American Dryer Corp -T75 User Manual

Size:
975.19 Kb
Download

T20 / T30 / T50 / T75

Installation/Operator Manual

WARNING: For your safety the information in this manual must be followed to minimize the risk of fire or explosion and to prevent property damage, personal injury or death.

Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS:

Do not try to light any appliance.

Do not touch any electrical switch; do not use any phone in your building.

Clear the room, building or area of all occupants.

Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.

If you cannot reach your gas supplier, call the fire department.

Installation and service must be performed by a qualified installer, service agency or the gas supplier.

AVERTISSEMENT:Assurez-vousde bien suivre les instructions données dans cette notice pour réduire au minimum le risque d’incendie ou d’explosion ou pour éviter tout dommage matériel, toute blessure ou la mort.

Ne pas entreposer ni utiliser d’essence ni d’autres vapeurs ou liquides inflammables à proximité de cet appareil ou de tout autre appareil.

QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:

Ne pas tenter d’allumer d’appareils.

Ne touchez à aucun interrupteur. Ne pas vous servir des téléphones se trouvant dans le bâtiment.

Évacuez la pièce, le bâtiment ou la zone.

Appelez immédiatement votre fournisseur de gaz depuis un voisin. Suivez les instructions du fournisseur.

Si vous ne pouvez rejoindre le fournisseur de gaz, appelez le service des incendies.

L’installation et l’entretien doivent être assurés par un installateur ou un service d’entretien qualifié ou par le fournisseur de gaz.

JLA Limited

Meadowcroft Lane, Halifax Road

Ripponden

West Yorkshire, England

HX6 4AJ

Telephone: 01422 822282 / Fax: 01422 824390

Part No. 113429-9

Retain This Manual in a Safe Place for Future Reference

This product embodies advanced concepts in engineering, design, and safety. If this product is properly maintained, it will provide many years of safe, efficient, and trouble free operation.

Only qualified technicians should service this equipment.

OBSERVE ALL SAFETY PRECAUTIONS displayed on the equipment or specified in the installation manual included with the dryer.

The following “FOR YOUR SAFETY” caution must be posted near the dryer in a prominent location.

FOR YOUR SAFETY

Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

POUR VOTRE SÉCURITÉ

Ne pas entreposer ni utiliser d’essence ni d’autres vapeurs ou liquides inflammables à proximité de cet appareil ou de tout autre appareil.

We have tried to make this manual as complete as possible and hope you will find it useful. The manufacturer reserves the right to make changes from time to time, without notice or obligation, in prices, specifications, colors, and material, and to change or discontinue models. The illustrations included in this manual may not depict your particular dryer exactly.

IMPORTANT

For your convenience, log the following information:

DATE OF PURCHASE __________________________________________________ MODEL NO. ________________________

RESELLER’S NAME ______________________________________________________________________________________

Serial Number(s) ________________________________________________________________________________________

_______________________________________________________________________________________________________

_______________________________________________________________________________________________________

Replacement parts can be obtained from your distributor or JLA. When ordering replacement parts, you can FAX your order to JLA at 01422 824390 or telephone your order directly to the JLA Parts Department at 01422 822282. Please specify the dryer model number and serial number in addition to the description and part number, so that your order is processed accurately and promptly.

“IMPORTANT NOTE TO PURCHASER”

Information must be obtained from your local gas supplier on the instructions to be followed if the user smells gas. These instructions must be posted in a prominent location near the dryer.

2

JLA Limited

113429 - 9

IMPORTANT

You must disconnect and lockout the electric supply and the gas supply or the steam supply before any covers or guards are removed from the machine to allow access for cleaning, adjusting, installation, or testing of any equipment per OSHA standards.

Please observe all safety precautions displayed on the equipment and/or specified in the installation manual included with the dryer.

Before installation, check that the local distribution conditions, nature of gas and pressure, and adjustment of the appliances are compatible.

CAUTION

Dryer(s) should never be left unattended while in operation.

When discarding or storing your old clothes dryer, remove the door.

Lorsque vous entreposez ou mettez votre sécheuse au rebut, enlevez-enla porte.

“Caution: Label all wires prior to disconnection when servicing controls. Wiring errors can cause improper operation.”

«Attention: Au moment de l’entretien des commandes, étiquetez tous les fils avant de les débrancher. Des erreurs de câblage peuvent entraîner un fonctionnement inadéquat et dangereux.»

WARNING

Children should not be allowed to play on or near the dryer(s). Children should be supervised if near dryer(s) in operation.

Under no circumstances should the dryer door switch(es), lint door/drawer switch(es), or heat safety circuit(s) ever be disabled.

The dryer must never be operated with any of the back guards, outer tops, or service panels removed. Personal injury or fire could result.

The dryer must never be operated without the lint filter/screen in place, even if an external lint collection system is used.

FOR YOUR SAFETY

Do not dry mop heads in the dryer. Do not use dryer in the presence of dry cleaning fumes.

The dryers must not be installed or stored in an area where it will be exposed to water and/or weather.

The wiring diagram for the dryer is located behind the control panel.

Table of Contents ________

Safety Precautions ................................

4

T20 Specifications ................................

6

T30 Specifications ................................

8

T50 Specifications ..............................

10

T75 Specifications ..............................

12

Installation Procedures ......................

14

Location Requirements .........................................

14

Unpacking/Setting Up ...........................................

14

Dryer Enclosure Requirements .............................

14

Fresh Air Supply Requirements ............................

15

Exhaust Requirements .........................................

15

Electrical Information ............................................

17

Gas Information ....................................................

21

Converting from One Family of Gas to Another .....

24

Gas Pressure Testing ...........................................

26

Steam Information .................................................

26

Water Information .................................................

27

Preparation for Operation/Start-Up ........................

28

Preoperational Test ...............................................

28

Preoperational Instructions ...................................

29

Shutdown Instructions ..........................................

29

Service/Parts Information ..................

29

Service ..................................................................

29

Parts .....................................................................

29

Warranty Information .........................

29

Returning Warranty Cards.....................................

29

Warranty ...............................................................

30

Routine Maintenance ..........................

30

Data Label Information .......................

31

List of Acronyms _______________________

HVAC

Heating, Ventilating, and Air-Conditioning

in WC

Inches of Water Column

L.C.D.

Liquid Crystal Display

L.E.D.

Light Emitting Diode

L.P.

Liquid Propane

OSHA

Occupational Safety and Health Administration

UL

Underwriters Laboratory

113429 - 9

Telephone 01422 822282

3

Safety Precautions ____________________

Warning

!For your safety, the information in this manual must be followed to minimize the risk of fire or

explosion and to prevent property damage, personal injury, or loss of life.

The dryer must never be operated with any of the back guards, outer tops, or service panels removed. Personal injury or fire could result.

Failure to properly install, maintain, and/or operate dryer according to this manual and operator’s manuals included with dryer may result in conditions which can cause serious injury, death and/or property damage.

Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

Purchaser and user should consult the local gas supplier for proper instructions to be followed in the event the user smells gas. The instructions should be posted in a prominent location.

What To Do If You Smell Gas:

Do not try to light any appliance.

Do not touch any electrical switch.

Do not use any phone in your building.

Clear the room, building, or area of all occupants.

Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.

If you cannot reach your gas supplier, call the fire department.

Installation and service must be performed by a qualified installer, service agency, or gas supplier.

Dryers must be exhausted to the outdoors.

Although the manufacturer produces a very versatile dryer, there are some articles that, due to fabric composition or cleaning method, should not be dried in it.

Warning

!Dry only water washed fabrics. Do not dry articles spotted or washed in dry cleaning solvents,

combustible detergents, or “all purpose” cleaner. Explosion could result.

Do not dry rags or articles coated or contaminated with gasoline, kerosene, oil, paint, or wax. Explosion could result.

Items that have been spotted or soaked with vegetable or cooking oil constitute a fire hazard and should not be placed in a tumble dryer.

Do not dry mop heads. Contamination by wax or flammable solvents will create a fire hazard.

Do not use heat for drying articles that contain plastic, foam, sponge rubber, or similarly textured rubber materials. Drying in a heated tumbler may damage plastics or rubber and also may be a fire hazard.

A program should be established for the inspection and cleaning of lint in the burner area, exhaust ductwork, and area around the back of the dryer. The frequency of inspection and cleaning can best be determined from experience at each location.

Do not operate steam dryers with more than 150 psi (10.34 bar) steam pressure. Excessive steam pressure can damage the steam coil and/or harm personnel.

Replace leaking flexible hoses or other steam fixtures immediately. Do not operate the dryer with leaking flexible hoses. Personal injury may result.

Warning

!The collection of lint in the burner area and exhaust ductwork can create a potential fire

hazard.

For personal safety, the dryer must be electrically grounded in accordance with local and/or country codes. In the absence of these codes use the National Electrical Code ANSI/NFPA NO. 70-LATESTEDITION or in Canada, the Canadian Electrical Codes Parts 1 & 2 CSAC22.1-1990or LATEST EDITION.

Note

!Failure to electrically ground the dryer properly will void the warranty.

Warning

!Personal injury or fire could result should the dryer door switch, lint door/drawer, or heat safety circuit

ever be disabled.

Remove articles from the dryer as soon as the drying cycle has been completed.

Warning

!Articles left in the dryer after the drying and cooling cycles have been completed can create a fire

hazard.

For safety, proper operation, and optimum performance, the dryer must not be operated with a load less than 66% of its rated capacity.

Warning

!You must disconnect and lockout the electric supply and the gas supply or the steam supply

before any covers or guards are removed from the machine to allow access for cleaning, adjusting, installation, or testing of any equipment per OSHA standards.

Important

!The dryer must be installed in a location/ environment, which the ambient temperature

remains between 40° F (4.44° C) and 130° F (54.44° C).

The operation of this appliance may affect the operation of other types of gas appliances, which take their air for safe combustion from the same room. If in doubt, consult the appliance manufacturer(s).

Use this dryer only for its intended purpose, drying fabrics.

4

JLA Limited

113429 - 9

The “cool down” cycle of tumble dryers should be used to reduce the temperature of the items. They should not be removed from the tumble dryer or piled or stacked while hot.

Fabric softeners or similar products should not be used in a tumbler dryer to eliminate the effects of static electricity unless this practice is specifically recommended by the manufacturer of the fabric softener or product.

Warning

!To reduce the risk of personal injury, install lockable doors to prevent public access to the rear

of the dryers.

Exhaust duct outlet should be checked periodically for blockages, and if any found, removed.

Important

!A means of restraint must be used to prevent straining of the gas supply when the appliance is

moved.

An external means of power removal (disconnect device) must be provided by the installer.

CE ONLY

Important

!This appliance must only be installed and operated in the country of destination indicated on

the dryer’s data plate. If the appliance is to be installed and operated in a country other than the one indicated on the data plate, a data plate amendment must be obtained from JLA Limited.

Warning

!This appliance must only operate with the gas type indicated on the dryer’s data plate. If the appliance

is converted (gas type is changed), a data plate amendment must be obtained from JLA Limited.

This appliance may cause spillage of products of combustion from an open-flueappliance fitted in the same room, and that such an appliance shall be tested for clearance of products with the appliance in operation and all windows and doors closed.

NOTES ______________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

NOTES ______________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

_____________________________________________________________

113429 - 9

Telephone 01422 822282

5

T20 Specifications __________________________________________________________________

 

MAXIMUM CAPACITY (DRY WEIGHT)

 

20 lb

 

9.07 kg

 

TUMBLER DIAMETER

 

25-3/4”

 

65.41 cm

 

TUMBLER DEPTH

 

 

 

24”

 

60.96 cm

 

TUMBLER VOLUME

 

 

 

7-1/2cu ft

212.38 L

 

TUMBLER/DRIVE MOTOR

 

1/4 hp

 

0.19 kW

 

BLOWER/FAN MOTOR

 

1/3 hp

 

0.25 kW

 

DOOR OPENING (DIAMETER)

 

19-3/8”

 

49.21 cm

 

DOOR SILL HEIGHT

 

 

 

13”

 

33.02 cm

 

WATER CONNECTION

 

3/4”-11.5 NH (North America)

 

 

 

 

 

 

 

3/4” B.S.P.T. (Outside North America)

 

DRYERS PER 20’/40’ CONTAINER

 

 

42 / 84

 

 

DRYERS PER 48’/53’ TRUCK

 

 

96 / 108

 

 

 

VOLTAGE AVAILABLE

 

120-240V

2w

50/60 Hz

 

 

APPROXIMATE NET WEIGHT

 

245 lb

 

111.13 kg

 

 

APPROXIMATE SHIPPING WEIGHT

265 lb

 

120.20 kg

 

Gas

AIRFLOW

 

 

60 Hz

230 cfm

 

6.51 cmm

 

 

 

 

 

50 Hz

191 cfm

 

5.40 cmm

 

 

 

 

 

 

 

 

 

HEAT INPUT

 

 

 

40,000 Btu/hr

10,080 kcal/hr

 

 

EXHAUST CONNECTION (DIAMETER)

4”

 

10.16 cm

 

 

COMPRESSED AIR CONNECTION

 

N / A

 

 

 

COMPRESSED AIR VOLUME

 

 

N / A

 

 

 

INLET PIPE CONNECTION

 

 

3/8” M.N.P.T.

 

 

 

 

 

 

 

 

3/8” M.B.S.P.T. (CE and Australia Only)

 

 

VOLTAGE AVAILABLE

 

200-416V

1,3ø

2,3,4w

50/60 Hz

 

 

APPROXIMATE NET WEIGHT

 

245 lb

 

111.13 kg

 

 

APPROXIMATE SHIPPING WEIGHT

265 lb

 

120.20 kg

 

 

AIRFLOW

 

 

60 Hz

230 cfm

 

6.51 cmm

 

 

 

 

 

 

50 Hz

191 cfm

 

5.40 cmm

 

Electric

EXHAUST CONNECTION (DIAMETER)

4”

 

10.16 cm

 

5.6

 

19,112

 

4,816

 

N / A

 

 

 

COMPRESSED AIR CONNECTION

 

 

 

 

COMPRESSED AIR VOLUME

 

 

N / A

 

 

 

 

 

OVEN SIZE

 

 

 

 

 

 

 

kW

 

Btu/hr

 

kcal/hr

 

 

 

 

 

 

4.1

 

13,843

 

3,488

 

 

 

 

 

 

5.0

 

17,065

 

4,300

 

 

 

 

 

 

5.4

 

18,430

 

4,644

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

6.1

 

20,819

 

5,246

 

 

 

 

 

 

6.5

 

22,184

 

5,590

 

 

 

 

 

 

6.8

 

23,208

 

5,848

 

 

 

 

 

 

7.4

 

25,255

 

6,364

 

 

 

 

 

 

7.5

 

25,597

 

6,450

 

 

 

 

 

 

8.1

 

27,644

 

6,966

 

 

 

 

 

 

VOLTAGE AVAILABLE

 

120-240V

2w

50/60 Hz

 

 

APPROXIMATE NET WEIGHT

 

253 lb

 

114.76 kg

 

Steam

APPROXIMATE SHIPPING WEIGHT

273 lb

 

123.83 kg

 

AIRFLOW

 

 

60 Hz

230 cfm

 

6.51 cmm

 

 

 

 

 

50 Hz

191 cfm

 

5.40 cmm

 

 

 

 

 

 

 

 

 

STEAM CONSUMPTION

 

45 lb/hr

 

20.41 kg/hr

 

 

OPERATING STEAM PRESSURE

150 psi max

10.34 bar

 

 

EXHAUST CONNECTION (DIAMETER)

4”

 

10.16 cm

 

 

COMPRESSED AIR CONNECTION

 

N / A

 

 

 

COMPRESSED AIR VOLUME

 

 

N / A

 

 

 

BOILER HORSEPOWER (NORMAL LOAD)

1.2 Bhp

 

 

 

 

 

SUPPLY CONNECTION

 

1/2” F.N.P.T.

 

 

 

 

RETURN CONNECTION

 

1/2” F.N.P.T.

 

 

 

Shaded areas are stated in metric equivalents

 

 

 

5/1/06

Note

!The manufacturer reserves the right to make changes in specifications at any time without notice or obligation.

6

JLA Limited

113429 - 9

T20 Specifications __________________________________________________________________

113429 - 9

Telephone 01422 822282

7

T30 Specifications __________________________________________________________________

 

MAXIMUM CAPACITY (DRY WEIGHT)

 

30 lb

 

13.61 kg

 

TUMBLER DIAMETER

 

30”

 

76.20 cm

 

TUMBLER DEPTH

 

 

 

27”

 

68.58 cm

 

TUMBLER VOLUME

 

 

 

11.04 cu ft

312.62 L

 

TUMBLER/DRIVE MOTOR

 

1/4 hp

 

0.19 kW

 

BLOWER/FAN MOTOR

 

1/2 hp

 

0.37 kW

 

DOOR OPENING (DIAMETER)

 

19-3/8”

 

49.21 cm

 

DOOR SILL HEIGHT

 

 

 

14-7/8”

 

37.78 cm

 

WATER CONNECTION

 

3/4”-11.5 NH (North America)

 

 

 

 

 

 

 

3/4” B.S.P.T. (Outside North America)

 

DRYERS PER 20’/40’ CONTAINER

 

 

12 / 28

 

 

DRYERS PER 48’/53’ TRUCK

 

 

34 / 38

 

 

 

VOLTAGE AVAILABLE

 

120-240V

2w

50/60 Hz

 

 

APPROXIMATE NET WEIGHT

 

285 lb

 

129.27 kg

 

 

APPROXIMATE SHIPPING WEIGHT

310 lb

 

140.61 kg

 

Gas

AIRFLOW

 

 

60 Hz

360 cfm

 

10.19 cmm

 

 

 

 

 

50 Hz

300 cfm

 

8.49 cmm

 

 

 

 

 

 

 

 

 

HEAT INPUT

 

 

 

55,000 Btu/hr

13,860 kcal/hr

 

 

EXHAUST CONNECTION (DIAMETER)

6”

 

15.24 cm

 

 

COMPRESSED AIR CONNECTION

 

N / A

 

 

 

COMPRESSED AIR VOLUME

 

 

N / A

 

 

 

INLET PIPE CONNECTION

 

 

1/2” M.N.P.T.

 

 

 

 

 

 

 

 

3/8” M.B.S.P.T. (CE and Australia Only)

 

 

VOLTAGE AVAILABLE

 

200-416V

1,3ø

2,3,4w

50/60 Hz

 

 

APPROXIMATE NET WEIGHT

 

285 lb

 

129.27 kg

 

 

APPROXIMATE SHIPPING WEIGHT

310 lb

 

140.61 kg

 

 

AIRFLOW

 

 

60 Hz

360 cfm

 

10.19 cmm

 

Electric

 

 

 

 

50 Hz

300 cfm

 

8.49 cmm

 

EXHAUST CONNECTION (DIAMETER)

6”

 

15.24 cm

 

 

 

 

 

COMPRESSED AIR CONNECTION

 

N / A

 

 

 

COMPRESSED AIR VOLUME

 

 

N / A

 

 

 

 

 

OVEN SIZE

 

 

 

 

 

 

 

kW

 

Btu/hr

 

kcal/hr

 

 

 

 

 

 

7.9

 

26,962

 

6,794

 

 

 

 

 

 

8.3

 

28,327

 

7,138

 

 

 

 

 

 

9.0

 

30,716

 

7,740

 

 

 

 

 

 

11.3

 

38,566

 

9,719

 

 

 

 

 

 

12.4

 

42,320

 

10,665

 

 

 

 

 

 

12.5

 

42,661

 

10,751

 

 

 

 

 

 

13.5

 

46,074

 

11,611

 

 

 

 

 

 

VOLTAGE AVAILABLE

 

120-240V

2w

50/60 Hz

 

 

APPROXIMATE NET WEIGHT

 

305 lb

 

138.35 kg

 

Steam

APPROXIMATE SHIPPING WEIGHT

330 lb

 

149.69 kg

 

AIRFLOW

 

 

60 Hz

360 cfm

 

10.19 cmm

 

 

 

 

 

50 Hz

300 cfm

 

8.49 cmm

 

STEAM CONSUMPTION

 

63 lb/hr

 

28.58 kg/hr

 

OPERATING STEAM PRESSURE

150 psi max

10.34 bar

 

EXHAUST CONNECTION (DIAMETER)

6”

 

15.24 cm

 

COMPRESSED AIR CONNECTION

 

N / A

 

 

COMPRESSED AIR VOLUME

 

 

N / A

 

 

 

BOILER HORSEPOWER (NORMAL LOAD)

 

1.75 Bhp

 

 

 

SUPPLY CONNECTION

 

 

1/2” F.N.P.T.

 

 

 

RETURN CONNECTION

 

 

1/2” M.N.P.T.

 

 

Shaded areas are stated in metric equivalents

 

 

 

9/30/05

Note

!The manufacturer reserves the right to make changes in specifications at any time without notice or obligation.

8

JLA Limited

113429 - 9

T30 Specifications __________________________________________________________________

113429 - 9

Telephone 01422 822282

9

T50 Specifications __________________________________________________________________

 

MAXIMUM CAPACITY (DRY WEIGHT)

 

50 lb

 

22.68 kg

 

TUMBLER DIAMETER

 

37”

 

93.98 cm

 

TUMBLER DEPTH

 

 

 

25-3/4”

 

65.41 cm

 

TUMBLER VOLUME

 

 

 

16.02 cu ft

453.64 L

 

TUMBLER/DRIVE MOTOR

 

3/4 hp

 

0.56 kW

 

BLOWER/FAN MOTOR

 

1/2 hp

 

0.37 kW

 

DOOR OPENING (DIAMETER)

 

27-3/8”

 

69.53 cm

 

DOOR SILL HEIGHT

 

 

 

16”

 

40.64 cm

 

WATER CONNECTION

 

3/4”-11.5 NH (North America)

 

 

 

 

 

 

 

3/4” B.S.P.T. (Outside North America)

 

DRYERS PER 20’/40’ CONTAINER

 

 

10 / 22

 

 

DRYERS PER 48’/53’ TRUCK

 

 

28 / 30

 

 

 

VOLTAGE AVAILABLE

 

120-240V

2w

50/60 Hz

 

 

APPROXIMATE NET WEIGHT

 

545 lb

 

247.21 kg

 

 

APPROXIMATE SHIPPING WEIGHT

565 lb

 

256.28 kg

 

Gas

AIRFLOW

 

 

60 Hz

525 cfm

 

14.87 cmm

 

 

 

 

 

50 Hz

437 cfm

 

12.37 cmm

 

 

 

 

 

 

 

 

 

HEAT INPUT

 

 

 

90,000 Btu/hr

22,680 kcal/hr

 

 

EXHAUST CONNECTION (DIAMETER)

8”

 

20.32 cm

 

 

COMPRESSED AIR CONNECTION

 

N / A

 

 

 

COMPRESSED AIR VOLUME

 

 

N / A

 

 

 

INLET PIPE CONNECTION

 

 

1/2” M.N.P.T.

 

 

 

 

 

 

 

 

1/2” F.B.S.P.T. (CE and Australia Only)

 

 

VOLTAGE AVAILABLE

 

120-600V

1,3ø

2,3,4w

50/60 Hz

 

 

APPROXIMATE NET WEIGHT

 

545 lb

 

247.21 kg

 

Electric

APPROXIMATE SHIPPING WEIGHT

565 lb

 

256.28 kg

 

13.4

 

45,869

 

11,559

525 cfm

 

14.87 cmm

 

 

AIRFLOW

 

 

60 Hz

 

 

 

 

 

 

 

50 Hz

437 cfm

 

12.37 cmm

 

 

EXHAUST CONNECTION (DIAMETER)

8”

 

20.32 cm

 

 

COMPRESSED AIR CONNECTION

 

N / A

 

 

 

COMPRESSED AIR VOLUME

 

 

N / A

 

 

 

 

 

OVEN SIZE

 

 

 

 

 

 

 

kW

 

Btu/hr

 

kcal/hr

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

14.7

 

50,136

 

12,634

 

 

 

 

 

 

14.8

 

50,545

 

12,737

 

 

 

 

 

 

16.0

 

54,606

 

13,761

 

 

 

 

 

 

VOLTAGE AVAILABLE

 

120-240V

2w

50/60 Hz

 

 

APPROXIMATE NET WEIGHT

 

545 lb

 

247.21 kg

 

Steam

APPROXIMATE SHIPPING WEIGHT

565 lb

 

256.28 kg

 

AIRFLOW

 

 

60 Hz

525 cfm

 

14.87 cmm

 

 

 

 

 

50 Hz

437 cfm

 

12.37 cmm

 

 

 

 

 

 

 

 

 

STEAM CONSUMPTION

 

127.5 lb/hr

57.83 kg/hr

 

 

OPERATING STEAM PRESSURE

150 psi max

10.34 bar

 

 

EXHAUST CONNECTION (DIAMETER)

8”

 

20.32 cm

 

 

COMPRESSED AIR CONNECTION

 

N / A

 

 

 

COMPRESSED AIR VOLUME

 

 

N / A

 

 

 

BOILER HORSEPOWER (NORMAL LOAD)

 

3.75 Bhp

 

 

 

SUPPLY CONNECTION

 

 

3/4” F.N.P.T.

 

 

 

RETURN CONNECTION

 

 

3/4” M.N.P.T.

 

 

Shaded areas are stated in metric equivalents

 

 

 

4/30/07

Note

!The manufacturer reserves the right to make changes in specifications at any time without notice or obligation.

10

JLA Limited

113429 - 9