Alliance Laundry Systems 70400401R2 User Manual

Size:
695.83 Kb
Download

Drying Tumblers

120 Pound Capacity

170 Pound Capacity

Refer to Page 3 for Model Identification

Keep These Instructions for Future Reference.

(If this machine changes ownership, this manual must accompany machine.)

 

 

 

wwww.comlaundry. .com.

Part No. 70400401R2

 

 

 

 

 

 

August 2007

Operation/Programming/Maintenance

Installation must conform with local codes or in the absence of local codes with:

In the U.S.A., installation must conform to the latest edition of the American National Standard Z223.1/ NFPA 54 “National Fuel Gas Code” and Standard ANSI/NFPA 70 “National Electric Code.”

In Canada, installation must comply with StandardsCSA-B149.1or Natural Gas and Propane Code CSA C22.1, latest edition, Canadian Electric Code, Part I.

In Australia, installation must comply with the Australian Gas Association Installation Code for Gas Burning Appliances and Equipment.

WARNING

FOR YOUR SAFETY, the information in this manual must be followed to minimize the risk of fire or explosion or to prevent property damage, personal injury or death.

W033

Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS:

Do not try to light any appliance.

Do not touch any electrical switch; do not use any phone in your building.

Clear the room, building or area of all occupants.

Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.

If you cannot reach your gas supplier, call the fire department.

Installation and service must be performed by a qualified installer, service agency or the gas supplier.

W052

FOR YOUR SAFETY

Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

W053

MISE EN GARDE

POUR VOTRE SÉCURITÉ, les informations de ce guide doivent être respectées afin de réduire les risques d’incendie, d’explosion ou d’éviter les dommages matériels, personnels ou blessures mortelles.

W033R3QU

Ne pas entreposer ou utiliser d’essence ou toutes autres vapeurs et liquides inflammables à proximité de cette machine ou de tout autre appareil.

QUE FAIRE EN CAS D’ODEUR DE GAZ :

Ne pas mettre d’appareil en marche.

Ne pas toucher aux interrupteurs électriques ; ne pas utiliser le téléphone des lieux.

Évacuer la pièce, le bâtiment ou la zone de tous les occupants.

Appeler immédiatement le fournisseur de gaz de la maison d’un voisin. Respecter les instructions communiquées par le fournisseur.

Si vous ne pouvez pas joindre le fournisseur de gaz, appeler le service d’incendie.

L’installation et l’entretien doivent être effectués par un installateur, service d’entretien qualifiés ou par le fournisseur de gaz.

W052R5QU

POUR VOTRE SÉCURITÉ

Ne pas entreposer ou utiliser d’essence ou toutes autres vapeurs et liquides inflammables à proximité de cette unité ou de tout autre appareil.

W053R2QU

IMPORTANT: Information must be obtained from a local gas supplier on instructions to be followed if the user smells gas. These instructions must be posted in a prominent location. Step-by-stepinstructions of the above safety information must be posted in a prominent location near the tumbler for customer use.

70400401

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

1

Table of

Contents

Introduction.........................................................................................

3

Model Identification .............................................................................

3

Customer Service..................................................................................

3

Wiring Diagram ....................................................................................

3

Serial Plate Location.............................................................................

4

Safety Information..............................................................................

5

Explanation of Safety Messages...........................................................

5

Important Safety Instructions ...............................................................

6

Operation.............................................................................................

8

Emergency Stop Button on CE Models................................................

8

Operating Instructions ..........................................................................

8

Control Instructions ..............................................................................

9

Dual Digital Timer Control..............................................................

9

Diagnostic Microprocessor Control.................................................

11

DMP OPL Models ...........................................................................

12

Ignition Control Operation ...................................................................

15

Maintenance ........................................................................................

18

Daily .....................................................................................................

18

Monthly.................................................................................................

19

Quarterly ...............................................................................................

19

Bi-Annually ..........................................................................................

19

Before You Call for Service ...............................................................

22

Customer Service..................................................................................

22

© Copyright 2007, Alliance Laundry Systems LLC

All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher.

2

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

70400401

Introduction

Model Identification

Information in this manual is applicable to these models.

 

 

Gas

 

Steam/Thermal Oil

 

 

 

 

 

 

BA120L

CA120N

BT120S

CU120T

 

BA120N

CT120L

BT120T

IT120S

120 Pound

BT120L

CT120N

BU120S

IT120T

BT120N

CU120L

BU120T

 

 

BU120L

CU120N

CT120S

 

 

BU120N

IT120L

CT120T

 

 

CA120L

IT120N

CU120S

 

 

 

 

 

 

 

BA170L

CA170N

BT170S

CU170T

 

BA170N

CT170L

BT170T

IT170S

170 Pound

BT170L

CT170N

BU170S

IT170T

BT170N

CU170L

BU170T

 

 

BU170L

CU170N

CT170S

 

 

BU170N

IT170L

CT170T

 

 

CA170L

IT170N

CU170S

 

 

 

 

 

 

Includes models with the following control suffixes:

R3 – reversing DX4 OPL

RD – reversing DMP OPL

RQ – reversing dual digital timer

Customer Service

If literature or replacement parts are required, contact the source from which the machine was purchased or contact Alliance Laundry Systems at (920) 748-3950for the name and address of the nearest authorized parts distributor.

For technical assistance, call (920) 748-3121.

Wiring Diagram

The wiring diagram is located in the junction or contactor box.

Models starting Serial No. 0309____ or later will have the wiring diagram part number in the lower portion of the electrical data on the serial plate.

70400401

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

3

Introduction

Serial Plate Location

When calling or writing for information about your product, be sure to mention model and serial numbers. Model and serial numbers are found on serial plate on rear of machine. Refer to Figure 1.

1

1

TMB1298N

120 POUND TUMBLER

170 POUND TUMBLER

TMB1298N

1

Serial Plate

Figure 1

4

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

70400401

Safety Information

Explanation of Safety Messages

Throughout this manual and on machine decals, you will find precautionary statements (“DANGER,” “WARNING,” and “CAUTION”) followed by specific instructions. These precautions are intended for the personal safety of the operator, user, servicer, and those maintaining the machine.

DANGER

Indicates an imminently hazardous situation that, if not avoided, will cause severe personal injury or death.

WARNING

Indicates a hazardous situation that, if not avoided, could cause severe personal injury or death.

CAUTION

Indicates a hazardous situation that, if not avoided, may cause minor or moderate personal injury or property damage.

Additional precautionary statements (“IMPORTANT” and “NOTE”) are followed by specific instructions.

IMPORTANT: The word “IMPORTANT” is used to inform the reader of specific procedures where minor machine damage will occur if the procedure is not followed.

NOTE: The word “NOTE” is used to communicate installation, operation, maintenance or servicing information that is important but not hazard related.

IMPORTANT: Warranty is void unless tumbler is installed according to instructions in the Installation Manual. Compliance with minimum specifications and requirements detailed herein, and with applicable local gas fitting regulations, municipal building codes, water supply regulations, electrical wiring regulations, and any other relevant statutory regulations. Because of varied requirements, applicable local codes should be thoroughly understood and all pre-installationwork arranged for accordingly.

WARNING

Failure to install, maintain, and/or operate this machine according to manufacturer’s instructions may result in conditions which can produce serious injury, death and/or property damage.

W051R1

NOTE: The WARNING and IMPORTANT instructions appearing in this manual are not meant to cover all possible conditions and situations that may occur. It must be understood that common sense, caution and carefulness are factors which CANNOT be built into this tumbler. These factors MUST BE supplied by the person(s) installing, maintaining or operating the tumbler.

Always contact your dealer, distributor, service agent or the manufacturer on any problems or conditions you do not understand.

70400401

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

5

Safety Information

Important Safety Instructions

Save These Instructions

WARNING

Hazardous Voltage. Can cause shock, burn or cause death. Allow machine power to remain off for two minutes prior to working in and around AC inverter drive.

W359

1.Read all instructions before using the tumbler.

2.Refer to the GROUNDING INSTRUCTIONS in the Installation Manual for the proper grounding of the tumbler.

3.Do not dry articles that have been previously cleaned in, washed in, soaked in, or spotted with gasoline, dry cleaning solvents, or other flammable or explosive substances as they give off vapors that could ignite or explode.

4.Do not allow children on or in the tumbler. This appliance is not intended for use by young children or infirm persons without supervision. Young children should be supervised to ensure that they do not play with the appliance.

5.Before the tumbler is removed from service or discarded, remove the door to the drying compartment and the door to the lint compartment.

6.Do not reach into the tumbler if the cylinder is revolving.

7.Do not install or store the tumbler where it will be exposed to water and/or weather.

8.Do not tamper with the controls.

9.Do not repair or replace any part of the tumbler, or attempt any servicing unless specifically recommended in the user-maintenanceinstructions or in publisheduser-repairinstructions that you understand and have the skills to carry out.

10.Do not use fabric softeners or products to eliminate static unless recommended by the manufacturer of the fabric softener or product.

11.To reduce the risk of fire, DO NOT DRY plastics or articles containing foam rubber or similarly textured rubberlike materials.

12.Always clean the lint filter daily.

13.Keep area around the exhaust opening and adjacent surrounding area free from the accumulation of lint, dust, and dirt.

14.The interior of the tumbler and the exhaust duct should be cleaned periodically by qualified service personnel.

15.If not installed, operated and maintained in accordance with the manufacturer’s instructions or if there is damage to or mishandling of this product’s components, use of this product could expose you to substances in the fuel or from fuel combustion which can cause death or serious illness and which are known to the State of California to cause cancer, birth defects or other reproductive harm.

16.Tumbler will not operate with the loading door open. DO NOT bypass the door safety switch to permit the tumbler to operate with the door open. The cylinder will stop rotating when the door is opened. Do not use the tumbler if the cylinder does not stop rotating when the door is opened or starts rotating without pressing or turning the START mechanism. Remove the tumbler from use and call the service person.

17.Tumbler will not operate with lint panel open. DO NOT bypass lint panel safety switch to permit the tumbler to operate with the lint panel open.

18.Do not put articles soiled with vegetable or cooking oil in the tumbler, as these oils may not be removed during washing. Due to the remaining oil, the fabric may catch on fire by itself.

19.To reduce the risk of fire, DO NOT put clothes which have traces of any flammable substances such as machine oil, flammable chemicals, thinner, etc. or anything containing wax or chemicals such as in mops and cleaning cloths, or anythingdry-cleanedat home withdry-cleaningsolvent in the tumbler.

20.Use the tumbler only for its intended purpose, drying water-washedfabrics.

21.ALWAYS disconnect the electrical power to the tumbler before servicing. Disconnect power by shutting off appropriate breaker or fuse.

22.Install this tumbler according to the Installation Manual. All connections for electrical power, grounding, and gas supply must comply with local codes and be made by licensed personnel when required.

6

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

70400401

23.Remove laundry immediately after tumbler stops.

24.Always read and follow manufacturer’s instructions on packages of laundry and cleaning aids. Heed all warnings or precautions. To reduce the risk of poisoning or chemical burns, keep them out of reach of children at all times (preferably in a locked cabinet).

25.Do not tumble fiberglass curtains and draperies unless the label says it can be done. If they are dried, wipe out the cylinder with a damp cloth to remove particles of fiberglass.

26.Always follow the fabric care instructions supplied by the garment manufacturer.

27.Never operate the tumbler with any guards and/or panels removed.

28.DO NOT operate the tumbler if it is smoking, grinding, has missing or broken parts.

29.DO NOT bypass any safety devices.

30.Solvent vapors from dry-cleaningmachines create acids when drawn through the heater of the drying unit. These acids are corrosive to the tumbler as well as to the laundry load being dried. Be suremake-upair is free of solvent vapors.

Safety Information

31.Failure to install, maintain, and/or operate this machine according to the manufacturer’s instructions may result in conditions which can produce bodily injury and/or property damage.

WARNING

To reduce the risk of serious injury, install lockable door(s) to prevent public access to rear of tumblers.

W055

70400401

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

7

Operation

WARNING

To reduce the risk of fire:

DO NOT DRY articles containing foam rubber or similarly textured rubberlike materials.

DO NOT DRY plastics, anything containing wax or chemicals such as mops and cleaning cloths, or anything dry-cleanedat home with adry-cleaningsolvent.

DO NOT TUMBLE fiberglass curtains and draperies unless the label says it can be done. If they are dried, wipe out the cylinder with a damp cloth to remove particles of fiberglass.

W076

To reduce the risk of serious injury, allow cylinder to stop before cleaning lint screen.

W412

Emergency Stop Button on CE Models

All CE approved OPL tumblers are factory equipped with an emergency stop button located on the front panel. Refer to Figure 2.

1

TMB1666N

1 Emergency Stop Button

Figure 2

To operate emergency stop button:

a.Press red emergency stop button to stop all action.

b.To restart machine, pull red emergency stop button out and press START pad or button.

NOTE: Activation of the emergency stop button stops all machine control circuit functions, but DOES NOT remove all electrical power from machine.

Operating Instructions

Step 1: Clean Lint Screen/Compartment

Remove any accumulated lint from the lint screen and compartment. Close panel tightly against tumbler frame and lock panel securely, if applicable.

IMPORTANT: Clean lint screen and lint compartment daily. Failure to clean the lint screen daily will result in higher than normal temperatures that may damage laundry.

Step 2: Load Laundry

Open loading door and load cylinder with laundry. DO NOT OVERLOAD.

NOTE: Overloading causes slow drying and wrinkling.

Close loading door. Tumbler will not operate with the door open.

Step 3: Determine Control Type and

Temperature Setting

Refer to the various controls, pages 9 - 15, follow instructions for the appropriate control type.

The type of fabric being dried will determine the temperature setting. Consult the fabric care label or fabric manufacturer to determine proper temperature setting.

IMPORTANT: Always follow the fabric care instructions supplied by the garment manufacturer.

Step 4: Remove Laundry

When the cycle is complete, open door and remove the laundry.

8

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

70400401