Allied Telesis Converteon AT-CV5000- User Manual

Size:
5.66 Mb
Download

CONVERTEON™ Family

Media Converter Chassis

AT-CV5000

Installation Guide

613-000586Rev. B

Copyright © 2007 Allied Telesis, Inc.

All rights reserved. No part of this publication may be reproduced without prior written permission from Allied Telesis, Inc.

Allied Telesis is a trademark of Allied Telesis, Inc. Microsoft and Internet Explorer are registered trademarks of Microsoft Corporation. Netscape Navigator is a registered trademark of Netscape Communications Corporation. All other product names, company names, logos or other designations mentioned herein are trademarks or registered trademarks of their respective owners.

Allied Telesis, Inc. reserves the right to make changes in specifications and other information contained in this document without prior written notice. The information provided herein is subject to change without notice. In no event shall Allied Telesis, Inc. be liable for any incidental, special, indirect, or consequential damages whatsoever, including but not limited to lost profits, arising out of or related to this manual or the information contained herein, even if Allied Telesis, Inc. has been advised of, known, or should have known, the possibility of such damages.

Electrical Safety and Emissions Standards

This product meets the following standards.

U.S. Federal Communications Commission

Radiated Energy

Note: This equipment has been tested and found to comply with the limits for a Class A digital device pursuant to Part 15 of FCC Rules. These limits are designed to provide reasonable protection against harmful interference when the equipment is operated in a commercial environment. This equipment generates, uses, and can radiate radio frequency energy and, if not installed and used in accordance with this instruction manual, may cause harmful interference to radio communications. Operation of this equipment in a residential area is likely to cause harmful interference in which case the user will be required to correct the interference at his own expense.

Note: Modifications or changes not expressly approved of by the manufacturer or the FCC, can void your right to operate this equipment.

Industry Canada

This Class B digital apparatus complies with Canadian ICES-003.

Cet appareil numérique de la classe A est conforme à la norme NMB-003du Canada.

RFI Emissions

FCC Class A, EN55022 Class A, EN61000-3-2,EN61000-3-3,VCCI

 

Class A, C-TICK,CE

Warning: In a domestic environment this product may cause radio interference in which case the user may be required to take adequate measures.

Immunity

EN55024

Electrical Safety

EN60950 (TUV), UL 60950 (CULUS)

Laser Safety

EN60825

3

Translated Safety Statements

Important: The indicates that a translation of the safety statement is available in a PDF document titled “Translated Safety Statements”(613-000405)posted on the Allied Telesis website at www.alliedtelesis.com.

4

Contents

Preface ...............................................................................................................................................................................

13

Safety Symbols Used in this Document...............................................................................................................................

14

Where to Find Web-based Guides ......................................................................................................................................

15

Contacting Allied Telesis .....................................................................................................................................................

16

Online Support .............................................................................................................................................................

16

Email and Telephone Support......................................................................................................................................

16

Warranty.......................................................................................................................................................................

16

Returning Products.......................................................................................................................................................

16

Sales or Corporate Information ....................................................................................................................................

16

Management Software Updates...................................................................................................................................

16

Chapter 1: Overview .........................................................................................................................................................

17

AT-CV5000 Overview..........................................................................................................................................................

18

Managed AT-CV5000...................................................................................................................................................

18

Unmanaged AT-CV5000 ..............................................................................................................................................

18

System Description..............................................................................................................................................................

19

Hardware Features.......................................................................................................................................................

19

Software Features ........................................................................................................................................................

19

Front and Rear Panel Components.....................................................................................................................................

20

LED Interface Card..............................................................................................................................................................

21

RS-232 Terminal Port...................................................................................................................................................

21

Interface Card LEDs.....................................................................................................................................................

22

RESET LINE/EXP Button.............................................................................................................................................

23

AT-CV5M01 Management Card ..........................................................................................................................................

24

RS-232 Terminal Port...................................................................................................................................................

24

10/100Base-TX Twisted Pair Port ................................................................................................................................

25

CPU RESET Button .....................................................................................................................................................

26

LEDs.............................................................................................................................................................................

26

Converteon™ Line Cards ....................................................................................................................................................

28

Link Test.......................................................................................................................................................................

28

MissingLink™ ...............................................................................................................................................................

28

Smart MissingLink ........................................................................................................................................................

29

OAM .............................................................................................................................................................................

29

Line Card Port Descriptions .........................................................................................................................................

29

Blank Slot Covers ................................................................................................................................................................

30

Power Supplies....................................................................................................................................................................

31

Fan Modules........................................................................................................................................................................

32

Management Connections...................................................................................................................................................

33

A Few Basics about Media Converters................................................................................................................................

34

MAC Address Table .....................................................................................................................................................

34

Duplex Mode ................................................................................................................................................................

34

Store-and-Forward .......................................................................................................................................................

35

Pass-through ................................................................................................................................................................

35

Network Topologies.............................................................................................................................................................

36

Standalone Topology ...................................................................................................................................................

36

Back-to-Back Topology ................................................................................................................................................

36

Chapter 2: Installation ......................................................................................................................................................

39

Reviewing Safety Precautions.............................................................................................................................................

40

Selecting a Site for the Chassis...........................................................................................................................................

44

5

Contents

 

Unpacking the Chassis ........................................................................................................................................................

45

Installing the Power Cord Retaining Clip (AC Powered Chassis Only)................................................................................

46

Installing the AT-CV5000 Chassis in a Rack .......................................................................................................................

48

Grounding the AT-CV5000 Chassis.....................................................................................................................................

50

Installing a Converteon™ Line Card....................................................................................................................................

52

Cabling a Converteon™ Line Card in an AT-CV5000 Chassis............................................................................................

55

Cabling a Fiber Optic Port ............................................................................................................................................

55

Cabling a Twisted Pair Port ..........................................................................................................................................

58

Cabling an SFP Transceiver.........................................................................................................................................

58

Powering On an AC Powered Chassis ................................................................................................................................

60

Powering On a DC Powered Chassis..................................................................................................................................

64

Starting a Local Management Session ................................................................................................................................

67

Starting a Remote Management Session ............................................................................................................................

70

Chapter 3: Working with Line Cards and other Modules ..............................................................................................

73

Removing a Converteon™ Line Card..................................................................................................................................

74

Working with the AT-CV5M01 Management Card...............................................................................................................

76

Installing an AT-CV5M01 Management Card...............................................................................................................

76

Resetting an AT-CV5M01 Management Card..............................................................................................................

77

Replacing an AT-CV5M01 Management Card .............................................................................................................

78

Installing an AT-CM70S Line Card ......................................................................................................................................

79

Resetting the Line Cards and the Module in the Rear Expansion Slot................................................................................

81

Installing an AT-PWR14 AC Power Supply .........................................................................................................................

82

Installing an AT-PWR15 DC Power Supply .........................................................................................................................

84

Replacing an AT-CVFAN Module ........................................................................................................................................

86

Installing a Blank Slot Cover................................................................................................................................................

90

Installing an AT-CV5PNL1 Blank Slot Cover................................................................................................................

90

Installing an AT-CV5PNL2 Blank Slot Cover................................................................................................................

92

Installing an AT-CV5PNL3 Blank Slot Cover................................................................................................................

93

Chapter 4: Troubleshooting .............................................................................................................................................

95

LED Interface Card ..............................................................................................................................................................

95

PS-A or PS-B LED is OFF............................................................................................................................................

95

PS-A or PS-B LED is Blinking.......................................................................................................................................

95

FAN-A or FAN-B LED is OFF .......................................................................................................................................

95

AT-CV5M01 Management Card ..........................................................................................................................................

97

PWR LED is OFF..........................................................................................................................................................

97

RDY LED is Blinking.....................................................................................................................................................

97

RDY LED is OFF ..........................................................................................................................................................

97

FLT LED is Blinking ......................................................................................................................................................

97

FLT LED is Steadily ON................................................................................................................................................

98

LK LED is OFF .............................................................................................................................................................

98

Converteon™ Line Cards ....................................................................................................................................................

98

LK LED is Blinking ........................................................................................................................................................

98

LK LED is OFF .............................................................................................................................................................

98

Appendix A: Technical Specifications ..........................................................................................................................

101

Physical Specifications ......................................................................................................................................................

101

Environmental Specifications.............................................................................................................................................

101

Power Specifications..........................................................................................................................................................

101

Safety and Electromagnetic Emissions Certifications........................................................................................................

102

Standards ..........................................................................................................................................................................

102

RJ-45 Twisted Pair Port Pinouts........................................................................................................................................

103

RS-232 Terminal Port Pinouts ...........................................................................................................................................

104

8-Pin Mini-DIN Console Port Pinouts.................................................................................................................................

105

SC Type Connectors..........................................................................................................................................................

106

Dual SC Connector.....................................................................................................................................................

106

Simplex SC Connector ...............................................................................................................................................

106

Dual ST Type Connector Cable.........................................................................................................................................

107

SFP Transceiver Cable......................................................................................................................................................

108

Appendix B: Cleaning Fiber Optic Connectors ............................................................................................................

109

6

 

AT - CV5000 Media Converter Chassis Installation Guide

Using a Cartridge-Type Cleaner

........................................................................................................................................ 110

Using a Swab ....................................................................................................................................................................

112

7

Contents

8

Figures

Figure 1. AT-CV5000 Media Converter .............................................................................................................................

18

Figure 2.

Front Panel of the AT-CV5000 Chassis .............................................................................................................

20

Figure 3. Rear Panel of the AT-CV5000 Chassis (AC Version) ........................................................................................

20

Figure 4. Rear Panel of the AT-CV5000 Chassis (DC Version) ........................................................................................

20

Figure 5. LED Interface Card Components .......................................................................................................................

21

Figure 6. AT-CV5M01 Management Card Components....................................................................................................

24

Figure 7. AT-CV5PNLx Series Blank Slot Covers .............................................................................................................

30

Figure 8. AT-CV5000 AC Powered Chassis......................................................................................................................

31

Figure 9. AT-CV5000 DC Powered Chassis......................................................................................................................

31

Figure 10. AT-CVFAN Module...........................................................................................................................................

32

Figure 11. Locations of Fan Slots A and B on an AT-CV5000 Rear Panel .......................................................................

32

Figure 12. Standalone Network Topology .........................................................................................................................

36

Figure 13. Back-to-Back Network Topology ......................................................................................................................

37

Figure 14.

Power Cord Retaining Clip ...............................................................................................................................

46

Figure 15.

Power Cord Retaining Bracket .........................................................................................................................

46

Figure 16.

Inserting the Retaining Clip into the Retaining Bracket ....................................................................................

46

Figure 17.

Retaining Clip Properly Installed in the Bracket ...............................................................................................

47

Figure 18.

Installing a Bracket to the Chassis ...................................................................................................................

48

Figure 19. Mounting the AT-CV5000 Chassis in a 19-inch Rack ......................................................................................

48

Figure 20. Frame Ground Connectors...............................................................................................................................

50

Figure 21.

Connecting the Wire to the Ground Lug...........................................................................................................

50

Figure 22. Placing the Ground Lug on the Frame Ground Stud........................................................................................

51

Figure 23. Securing the Ground Lug with Lock Nut...........................................................................................................

51

Figure 24.

Location of the Alignment Guides.....................................................................................................................

53

Figure 25.

Inserting a Line Card ........................................................................................................................................

53

Figure 26.

Tightening the Captive Screw...........................................................................................................................

54

Figure 27. Dual SC Port ....................................................................................................................................................

55

Figure 28. Removing the Dust Cover from a Dual SC Fiber Optic Port.............................................................................

56

Figure 29.

Connecting to the Dual SC Fiber Optic Port.....................................................................................................

56

Figure 30. Removing the Dust Cover from a Simplex SC Fiber Optic Port .......................................................................

57

Figure 31.

Connecting to the Simplex SC Fiber Optic Port ...............................................................................................

57

Figure 32.

Connecting to the Twisted Pair Port.................................................................................................................

58

Figure 33.

Inserting an SFP Transceiver into the SFP Slot...............................................................................................

59

Figure 34. Removing the Dust Cover from the SFP Transceiver ......................................................................................

59

Figure 35.

Connecting Fiber Optic Cables to the SFP Transceiver...................................................................................

59

Figure 36. ON/OFF Power Switch in OFF Position ...........................................................................................................

60

Figure 37.

Power Cord Retaining Clip in the Up Position..................................................................................................

61

Figure 38. Connecting the AC Power Cord .......................................................................................................................

61

Figure 39.

Securing the Power Cord with the Retaining Clip.............................................................................................

61

Figure 40. ON/OFF Power Switch in ON Position .............................................................................................................

62

Figure 41. DC Terminal Block............................................................................................................................................

64

Figure 42.

Stripped Wire....................................................................................................................................................

65

Figure 43.

Inserting Wires into a DC Terminal Block.........................................................................................................

66

Figure 44. Connecting a Management Cable to the RS-232 Terminal Port on an AT-CV5M01 Management Card.........

67

Figure 45. Connecting a Management Cable to the RS-232 Console Port on an AT-CM70S Line Card..........................

67

Figure 46. AT-S70 Main Menu...........................................................................................................................................

68

Figure 47. Connecting a Twisted Pair Cable to the 10/100Base-TX Port on the AT-CV5M01 Management Card ...........

70

Figure 48. Line Card Removal Tool...................................................................................................................................

74

Figure 49. Removing a Line Card from an AT-CV5000 Chassis.......................................................................................

74

Figure 50. Inserting the AT-CV5M01 Management Card ..................................................................................................

77

9

Figures

 

 

Figure 51.

Tightening the Captive Screw...........................................................................................................................

77

Figure 52. Resetting the AT-CV5M01 Management Card.................................................................................................

78

Figure 53. Inserting an AT-CM70S Line Card....................................................................................................................

80

Figure 54. Tightening the Captive Screw on the AT-CM70S Line Card ............................................................................

80

Figure 55. Resetting Converteon™ Line Cards/Rear Expansion Module..........................................................................

81

Figure 56. Inserting the AT-PWR14 AC Power Supply......................................................................................................

83

Figure 57. Securing the AT-PWR14 AC Power Supply .....................................................................................................

83

Figure 58. Inserting the AT-PWR15 DC Power Supply .....................................................................................................

85

Figure 59. Securing the AT-PWR15 DC Power Supply.....................................................................................................

85

Figure 60. Removing an AT-CVFAN Module from Fan Slot A...........................................................................................

87

Figure 61. Removing an AT-CVFAN Module from Fan Slot B...........................................................................................

87

Figure 62. Inserting an AT-CVFAN Module into Fan Slot A...............................................................................................

88

Figure 63. Inserting an AT-CVFAN Module into Fan Slot B...............................................................................................

88

Figure 64. Tightening the Screws on the AT-CVFAN Module in Slot A.............................................................................

88

Figure 65. Tightening the Screws on the AT-CVFAN Module in Slot B.............................................................................

89

Figure 66. Inserting an AT-CV5PNL1 Blank Slot Cover ....................................................................................................

91

Figure 67. Tightening the Captive Screw on an AT-CV5PNL1..........................................................................................

91

Figure 68. Inserting an AT-CV5PNL2 Blank Slot Cover ....................................................................................................

92

Figure 69. Tightening the Captive Screws on an AT-CV5PNL2 ........................................................................................

92

Figure 70. Inserting an AT-CV5PNL3 Blank Slot Cover ....................................................................................................

93

Figure 71. Tightening the Captive Screws on an AT-CV5PNL3 ........................................................................................

94

Figure 72. RJ-45 Connector and Port Pin Layout............................................................................................................

103

Figure 73.

RS-232 Terminal Port Pinouts........................................................................................................................

104

Figure 74.

8-Pin Mini-DIN Console Port and Connector Pin Layouts ..............................................................................

105

Figure 75. Dual SC Connector Cable ..............................................................................................................................

106

Figure 76. Simplex SC Connector Cable.........................................................................................................................

106

Figure 77. Dual ST Connector Cable...............................................................................................................................

107

Figure 78. SFP Transceiver.............................................................................................................................................

108

Figure 79. SFP Transceiver Cable...................................................................................................................................

108

Figure 80. Ferrule in an SC Connector Plug....................................................................................................................

109

Figure 81.

Unclean and Clean Ferrule.............................................................................................................................

109

Figure 82.

Cartridge Cleaner ...........................................................................................................................................

110

Figure 83.

Rubbing the Ferrule Tip on the Cleaning Surface ..........................................................................................

110

Figure 84.

Lint-Free and Alcohol-Free Swabs .................................................................................................................

112

Figure 85. Cleaning a Recessed Ferrule .........................................................................................................................

112

10