Alliance Laundry Systems D0582 User Manual

Size:
440.9 Kb
Download

Drying Tumblers

110 Pound Capacity

Installation

Keep These Instructions for Future Reference.

(If this machine changes ownership, this manual must accompany machine.)

Part No. D0582

September 2007

Addendum A

Information in this manual is applicable to these models:

HD110

D0582

i

IMPORTANT NOTES - PLEASE READ

For optimum efficiency and safety, we recommend that you read the manual before operating the equipment. Store this manual in a file or binder and keep for future reference.

WARNING: Purchaser must post the following notice in a prominent location:

WARNING: For your safety, the information in this manual must be followed to minimize the risk of fire or explosion or to prevent property damage, personal injury, or death.

-Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance.

-WHAT TO DO IF YOU SMELL GAS

Do not try to light any appliances.

Do not touch any electrical switch; do not use any phone in your building.

Clear the room, building, or area of all occupants.

Immediately call your gas supplier from a neighbor's phone. Follow the gas supplier's instructions.

If you cannot reach your gas supplier, call the fire department.

Installation and service must be performed by a qualified installer, service agency or the gas supplier.

WARNING: In the event the user smells gas odor, instructions on what to do must be posted in a prominent location. This information can be obtained from the local gas supplier.

WARNING: Wear safety shoes to prevent injuries.

WARNING: Purchaser must post the following notice in a prominent location:

FOR YOUR SAFETY

Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

WARNING: A clothes dryer produces combustible lint and should be exhausted outside the building. The dryer and the area around the dryer should be kept free of lint.

WARNING: Be safe, before servicing machine, the main power should be shut off.

Page 1

IMPORTANT NOTES - PLEASE READ

WARNING: To avoid fire hazard, do not dry articles containing foam rubber or similar texture materials. Do not put into this dryer flammable items such as baby bed mattresses, throw rugs, undergarments (brassieres, etc.) and other items which use rubber as padding or backing. Rubber easily oxidizes causing excessive heat and possible fire. These items should be air dried.

WARNING: Synthetic solvent fumes from drycleaning machines create acids when drawn through the dryer. These fumes cause rusting of painted parts, pitting of bright or plated parts, and completely removes the zinc from galvanized parts, such as the tumbler basket. If drycleaning machines are in the same area as the tumbler, the tumbler'smake-upair must come from a source free of solvent fumes.

WARNING: Do not operate without guards in place.

WARNING: Check the lint trap often and clean as needed but at least a minimum of once per day.

WARNING: Alterations to equipment may not be carried out without consulting with the factory and only by a qualified engineer or technician. OnlyManufacturer’s parts may be used.

WARNING: Remove clothes from dryer as soon as it stops. This keeps wrinkles from setting in and reduces the possibility of spontaneous combustion.

WARNING: Be safe - shut main electrical power and gas supply off externally before attempting service.

WARNING: Never use drycleaning solvents, gasoline, kerosene, or other flammable liquids in the dryer.

FIRE AND EXPLOSION WILL OCCUR. NEVER PUT FABRICS TREATED WITH THESE LIQUIDS INTO THE DRYER. NEVER USE THESE LIQUIDS NEAR THE DRYER.

WARNING: Do not place items exposed to cooking oils in your dryer. Items contaminated with cooking oils may contribute to a chemical reaction that could cause a load to catch fire.

WARNING: Never let children play near or operate the dryer. Serious injury could occur if a child should crawl inside and the dryer is turned on.

WARNING: Never tumble fiberglass materials in the dryer unless the labels say they are machine dryable. Glass fibers break and can remain in the dryer. These fibers cause skin irritation if they become mixed with other fabrics.

WARNING: Before operating gas ignition system - purge air from natural gas or propane gas lines per manufacturer’s instructions.

WARNING: To reduce the risk of electric shock, disconnect this appliance from the power supply before attempting any user maintenance other than cleaning the lint trap. Turning the controls to the OFF position does not disconnect this appliance from the power supply.

Page 2

IMPORTANT NOTES - PLEASE READ

ATTENTION: L’ACHETEUR DOIT PLACER L’AVERTISSEMENT SUIVANT DANS UN ENDROIT CLAIR ET VISIBLE:

AVERTISSEMENT. Assurez-vousde bien suivre les instructions donnees dans cette notice pour reduire au minimum le risque d’incendie ou d’explosion ou pour eviter tuot dommage materiel, toute blessure ou la mort.

__ Ne pas entreposer ni utiliser d’essence ni d’autres vapeurs ou liquides inflammables dans le voisinage de cet appareil ou de tout autre apparell.

__ QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:

Ne pas tenter d’allumer d’apparell.

Ne touchez a aucun interrupteur. Ne pas vous servir des telephones se trouvant dans le batiment ou vous vous trouvez.

Evacuez la piece, le batiment ou la zone.

Appelez immediatement votre fournisseur de gaz depuis un voisin. Suivez les instructions du fournisseur.

Si vous ne pouvez rejoindre le fournisseur de gaz, appelez le service des incendies.

__ l’installation et l’entretien doivent etre assures par un installateur ou un service d’entretien qualifie ou par le fournisseur de gaz.

ATTENTION: L’ACHETEUR DOIT PLACER L’AVERTISSEMENT SUIVANT DANS UN ENDROIT CLAIR ET VISIBLE:

POUR VOTRE SECURITE

Ne pas entreposer ni utiliser d’ essence ni d’autres vapeurs ou liquides inflammables dans le voisinage de cet appareil ou de tout autre appareil.

Page 3

 

TABLE OF CONTENTS

 

PAGE

ImportantNotices ..............................................................................................................

1-3

TableofContents .................................................................................................................

4

CustomerService .................................................................................................................

5

Warnings, Symbols ...........................................................................................................

6-7

Unpacking/GeneralInstallation ..............................................................................................

8

GeneralDimensions .........................................................................................................

9-11

DryerSpecifications .......................................................................................................

12-13

ElectricalConnections .........................................................................................................

14

GasPiping .....................................................................................................................

15-16

Gas Pipe Size Chart ............................................................................................................

17

GasPipingInstallation .........................................................................................................

18

SteamPipingInstallation ................................................................................................

19-20

ExhaustInstallation-MultipleExhaust ............................................................................

21-23

DryerMake-upAirRequirements .......................................................................................

24

ExhaustInstallation-SeparateExhaust ................................................................................

25

DryerAirFlowInstallation ..................................................................................................

26

(C)CopyrightAllianceLaundrySystemsLLC

All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means withouttheexpressedwrittenconsentofthepublisher.

Page 4

CUSTOMERSERVICE

Ifliteratureorreplacementpartsarerequired,contactthesourcefromwhich

 

the machine was purchased or contact Alliance Laundry Systems at (920) 748-

 

3950 for the name and address of the nearest authorized parts distributor.

 

For technical assistance, call (920) 748-3121.

 

 

Page 5

SYMBOLS

Thefollowingsymbolsareusedinthismanualand/oronthemachine.

Symbol

Description

NOTE!

Hot! Do Not Touch

Heiß! NichtBeruhren Haute temperature! Ne pas toucher

Caliente! no tocar

dangerousvoltage tensiondangereuse Gefährliche elektrische Spannung

tension peligrosa

on marche Ein conectado

off arrêt Aus

desconectado

start demarrage Start

arranquedeunmovimiento

emission of heat in general êmission de chaleur en general

Warmeabgabeallgemein emisión de calor

cooling refroidissement Kühlen enfriamiento

Page 6

SYMBOLS

Symbol Description

rotationintwodirections rotationdanslesdeuxsens DrehbewigunginzweiRichtungen movimientorotativoenlosdos sentidos

direction of rotation

sens de mouvement continu de rotation DrehbewegunginPfeilrichtung movimiento giratorio o rotatorio

en el sentido de la flecha

End of Cycle

caution attention Achtung

atencion;precaucion

Page 7