instructions English

I1 Smokestack Assembly

J2 Short Leg Assembly

 

H

 

F

E

I

E

B K

D

M

G J

A

P C C

C LL

O

N

7

ASSEMBLY

FIRST, GET A HELPER! This unit is heavy and requires a second person for lifting and moving.NEXT, pick a suitable1 location to work. Open the carton and slit the corners so that the carton lays flat. This will give you a protective surface

during assembly. Remove the carton packing material and the parts from inside the firebox and smoke chamber.

Turn the smoke chamber on end so that the heat passage 2 opening is facing up. Match the heat passage opening on

the firebox with the opening on the smoke chamber. Secure the two sections together using eight 3/8-16X1" hex-head bolts, 3/8" lock washers and3/8-16 hex nuts.

NOTE: Opening in Firebox shown for clarity

3/8-16x1"hex head bolt

Firebox

3/8" washer

3/8-16x1”hex-headbolt Qty. 8

3/8-16hex nut

3/8” lock washer

Qty. 8

Smoke Chamber

3/8-16hex nut

Qty. 8

8

With unit still in position from previous steps, insert long legs over 3 leg sockets closest to the floor. Secure each leg to socket using a

3/8-16x3/4” hex-head bolt. Do not fully tighten. Tighten bolts just enough to keep legs from sliding off of sockets.

Leg Socket

3/8-16x3/4”hex-headbolt Qty. 2

3/8-16x3/4"

 

hex head bolt

Long Leg

 

Attach short legs to remaining leg sockets near

4 firebox using 3/8-16x3/4”hex-headbolts. Do not fully tighten. Tighten bolt just enough

to keep leg from sliding off of socket .

3/8-16x3/4”hex-headbolt Qty. 2

Short Leg

NOTE: Axle bushing should

3/8-16x3/4"

be to the outside

hex head bolt

9

Insert hitch pin through the hole at one end of the axle. Slide a 7/16" flat washer onto the axle, then a wheel, then another7/16" flat 5 washer. Slide the axle through the bushings on the bottom of the short legs. At the end of the axle add a7/16" flat washer, wheel,

another 7/16" flat washerand finally the hitch pin.

Hitch Pin

Qty: 2

7/16" flat washer Qty: 4

Axle

7/16" flat washer

Axle Bushing

Carefully stand the unit up onto it’s legs. REMEMBER, THE LEGS ARE NOT FULLY TIGHTENED AND CAN FALL OFF.Adjust the

6 position of the legs on the leg sockets so that the unit will sit at a slight downward angle toward the grease drain in the smoke chamber. Now fully tighten all four leg bolts.

Grease

Drain

10