BOSS 640UI User Manual

Size:
2.5 Mb
Download

CONTENTS LIST

PAGE CONTENTS

2NOTE OF DISCS

3ACCESSORY INCLUDED

4INSTALLATION

6DETACHABLE CONTROL PANEL

7WIRING DIAGRAM

8PANEL OPEN/CLOSE OPERATION

9CONTROL PANEL FUNCTION

10BASIC OPERATIONS

11MENU OPERATION

12AUDIO OPERATION

14TUNER OPERATION

15RDS OPERATION

16CD /MP3/WMA OPERATION

20USB OPERATION

21MEMORY CARD OPERATION

22RECORDING OPERATION

25MUSIC FILES TRANSFERRING

27MUSIC FILES ERASING

29FILES MANAGER

30 iPod OPERATION

32REMOTE FUNCTION

33SPECIFICATIONS

34TROUBLE SHOOTING

1

1. NOTE OF DISCS

MOISTURE CONDENSATION

On a rainy day or in a very damp area, moisture may condense on the lenses inside the unit.

Should this occur, the unit will not operate properly. In such a case, remove the disc and wait for

about an hour until the moisture has evaporated.

NOTES ON CDs

1.A dirty or defective disc may cause sound dropouts while playing. To enjoy optimum sound, handle the disc as follows.

Handle the disc by its edge. To keep the disc clean, do not touch the surface (P.1).

P.1

2.Do not stick paper or tape on the disc (P.2).

P.2

3.Do not expose the discs to direct sunlight or heat sources such as hot air-ducts,or leave them in a car parked in direct sunlight where there can be a considerable rise in temperature inside the car (P.3).

P. 3

4.Before playing, clean the discs with an optional cleaning cloth. Wipe each disc from the centre out (P.4).

P.4

5.Do not use solvents such as benzene, thinner,commercially available cleaners, or antistatic spray intended for analog discs.

NOTES ON DISCS

If you use the discs explained below, the sticky residue can cause the CD to stop spinning and may cause malfunction or ruin your discs.

Do not use second-handor rental CDs that have a sticky residue on the surface (for example, frompeeled-offstickers or from ink, or glue leaking from under the stickers).

There are paste residue.

Ink is sticky (P.5).

****

*******

*******

******* *******

P. 5

Do not use rental CDs with old labels that

are beginning to peel off.

Stickers that are beginning

to peel away, leaving a

**************

sticky residue (P.6).

*******

*******

*******

P. 6

Do not use your CDs with labels or stickers

attached.

Labels are attached (P.7).

*******

******* *******

*******

*******

P. 7

Do Not Use Special Shape CDs

Be sure to use round shape CDs only for this unit and do not use any special shape CDs. Use of special shape CDs may cause the unit to malfunction.(P.8).

P. 8

Be sure to use CDs with disc mark

RECORDABLE

REWRITABLE

TEXT

Only for this unit.

CD-RsandCD-RWswhich have not undergone finalization processing cannot be played. (For more information on finalization processing, refer to the manual for yourCD-R/CD-RWwriting software orCD-R/CD-RWrecorder.) Additionally, depending on the recording status, it may prove impossible to play certain CDs record onCD-RorCD-RW.

2

2. ACCESSORY INCLUDED

When first unpacking your new full detachable DVD head unit, please check first that the package contains all of the items below. If something is missing, contact the store where you purchased the player.

Owner’s Manual

Ow

ner’

 

ma

 

s

 

nu

al

 

 

 

 

Warranty Card

W

 

 

arr

 

Ca

an

ty

rd

 

 

Remote control

Lithium Battery

R20

2

5

C

 

+

 

3V

 

 

Half Sheeve

Insert Key

1.Dashboard

2.Nut (5mm)

3.Spring washer

4.Screw (4X12mm)

5.Screw

6.Support Strap

7.Plain washer

1

6

7

4

2 5 3

3

3. INSTALLATION

Before finally installing the unit, connect the wiring temporarily and make sure it is all connected up properly and the unit and system work properly.

Use only the parts included with the unit to ensure proper installation. The use of unauthorized parts can cause malfunctions.

Consult with your nearest dealer if installation requires the drilling of holes or other modifications of the vehicle.

Install the unit where it does not get in the driver's way and cannot injure the passenger if there is a sudden stop, like an emergency stop.

If installation angle exceeds 30° from horizontal, the unit might not give its optimum performance.

Avoid installing the unit where it would be subject to high temperature, such as from direct sunlight, or from hot air, from heater, or where it would be subject to dust dirt or excessive vibration.

Be sure to remove the front panel before installing the unit.

DIN FRONT/REAR-MOUNT

This unit can be property installed either from “Front” (conventional DIN Front-mount)or “Rear” (DINRear-mountinstallation, utilizing threaded screw holes at the sides of the unit chassis). For details, refer to the following illustrated installation methods A and B.

DIN FRONT-MOUNT(Method A)

Installation the unit

1

2

182

53

3

1

6

7

4

2 5 3

1.Dashboard

2.Holder

After inserting the half sleeve into the dashboard, select the appropriate tab according to the thickness of the dashboard material and bend them inwards to secure the holder in place.

3. Screw

1.Dashboard

2.Nut (5mm)

3.Spring washer

4.Screw (4x12mm)

5.Screw

6.Support Strap

Be sure to use the support strap to secure the back of the unit in place. The strap can be bent by hand to the desired angle.

7.Plain washer

4

Removing the unit

a

b

c

Trim Plate Installation:

a.Frame

b.Insert fingers into the groove in the front of frame and pull out to remove the frame. (When re-attachingthe frame, point the side with a groove down wards and attach it.)

c.Insert the levers supplied with the unit into the grooves at both sides of the unit as shown in figure until they click. Pulling the levers makes it possible to remove the unit from the dashboard.

Push the trim plate against the chassis until it is fitted.

You must do this before you install the front panel, otherwise it can't be attached.

DIN REAR-MOUNT(METHOD B)

Installation using the screw holes on the sides of the unit. Fastening the unit to the factory radio mounting bracket.

2

4

5 3

2

5

1.Select a position where the screw holes of the bracket and the screw holes of the main unit become aligned (are fitted) and tighten the screws at 2 places on each side.

2.Screw

3.Factory radio mounting bracket.

4.Dashboard or Console

5.Hook (Remove this part)

Note: the mounting box, outer trim ring, and half-sleeveare not used for method B installation.

5

4. DETACHABLE CONTROL PANEL (D.C.P.)

Removing The Detachable Control Panel (D.C.P.).

1. Turn the power off

2. Press the D.C.P. release button

3. Remove the D.C.P.

PANEL RELEASE

BUTTON

Attaching the DCP

2

A

B

CAUTION

1.Attach the panel at the right side first, with point B on the main unit touching point A on the D.C.P. (As shown on the diagram).

2.Then press the left side of D.C.P. onto the main unit until a “click” sound is heard.

DO NOT insert the D.C.P from the left side. Doing so may damage it.

The D.C.P can easily be damaged by shocks. After removing it, place it in a protective case and be careful not to drop it or subject it to strong shocks.

When the release button is pressed and the D.C.P is unlocked, the car's vibrations may cause it to fall. To prevent damage to the D.C.P, always store it in a protective case after detaching it.

The rear connector that connects the main unit and the D.C.P is an extremely important part. Be careful not to damage it by pressing on it with fingernails, pens, screwdrivers, etc.

Note:

If the D.C.P is dirty, wipe off the dirt with soft, dry

cloth only. And use a cotton swab soaked in

isopropyl alcohol to clean the socket on the back

Socket

of the D.C.P.

RESETTING THE UNIT:

After releasing the front panel, use a pencil or any non-metalicobject to press & hold the reset button for five seconds to reset the unit.

RESET

6

5. WIRING DIAGRAM (20 PIN + ISO PLUG)

 

 

 

ANTENNA

 

 

 

JACK

cable

 

FUSE

 

readyiPod

WHITE

CH-LCH-R

 

 

 

RED

 

 

YELLOW

 

 

 

 

WHITE

 

 

20-PIN

 

 

 

AUDIO/POWER

 

 

 

BLUE

 

 

 

HARNESS

 

 

 

(See Figure 1)

 

 

 

 

 

 

 

 

 

 

 

 

 

SUB WOOFER WHITE

RCA-TO-RCACABLES

 

 

 

 

 

 

 

 

 

 

 

 

(not supplied)

 

 

 

 

 

 

 

 

 

 

 

 

 

SUB

 

 

 

 

 

 

 

 

 

 

 

 

 

WOOFER

iPod

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

RCA-TO-RCACABLES

 

 

 

 

 

 

 

 

 

GREY

 

WHITE

(not supplied)

 

 

 

 

 

 

 

 

 

 

CH

 

 

 

 

 

 

 

 

 

 

REAR LINE OUT

L-

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

RED

 

 

 

 

 

 

 

 

 

 

 

 

 

R-CH

AMP

 

 

 

 

 

 

 

 

 

BLACK

 

WHITE

 

 

 

 

 

 

 

 

FRONT LINE OUT

L-CH

 

 

 

 

 

 

 

 

 

 

 

 

RED

 

 

 

 

 

 

 

 

 

 

 

 

 

R-CH

 

PIN(B8) GREEN/BLACK

PIN(B7) GREEN

PIN(B6) WHITE/BLACK

PIN(B5) WHITE

PIN(B4) GREY/BLACK

PIN(B3) GREY

PIN(B2) VIOLET/BLACK

PIN(B1) VIOLET

PIN(A8) BLACK

PIN(A7) RED

PIN(A5) BLUE

PIN(A4) YELLOW

 

 

ISO

CONNECTOR

ANTENNA

EXTENDER

CABLE

AUX LINE IN

CONNECTOR

3

4

3

4

CONNECTOR

 

7

8

7

8

 

 

5

6

5

6

 

B

 

 

 

 

A

 

1

2

1

2

 

Figure 2

ISO CONNECTOR 4PIN+8PIN

FEMALE WITH MALE TERMINAL

 

ISO CONNECTOR WIRING CHART

PIN

WIRE COLOR

FUNCTION/LABEL

A4

YELLOW

CONSTANT 12 VOLTS (+)

A5

BLUE

POWER ANTENNA

A7

RED

IGNITION(ACC)

A8

BLACK

GROUND

B1

VIOLET

RIGHT REAR SPEAKER (+)

B2

VIOLET/BLACK

RIGHT REAR SPEAKER (-)

B3

GREY

RIGHT FRONT SPEAKER (+)

B4

GREY/BLACK

RIGHT FRONT SPEAKER (-)

B5

WHITE

LEFT FRONT SPEAKER (+)

B6

WHITE/BLACK

LEFT FRONT SPEAKER (-)

B7

GREEN

LEFT REAR SPEAKER (+)

B8

GREEN/BLACK

LEFT REAR SPEAKER (-)

(See Figure 2)

PIN

WIRE COLOR

FUNCTION/LABEL

1

GREY/BLACK

RIGHT FRONT SPEAKER (-)

 

 

2

GREY

RIGHT FRONT SPEAKER (+)

3

VIOLET

RIGHT REAR SPEAKER (+)

4

VIOLET/BLACK

RIGHT REAR SPEAKER (-)

5

 

 

6

GREEN

LEFT REAR SPEAKER (+)

7

GREEN/BLACK

LEFT REAR SPEAKER (-)

8

RED

IGNITION(ACC)

9

BLACK

REAR PRE-AMPLINE OUT COMMON

10

RED

RIGHT REAR PRE-AMPLINE OUT

11

WHITE

LEFT FRONT SPEAKER (+)

12

WHITE/BLACK

LEFT FRONT SPEAKER (-)

 

 

13

 

 

14

BLUE

POWER ANTENNA

15

YELLOW

CONSTANT 12 VOLTS (+)

16

BLACK

CHASSIS GROUND

17

WHITE

LEFT FRONT PRE-AMPLINE OUT

18

RED

RIGHT FRONT PRE-AMPLINE OUT

19

BLACK

FRONT PRE-AMPLINE OUT COMMON

20

WHITE

LEFT REAR PRE-AMPLINE OUT

7

6. PANEL OPEN/CLOSE OPERATION

This unit is equipped with the most advanced full logic motorized slide down system. You can enjoy this advance technology with just a single press of the “OPEN” button Please read carefully the following operation instruction before operating the unit.

OPEN / CLOSE THE PANEL:

Press the Open button to slide down (open) a closed panel or to slide up (close) an opened panel.

LOADING A CD

When the panel is in the slide down position, the disc slot becomes accessible.

Insert a CD through the disc slot, the CD will be automatically loaded and the panel will also close automatically & playback will begin.

If no CD is inserted, press Open button again to slide up(close) the panel.

EJECTING A CD

Press Open button to slide down the panel, if a CD is loaded, it will be ejected automatically. No further key press is needed.

If the ejected CD is not being removed, after 10 seconds it will be reloaded automatically. And the panel will automatically slide up after disc has been reloaded.

Warning : If the ejected disc remains in the slot, the Open button will not function, so closing the panel by using Open button is prevented unless the disc is removed or reloaded.

CAUTION:

A)Please always use the “OPEN” button to slide up/ down the front panel. Please never try to slide up or down the front panel manually, this will cause serious & permanent damage to the slide down mechanism, and this will void the warranty.

B)Please do not try to detach / remove the front panel ( by pressing the detach button ) or attach the front panel when the panel is in the slide down position. This may cause serious & permanent damage to the unit & panel. Only attach or detach the front panel when the panel is in the slide up position.

8

7. CONTROL PANEL FUNCTION(RDS+iPod)

3

18

1

8

9

7

2

6

10

4

5

22

11

21

20

12

13

14

15

16

17

19

OPERATIONS:

 

SYSTEM

TUNER

CD/MP3/WMA

iPod

KEY

Short

Long

Short

Long

Short

Long

Short

Long

 

Press

Press

Press

Press

Press

Press

Press

Press

 

 

 

 

 

 

 

 

 

1

Power

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

2

Panel Open & Close

 

 

Eject

 

 

 

3

 

 

 

Panel release button

 

 

 

4

Audio Menu

 

 

Enter

 

Enter

 

 

 

 

 

 

 

 

 

 

5

Mode

 

 

 

 

 

 

 

6

Encoder Volume

 

 

 

 

 

 

7

 

 

Band

 

File/Folder

File

iPod

 

 

 

 

Search

Erase

Search

 

8

 

Sub-W

AF

 

 

 

 

 

 

 

 

 

 

 

 

 

 

9

 

Record

TA

 

 

 

 

 

 

Copy

 

 

 

 

 

10

 

ix-Bass

PTY

 

 

 

 

 

11

 

 

PS

AS

ID3

 

iPod

 

 

 

 

informati on

 

12

 

 

M1

Memory 1

Pause

 

Pause

 

 

 

/Play

 

/Play

 

13

 

 

M2

Memory 2

Intro

Folder

 

 

 

 

Intro

 

 

14

 

 

M3

Memory 3

Repeat

Folder

Repeat

Album

 

 

Repeat

Repeat

15

 

 

M4

Memory 4

Random

Fol der

Shuffle

Album

 

 

Rando m

Shuffle

 

 

 

 

 

 

 

16

 

 

M5

Memory 5

Folder

 

 

 

 

 

Down

 

 

 

 

 

 

 

 

 

 

 

17

 

 

M6

Memory 6

Folder

 

 

 

 

 

Up

 

 

 

18

Display

Menu

 

 

 

 

 

 

19

 

 

 

USB Cover / Socket

 

 

 

20

 

 

Seek Up

Tune Up

Track/File

Fast

File Up

Fast

 

 

Up

Forward

Forward

 

 

 

 

 

 

21

 

 

Seek

Tune

Track/File

Fast

File Down

Fast

 

 

 

Down

Down

Down

Backward

 

Backward

22

Mute

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

9