Alliance Laundry Systems 70278501R5EN User Manual

Size:
932.06 Kb
Download

Drying Tumblers

50 Pound Capacity

75 Pound Capacity

Refer to page 3 for Model Identification

Keep These Instructions for Future Reference.

(If this machine changes ownership, this manual must accompany machine.)

Supplement Installation/Operation

www.comlaundry.com

Part No. 70278501R5EN

December 2007

Installation must conform with local codes.

WARNING

FOR YOUR SAFETY, the information in this manual must be followed to minimize the risk of fire or explosion or to prevent property damage, personal injury or death.

W033

Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS:

Do not try to light any appliance.

Do not touch any electrical switch; do not use any phone in your building.

Clear the room, building or area of all occupants.

Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.

If you cannot reach your gas supplier, call the fire department.

Installation and service must be performed by a qualified installer, service agency or the gas supplier.

W052

FOR YOUR SAFETY

Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

W053

IMPORTANT: Information must be obtained from a local gas supplier on instructions to be followed if the user smells gas. These instructions must be posted in a prominent location. Step-by-stepinstructions of the above safety information must be posted in a prominent location near the tumbler for customer use.

Installation/Operation Supplement

WARNING

To reduce the risk of fire, electric shock, serious injury or death to persons when using the tumbler unit, follow these basic precautions:

Read all instructions before using tumbler.

DO NOT tamper with controls.

DO NOT bypass any safety devices.

Always follow the fabric care instructions supplied by the garment manufacturer.

Remove laundry immediately after the tumbler stops.

DO NOT reach into tumbler if cylinder is revolving.

To avoid creating any flammable vapors which may explode, ignite or cause corrosive damage, DO NOT dry the following materials:

Articles that have been cleaned in, soaked in, washed in or spotted with gasoline, dry-cleaningsolvents or other flammable/explosive substances.

Plastics or articles containing foam rubber or similarly textured rubberlike materials.

Articles that have traces of flammable substances like cooking oil, machine oil, flammable chemicals or thinner.

Articles containing wax or cleaning chemicals.

Fiberglass curtains or draperies (unless the label says it can be done).

W440R1

70278501 (EN)

© Published by permission of the copyright owner – DO NOT COPY or TRANSMIT

1

Installation/Operation Supplement

 

 

 

Introduction.........................................................................................

3

Table of

Model Identification .............................................................................

3

 

Wiring Diagram ....................................................................................

3

Contents

Serial Plate Location.............................................................................

4

 

Safety Information..............................................................................

5

 

Important Safety Instructions ...............................................................

5

 

Installation...........................................................................................

7

 

Specifications and Dimensions.............................................................

7

 

Cabinet Dimensions .........................................................................

8

 

Horizontal Exhaust Outlet Locations...............................................

9

 

Gas Connection Locations ...............................................................

10

 

Electrical Connection Locations ......................................................

11

 

Steam Connection Locations ...........................................................

12

 

Position and Level the Tumbler............................................................

13

 

Fire Suppression System.......................................................................

14

 

Water Requirements.........................................................................

14

 

Water Connections...........................................................................

14

 

Electrical Requirements ...................................................................

14

 

Auxiliary Alarm ...............................................................................

14

 

Gas Requirements.................................................................................

15

 

Natural Gas and Liquefied Petroleum..............................................

15

 

European Gas ...................................................................................

16

 

Exhaust Requirements ..........................................................................

18

 

Make-Up Air....................................................................................

18

 

Venting.............................................................................................

18

 

Electrical Requirements........................................................................

19

 

Grounding Instructions ....................................................................

19

 

Steam Requirements .............................................................................

20

 

Thermal Oil Prep ..................................................................................

20

 

Operation.............................................................................................

22

 

Emergency Stop Button on CE Models................................................

22

 

Operating Instructions ..........................................................................

22

 

Step 1: Clean Lint Screen/Compartment .........................................

22

 

Step 2: Load Laundry.......................................................................

22

 

Step 3: Determine Control Type and Temperature Setting .............

22

 

Step 4: Remove Laundry .................................................................

22

 

Control Instructions ..............................................................................

23

 

Electromechanical Coin Control......................................................

23

 

Manual Timer Control .....................................................................

24

 

Dual Digital Timer Control..............................................................

25

 

Single Drop Control.........................................................................

26

 

DMP OPL Control ...........................................................................

27

 

DMP Coin Control...........................................................................

28

 

Ignition Control Operation ...................................................................

29

 

Disposal of Unit ...................................................................................

30

© Published by permission of the copyright owner.

All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher.

2

© Published by permission of the copyright owner – DO NOT COPY or TRANSMIT

70278501 (EN)

Installation/Operation Supplement

Introduction

Model Identification

Information in this manual is applicable to these models:

 

Gas

Steam/Thermal Oil

Electric

 

 

 

 

 

CHD50G2-CU050L

BU050T

CHD50E2-CU050E

50 Pound

CHD50G2-CU050N

CHD50S2-CU050S

DR50E2-BU050E

DR50G2-BU050L

CU050T

 

 

 

 

DR50G2-BU050N

DR50S2-BU050S

 

 

 

 

 

 

CHD75G2-CU075L

BU075T

CHD75E2-CU075E

75 Pound

CHD75G2-CU075N

CHD75S2-CU075S

DR75E2-BU075E

DR75G2-BU075L

CU075T

 

 

 

 

DR75G2-BU075N

DR75S2-BU075S

 

 

 

 

 

Includes models with the following control suffixes:

3O

– DX4 OPL

DV – DMP vended

RQ – reversing dual digital timer

3V

– DX4 vended

DX – DMP prep for coin

RT – reversing manual timer

3X – DX4 prep for coin

MT– manual timer

SD – single drop

CD – rotary coin drop

QT – dual digital timer

SX – single drop, prep for coin

CX – prep for coin

R3 – reversing DX4 OPL

 

DO – DMP OPL

RD – reversing DMP OPL

 

Wiring Diagram

The wiring diagram is located in the junction or contactor box.

70278501 (EN)

© Published by permission of the copyright owner – DO NOT COPY or TRANSMIT

3

Installation/Operation Supplement

Serial Plate Location

1

1

TMB803N

TMB803N

1 Serial Plate

4

© Published by permission of the copyright owner – DO NOT COPY or TRANSMIT

70278501 (EN)

Installation/Operation Supplement

Safety Information

Save These Instructions

Important Safety Instructions

WARNING

Hazardous Voltage. Can cause shock, burn or cause death. Allow machine power to remain off for two minutes prior to working in and around AC inverter drive.

W359

1.Read all instructions before using the tumbler.

2.Refer to the GROUNDING INSTRUCTIONSfor the proper grounding of the tumbler.

3.Do not dry articles that have been previously cleaned in, washed in, soaked in, or spotted with gasoline, dry-cleaningsolvents, or other flammable or explosive substances, as they give off vapors that could ignite or explode.

4.Do not allow children to play on or in the tumbler. This appliance is not intended for use by young children or infirm persons without supervision. Young children should be supervised to ensure that they do not play with the appliance.

5.Before the tumbler is removed from service or discarded, remove the door to the drying compartment and the door to the lint compartment.

6.Do not reach into the tumbler if the cylinder is revolving.

7.Do not install or store the tumbler where it will be exposed to water and/or weather.

8.Do not tamper with the controls.

9.Do not repair or replace any part of the tumbler, or attempt any servicing unless specifically recommended in the user-maintenanceinstructions or in publisheduser-repairinstructions that you understand and have the skills to carry out.

10.Do not use fabric softeners or products to eliminate static unless recommended by the manufacturer of the fabric softener or product.

11.To reduce the risk of fire, DO NOT DRY plastics or articles containing foam rubber or similarly textured rubberlike materials.

12.Always clean the lint filter daily.

13.Keep area around the exhaust opening and adjacent surrounding area free from the accumulation of lint, dust and dirt.

14.The interior of the tumbler and the exhaust duct should be cleaned periodically by qualified service personnel.

15.If not installed, operated and maintained in accordance with the manufacturer’s instructions or if there is damage to or mishandling of this product’s components, use of this product could expose you to substances in the fuel or from fuel combustion which can cause death or serious illness and which are known to the State of California to cause cancer, birth defects or other reproductive harm.

16.Tumbler will not operate with the loading door open. DO NOT bypass the door safety switch to permit the tumbler to operate with the door open. The tumbler will stop tumbling when the door is opened. Do not use the tumbler if it does not stop tumbling when the door is opened or starts tumbling without pressing or turning the START mechanism. Remove the tumbler from use and call for service.

17.Tumbler will not operate with lint panel open. DO NOT bypass lint panel safety switch to permit the tumbler to operate with the lint panel open.

18.Do not put articles soiled with vegetable or cooking oil in the tumbler, as these oils may not be removed during washing. Due to the remaining oil, the fabric may catch on fire by itself.

19.To reduce the risk of fire, DO NOT put clothes which have traces of any flammable substances such as machine oil, flammable chemicals, thinner, etc. or anything containing wax or chemicals such as in mops and cleaning cloths, or anythingdry-cleanedat home withdry-cleaningsolvent in the tumbler.

20.Use the tumbler only for its intended purpose, drying fabrics.

21.ALWAYS disconnect and lockout the electrical power to the tumbler before servicing. Disconnect power by shutting off appropriate breaker or fuse.

70278501 (EN)

© Published by permission of the copyright owner – DO NOT COPY or TRANSMIT

5

Installation/Operation Supplement

22.Install this tumbler according to the

INSTALLATION INSTRUCTIONS. All connections for electrical power, grounding, and gas supply must comply with local codes and be made by licensed personnel when required.

23.Remove laundry immediately after tumbler stops.

24.Always read and follow manufacturer’s instructions on packages of laundry and cleaning aids. Heed all warnings or precautions. To reduce the risk of poisoning or chemical burns, keep them out of reach of children at all times (preferably in a locked cabinet).

25.Do not tumble fiberglass curtains and draperies unless the label says it can be done. If they are dried, wipe out the cylinder with a damp cloth to remove particles of fiberglass.

26.Always follow the fabric care instructions supplied by the garment manufacturer.

27.Never operate the tumbler with any guards and/or panels removed.

28.DO NOT operate the tumbler if it is smoking, grinding, has missing or broken parts.

29.DO NOT bypass any safety devices.

30.Solvent vapors from dry-cleaningmachines create acids when drawn through the heater of the drying unit. These acids are corrosive to the tumbler as well as to the laundry load being dried. Be suremake-upair is free of solvent vapors.

31.Failure to install, maintain, and/or operate this machine according to the manufacturer’s instructions may result in conditions which can produce bodily injury and/or property damage.

WARNING

To reduce the risk of serious injury, install lockable door(s) to prevent public access to rear of tumblers.

W055

6

© Published by permission of the copyright owner – DO NOT COPY or TRANSMIT

70278501 (EN)

 

 

Installation/Operation Supplement

Installation

 

 

Specifications and Dimensions

 

 

 

 

 

 

 

 

 

Specifications

 

50 Pound

 

75 Pound

 

 

 

 

 

Noise level measured during operation at

 

63 dBA

 

69 dBA

operator position of 1 meter (3.3 feet) in front

 

 

 

of machine and 1.6 meters (5.2 feet) from

 

 

 

 

floor.

 

 

 

 

 

 

 

 

 

Net Weight (approximate):

 

247

 

279

kg (lbs.)

 

(545)

 

(615)

 

 

 

 

 

Cylinder Size:

 

940 x 762

 

940 x 914

mm (in.)

 

(37 x 30)

 

(37 x 36)

 

 

 

 

 

Cylinder Capacity (dry weight):

 

22.7

 

34

kg (lbs.)

 

(50)

 

(75)

 

 

 

 

 

Air Outlet Diameter:

 

203

 

203

mm (in.)

 

(8)

 

(8)

 

 

 

 

 

Maximum Static Back Pressure:

 

1.3

 

1.3

mbar (W.C.I.)

 

(0.5)

 

(0.5)

 

 

 

 

Maximum Airflow:

 

354

Gas/Steam 50 Hz 354 (750)

 

(750)

Gas/Steam 60 Hz 434 (920)

L/sec. (C.F.M.)

 

 

 

Electric

354 (750)

 

 

 

 

 

 

 

 

Motor Horsepower:

 

1/2

 

3/4

Nonreversing

 

 

Reversing

 

 

 

 

Fan

 

1/3

 

1/3

Cylinder

 

1/3

 

1/3

 

 

 

 

 

 

 

 

 

Gas Models

 

 

 

 

 

 

 

Gas Connection

 

1/2 in. NPT

 

1/2 in. NPT

 

 

 

 

 

Gas Burner Rating:

 

126.6

 

174.1

Mj/hr (Btu/hr)

 

(120,000)

 

(165,000)

 

 

 

 

 

 

Electric Models

 

 

 

 

 

 

 

Heating Elements Rating:

 

21 kW (240 V/50 Hertz)

 

30 kW

Kilowatts (kW)

 

30 kW (other voltages)

 

 

 

 

 

 

 

 

Steam Models

 

 

 

 

 

 

 

Steam Connection

 

3/4 in. NPT

 

3/4 in. NPT

 

 

 

 

 

Steam Coil Rating:

 

5.1

 

6.1

Btu/hr (Boiler Horsepower)

 

(177,500)

 

(210,300)

 

 

 

 

 

70278501 (EN)

© Published by permission of the copyright owner – DO NOT COPY or TRANSMIT

7

Installation/Operation Supplement

Cabinet Dimensions

C

E

B

 

 

D

A

 

G

F

 

TMB2213N

Models

A

B

C

D

E

F

G

 

 

 

 

 

 

 

 

050

781 mm

717 mm

1194 mm

1946 mm

981 mm

838 mm

749 mm

Gas and

(30.75 in.)

(28.25 in.)

(47 in.)

(76.625 in.)

(38.625 in.)

(33 in.)

(29.5 in.)

Electric

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

050

781 mm

717 mm

1194 mm

2032 mm

981 mm

838 mm

749 mm

Steam

(30.75 in.)

(28.25 in.)

(47 in.)

(80 in.)

(38.625 in.)

(33 in.)

(29.5 in.)

 

 

 

 

 

 

 

 

075

781 mm

717 mm

1346 mm

1946 mm

981 mm

838 mm

902 mm

Gas and

(30.75 in.)

(28.25 in.)

(53 in.)

(76.625 in.)

(38.625 in.)

(33 in.)

(35.5 in.)

Electric

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

075

781 mm

717 mm

1346 mm

2032 mm

981 mm

838 mm

902 mm

Steam

(30.75 in.)

(28.25 in.)

(53 in.)

(80 in.)

(38.625 in.)

(33 in.)

(35.5 in.)

 

 

 

 

 

 

 

 

8

© Published by permission of the copyright owner – DO NOT COPY or TRANSMIT

70278501 (EN)