Alliance Laundry Systems 105 User Manual
Size:
2.7 Mb
Download

Drying Tumblers

30 Pound Capacity (28" Wide)

30 Pound Capacity (31.5" Wide)

Refer to Page 7 for Model Numbers

NOTA: El manual en español aparace después del manual en inglés.

KEEP THESE INSTRUCTIONS FOR FUTURE REFERENCE. (If this tumbler changes ownership, be sure this manual accompanies the tumbler.)

www.comlaundry.com

Installation/Operation/Maintenance

Part No. M414545

September 2002

TABLE OF CONTENTS

SECTION I

Safety

Important Safety Instructions . . . . . . . . . . . . . . . . . . 5

SECTION II

Introduction

Information for Handy Reference . . . . . . . . . . . . . . 7 Parts Ordering Information . . . . . . . . . . . . . . . . . . . 8 Nameplate Location . . . . . . . . . . . . . . . . . . . . . . . . . 8

Roughing-In Dimensions and Specifications

Cabinet Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . 9

Roughing-In Dimensions and Specifications

Exhaust Thimble Locations . . . . . . . . . . . . . . . . . . . 10

Roughing-In Dimensions and Specifications

Steam Connection Locations . . . . . . . . . . . . . . . . . . 11

Roughing-In Dimensions and Specifications

Gas Connection Locations . . . . . . . . . . . . . . . . . . . . 12

Roughing-In Dimensions and Specifications

Electrical Connection Locations . . . . . . . . . . . . . . . 13 28" wide Gas Tumbler . . . . . . . . . . . . . . . . . . . . . . . 14 28" wide Electric Tumbler . . . . . . . . . . . . . . . . . . . . 14 Gas Tumbler . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 Electric Tumbler . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15 Steam Tumbler . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

SECTION III

Installation Instructions

Receiving Inspection . . . . . . . . . . . . . . . . . . . . . . . . 17

Materials Required (Obtain Locally) . . . . . . . . . . . . 17

Gas, Electric or Steam Drying Tumblers . . . . . . 17

Gas Drying Tumblers Only . . . . . . . . . . . . . . . . 17

Steam Drying Tumblers Only . . . . . . . . . . . . . . 17

Positioning the Tumbler . . . . . . . . . . . . . . . . . . . . . . 18

Leveling the Tumbler . . . . . . . . . . . . . . . . . . . . . . . . 18

Tumbler Enclosure Construction . . . . . . . . . . . . . . . 19

Facilities Required . . . . . . . . . . . . . . . . . . . . . . . . . . 20

Floor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

Layout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

Venting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

Make-Up Air . . . . . . . . . . . . . . . . . . . . . . . . . . . 21

Gas Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . 24

Example of Gas Loop Piping . . . . . . . . . . . . . . . . . . 26

Example of Gas Supply Piping . . . . . . . . . . . . . . . . . 26

Steam Requirements (Steam Drying Tumblers) . . . . 28

Piping Recommendations . . . . . . . . . . . . . . . . . . 28

Steam Valve Electrical Connections . . . . . . . . . . 28

Installing Steam Solenoid Valve

and Making Steam Inlet Connections . . . . . . . . 29

Installing Steam Trap and Making Condensate

Return Connections . . . . . . . . . . . . . . . . . . . . . . 29

Steam Requirements

Steam Drying Tumblers Only . . . . . . . . . . . . . . . . . . 30

Electrical Requirements . . . . . . . . . . . . . . . . . . . . . . 31

Grounding Instructions . . . . . . . . . . . . . . . . . . . . 31

Jumper Configuration Instructions

(OPL Micro Control Models Only) . . . . . . . . . . 33

Ring Ferrite Installation

(Gas and Steam OPL Micro Control

Models Only) . . . . . . . . . . . . . . . . . . . . . . . . . . . 33

Electrical Requirements

For 28" wide Tumblers . . . . . . . . . . . . . . . . . . . . . . . 34

Electrical Requirements

For 31.5" wide Tumblers . . . . . . . . . . . . . . . . . . . . . 35

Accessory Timing Cam Installation

(Coin Meter Models) . . . . . . . . . . . . . . . . . . . . . . . . 36

Removal of Existing Timing Cam . . . . . . . . . . . 36

Installation of New Timing Cam . . . . . . . . . . . . 36

Preliminary Operating Checks . . . . . . . . . . . . . . . . . 37

Final Operating Checks . . . . . . . . . . . . . . . . . . . . . . 38

OPL Micro Control Tumbler . . . . . . . . . . . . . . . 38

Manual Dual Timer Tumbler . . . . . . . . . . . . . . . 38

Coin-Operated Tumbler . . . . . . . . . . . . . . . . . . . 38

SECTION IV

Adjustments

Main Gas Burner Air Shutter

All Gas Models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 41

Airflow Switch

For Gas and Electric Tumblers . . . . . . . . . . . . . . . . . 42

Loading Door Switch . . . . . . . . . . . . . . . . . . . . . . . . 43

Loading Door Strike . . . . . . . . . . . . . . . . . . . . . . . . . 44

Chain Drive Nonreversing Models . . . . . . . . . . . . . . 45

Belt Drive Nonreversing Models . . . . . . . . . . . . . . . 45

Belt Drive Reversing Models . . . . . . . . . . . . . . . . . . 46

M414545

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

1

SECTION V

 

SECTION VI

 

Operating Instructions

 

Preventive Maintenance Instructions

 

Manual Dual Timer Tumbler . . . . . . . . . . . . . . . . . .

51

Daily . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

65

Coin-Operated Tumbler . . . . . . . . . . . . . . . . . . . . . .

52

Lint Removal . . . . . . . . . . . . . . . . . . . . . . . . . . . .

65

Reversing Operation . . . . . . . . . . . . . . . . . . . . . .

53

Monthly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

66

Reverse Control Switch . . . . . . . . . . . . . . . . . . .

53

Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

66

Electronically Controlled OPL Tumbler . . . . . . . . . .

54

Lint Removal . . . . . . . . . . . . . . . . . . . . . . . . . . . .

66

Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . .

54

Every Three Months . . . . . . . . . . . . . . . . . . . . . . . . .

66

Status Lights, Signal and Reversing . . . . . . . . . .

56

Lint Removal . . . . . . . . . . . . . . . . . . . . . . . . . . . .

66

Drying Laundry . . . . . . . . . . . . . . . . . . . . . . . . .

56

Belt Tension . . . . . . . . . . . . . . . . . . . . . . . . . . . .

66

Security Lock-Out . . . . . . . . . . . . . . . . . . . . . . .

60

Every Six Months . . . . . . . . . . . . . . . . . . . . . . . . . . .

66

Temperature Adjustment . . . . . . . . . . . . . . . . . .

60

Overall Check . . . . . . . . . . . . . . . . . . . . . . . . . . .

66

Show Mode . . . . . . . . . . . . . . . . . . . . . . . . . . . .

60

Energy Saving Tips . . . . . . . . . . . . . . . . . . . . . . . . . .

68

Temperature Sensor . . . . . . . . . . . . . . . . . . . . . .

60

Service Savers . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

68

 

 

Troubleshooting the Tumbler . . . . . . . . . . . . . . . . . .

69

©Copyright 2002, Alliance Laundry Systems LLC

All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without the expressed written consent of the publisher.

2

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

M414545

Section I

Safety

IMPORTANT: Warranty is void unless drying tumbler is installed according to instructions in this manual. Compliance with minimum specifications and requirements detailed herein, and with applicable local gas fitting regulations, municipal building codes, water supply regulations, electrical wiring regulations, and any other relevant statutory regulations. Because of varied requirements, applicable local codes should be thoroughly understood and all pre-installationwork arranged for accordingly.

In the U.S.A., installation must conform to the latest edition of the American National Standard Z223.1 “National Fuel Gas Code” and Standard ANSI/NFPA 70 “National Electric Code”.

In Canada, installation must comply with Standards CAN1-B149.1orCAN1-B149.2codes for gas burning appliances and equipment and CSA C22.1, latest edition, Canadian Electric Code, Part I.

In Australia, installation must comply with the Australian Gas Association Installation Code for Gas Burning Appliances and Equipment.

WARNING

Failure to install, maintain, and/or operate this machine according to manufacturer’s instructions may result in conditions which can produce serious injury, death and/or property damage.

W051

NOTE: The WARNING and IMPORTANT instructions appearing in this manual are not meant to cover all possible conditions and situations that may occur. It must be understood that common sense, caution and carefulness are factors which CANNOT be built into this tumbler. These factors MUST BE supplied by the person(s) installing, maintaining or operating the tumbler.

Always contact your dealer, distributor, service agent or the manufacturer on any problems or conditions you do not understand.

M414545

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

3

IMPORTANT: Information must be obtained from your local gas supplier on instructions to be followed if the user smells gas. These instructions must posted in a prominent location. Step-by-stepinstructions of the safety information below must be posted in a prominent location near the tumbler for customer use.

WARNING

FOR YOUR SAFETY, the information in this manual must be followed to minimize the risk of fire or explosion or to prevent property damage, personal injury or death.

W033

Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS:

Do not try to light any appliance.

Do not touch any electrical switch; do not use any phone in your building.

Clear the room, building or area of all occupants.

Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.

If you cannot reach your gas supplier, call the fire department.

Installation and service must be performed by a qualified installer, service agency or the gas supplier.

W052

FOR YOUR SAFETY

Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.

W053

AVERTISSEMENT

POUR VOTRE SÉCURITÉ il est impératif de suivre les instructions de ce manuel pour minimiser les risques d’incendie ou d’explosion et pour éviter les dommages matériels, les blessures corporelles ou la mort.

W033Q

Ne pas entreposer ni utiliser d’essence ni d’autres vapeurs ou liquides inflammables dans le voisinage de cet appareil ou de tout autre appareil.

QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ :

Ne pas tenter d’allumer d’apareil.

Ne touchez à aucun interrupteur. Ne pas vous servir des téléphones se trouvant dans le bâtiment où vous vous trouvez.

Évacuez la pièce, le bâtiment ou la zone.

Appelez immédiatement votre fournisseur de gaz depuis un voisin. Suivez les instructions du fournisseur.

Si vous ne pouvez rejoindre le fournisseur de gaz, appelez le service des incendies.

L’installation et l’entretien doivent être assurés par un installateur ou un service d’entretien qualifié ou par le fournisseur de gaz.

W052Q

POUR VOTRE SÉCURITÉ

Ne pas entreposer ni utiliser d’essence ni d’autres vapeurs ou liquides inflammables dans le voisinage de cet appareil ou de tout autre appareil.

W053Q

4

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

M414545

IMPORTANT SAFETY INSTRUCTIONS

(SAVE THESE INSTRUCTIONS)

WARNING

To reduce the risk of fire, electric shock, serious injury or death to persons when using your tumbler, follow these basic precautions:

W054

1.Read all instructions before using the tumbler.

2.Refer to the GROUNDING INSTRUCTIONS for the proper grounding of the tumbler.

3.Do not dry articles that have been previously cleaned in, washed in, soaked in, or spotted with gasoline, drycleaning solvents, other flammable or explosive substances as they give off vapors that could ignite or explode.

4.Do not allow children to play on or in the tumbler. Close supervision of children is necessary when the tumbler is used near children. This is a safety rule for all appliances.

5.Before the tumbler is removed from service or discarded, remove the door to the drying compartment.

6.Do not reach into the tumbler if the cylinder is revolving.

7.Do not install or store the tumbler where it will be exposed to water and/or weather.

8.Do not tamper with the controls.

9.Do not repair or replace any part of the tumbler, or attempt any servicing unless specifically recommended in the User-Maintenanceinstructions or in publisheduser-repairinstructions that you understand and have the skills to carry out.

10.Do not use fabric softeners or products to eliminate static unless recommended by the manufacturer of the fabric softener or product.

11.To reduce the risk of fire, DO NOT DRY plastics or articles containing foam rubber or similarly textured rubberlike materials.

12.Always clean the lint filter before every load. A layer of lint in the filter reduces drying efficiency and prolongs drying time.

13.Keep area around the exhaust opening and adjacent surrounding area free from the accumulation of lint, dust and dirt.

14.The interior of the tumbler and the exhaust duct should be cleaned periodically by qualified service personnel.

15.If not installed, operated and maintained in accordance with the manufacturer’s instructions or if there is damage to or mishandling of this product’s components, use of this product could expose you to substances in the fuel or from fuel combustion which can cause death or serious illness and which are known to the State of California to cause cancer, birth defects or other reproductive harm.

16.Tumbler will not operate with the loading door open. DO NOT bypass the door safety switch by permitting the tumbler to operate with the door open. The tumbler will stop tumbling when the door is opened. Do not use the tumbler if it does not stop tumbling when the door is opened or starts tumbling without pressing or turning the START mechanism. Remove the tumbler from use and call the serviceman. Tumbler will not operate with lint panel open.DO NOT bypass lint panel safety switch by permitting the tumbler to operate with the lint panel open.

M414545

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

5

17.Do not put articles soiled with vegetable or cooking oil in the tumbler, as these oils may not be removed during drying. Due to the remaining oil, the fabric may catch on fire by itself.

18.To reduce the risk of fire, DO NOT put clothes which have traces of any flammable substances such as machine oil, flammable chemicals, thinner, etc. or anything containing wax or chemicals such as in mops and cleaning cloths, or anythingdry-cleanedat home with adry-cleaningsolvent in the tumbler.

19.Use the tumbler only for its intended purpose, drying fabrics.

20.ALWAYS disconnect the electrical power to the tumbler before servicing. Disconnect power by shutting off appropriate breaker or fuse.

21.Install this tumbler according to these INSTALLATION INSTRUCTIONS. All connections for electrical power, grounding, and gas supply must comply with local codes and be made by licensed personnel when required. Do not do it yourself unless you know how!

22.Remove laundry immediately after the tumbler stops.

23.Always read and follow manufacturer’s instructions on packages of laundry and cleaning aids. Heed all warnings or precautions. To reduce the risk of poisoning or chemical burns, keep them out of reach of children at all times (preferably in a locked cabinet).

24.Do not tumble fiberglass curtains and draperies unless the label says it can be done. If they are dried, wipe out the cylinder with a damp cloth to remove particles of fiberglass.

25.Always follow the fabric care instructions supplied by the garment manufacturer.

26.Never operate the tumbler with any guards and/or panels removed.

27.DO NOT operate the tumbler with missing or broken parts.

28.DO NOT bypass any safety devices.

29.Failure to install, maintain, and/or operate this machine according to the manufacturer’s instructions may result in conditions which can produce bodily injury and/or property damage.

30.Run tumbler with a load before putting tumbler into service.

WARNING

To reduce the risk of serious injury, install lockable door(s) to prevent public access to rear of tumblers.

W055

This machine is intended for commercial use.

6

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

M414545

Section II

Introduction

Information in this manual is applicable to these tumbler models.

30 Pound

30 Pound

(28" Wide)

(31.5" Wide)

JT30XG

JT30CG

JT30WE

STB30CG

ST30WE

JTB30CG

DTB30CG

ST30WG

 

ST30XG

JT30EG

 

STB30EG

 

JTB30EG

 

DTB30EG

 

JT30CE

 

STB30CE

 

JTB30CE

 

DTB30CE

 

JT30CSH

 

STB30CSH

 

JTB30CSH

 

DTB30CSH

 

JT30CSL

 

STB30CSL

 

JTB30CSL

 

DTB30CSL

 

 

Conversion Table

Multiply

By

To Obtain

 

Multiply

By

To Obtain

 

 

 

 

 

 

 

BTU

.252

kCal

 

Pounds / sq. in.

.06895

Bars

 

 

 

 

 

 

 

BTU

1055

Joules

 

Pounds / sq. in.

.070

kg / sq. cm.

 

 

 

 

 

 

 

Inch

2.54

Centimeters

 

Pounds (lbs.)

.454

Kilograms

 

 

 

 

 

 

 

Inches W.C.

.036

Pounds / sq. in.

 

Boiler Horsepower

33479

BTU

 

 

 

 

 

 

 

Inches W.C.

.249

kPa

 

Boiler Horsepower

34.5

lbs. Steam / hr.

 

 

 

 

 

 

 

lbf / inch2 (psi)

.0369

kPa

 

CFM

.471

liters / second

ft3

28.32

Liters

 

KW

3414

BTU / hr.

Information For Handy Reference

Date Purchased _________________________________________________________

Model No. _________________________ Serial No. __________________________

Dealer’s Name _________________________________________________________

NOTICE: For your own convenience and protection, record the above information and retain your sales slip for this appliance. The model and serial numbers will be found on the nameplate located on the tumbler. Refer to

Figure 1.

M414545

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

7

PARTS ORDERING INFORMATION

If literature or replacement parts are required, contact the source from whom the machine was purchased or contact Alliance Laundry Systems at (920) 748-3950for the name and address of the nearest authorized parts distributor.

For technical assistance, call (920) 748-3121.

NAMEPLATE LOCATION

When calling or writing about your product, be sure to mention model and serial numbers. Model and serial numbers are located on nameplate as shown.

Nameplate

TMB1961N

Figure 1

8

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

M414545

ROUGHING-INDIMENSIONS AND SPECIFICATIONS

CABINET DIMENSIONS

DEPTH

 

 

WIDTH

 

 

 

 

OPENING

HEIGHT

CLEARANCE

T326IE3A

TUMBLER MODELS

 

OVERALL

 

 

DOOR

 

 

 

 

 

 

HEIGHT

WIDTH

DEPTH

OPENING

 

CLEARANCE

 

 

 

 

 

 

 

 

 

30XG/30WE

72-1/4"(1835 mm)

28" (711 mm)

44-7/8"(1140 mm)

26-3/4"(679 mm)

 

30-3/4"(781 mm)

 

 

 

 

 

 

 

30CG/30EG

72-1/4"(1835 mm)

31-1/2"(800 mm)

46-11/16"(1186 mm)

28-1/4"(717 mm)

 

30-3/4"(781 mm)

 

 

 

 

 

 

 

30CE/30CSH

72-1/4"(1835 mm)

31-1/2"(800 mm)

44-7/8"(1140 mm)

28-1/4"(717 mm)

 

30-3/4"(781 mm)

 

 

 

 

 

 

 

30CSL

72-1/4"(1835 mm)

31-1/2"(800 mm)

45-1/32"(1144 mm)

28-1/4"(717 mm)

 

30-3/4"(781 mm)

 

 

 

 

 

 

 

M414545

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

9

Roughing-InDimensions and Specifications

Exhaust Thimble Locations

30XG and 30WE

ACROSS

 

DEPTH

ACROSS

HEIGHT

HEIGHT

ACROSS

TMB1959N

TUMBLER MODELS

 

HORIZONTAL EXHAUST

 

VERTICAL EXHAUST

 

 

 

 

 

 

 

 

 

DIAMETER

 

ACROSS

HEIGHT

DIAMETER

ACROSS

 

HEIGHT

 

 

 

 

 

 

 

 

 

 

 

 

30XG/30WE

N/A

 

N/A

N/A

6" (152 mm)

3-3/8"(86 mm)

 

3-3/8"(86 mm)

 

 

 

 

 

 

 

 

 

30CG/30CE

8" (203 mm)

 

4-7/16"(113 mm)

21-7/8"(556 mm)

N/A

N/A

 

N/A

30CSL/30CSH

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

30EG

8" (203 mm)

 

4-7/16"(113 mm)

55-3/8"(1407 mm)

N/A

N/A

 

N/A

 

 

 

 

 

 

 

 

 

10

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

M414545

Roughing-InDimensions and Specifications

Steam Connection Locations

 

 

 

 

 

ACROSS

 

 

 

 

 

 

 

 

SPAN

 

 

 

 

 

 

STEAM

 

 

 

 

 

 

 

 

INLET

 

 

 

 

 

 

 

 

HEIGHT

 

 

STEAM

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

 

OUTLET

 

 

 

 

 

 

 

 

HEIGHT

 

 

 

 

 

 

 

T328IE3A

 

 

TUMBLER

 

STEAM INLET

 

 

STEAM OUTLET

 

MODELS

DIAMETER

ACROSS

HEIGHT

SPAN

DIAMETER

ACROSS

HEIGHT

SPAN

 

30CSL

3/4" (19 mm)

14" (356 mm)

68-3/4"

7-1/2"

3/4" (19 mm)

14" (356 mm)

61-1/4"

7-1/2"

30CSH

I.D.

 

(1746 mm)

(190 mm)

I.D.

 

(1556 mm)

(190 mm)

M414545

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

11

Roughing-InDimensions and Specifications

Gas Connection Locations

 

 

ACROSS

 

 

HEIGHT

 

 

 

 

 

T329IE3A

TUMBLER

 

GAS CONNECTION

MODELS

DIAMETER (N.P.T.)

ACROSS

HEIGHT

 

30XG

1/2" (12.7 mm)

12-1/4"(311 mm)

62-1/8"(1578 mm)

30CG/30EG

1/2" (12.7 mm)

15" (381 mm)

62-1/8"(1578 mm)

12

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

M414545

Roughing-InDimensions and Specifications

Electrical Connection Locations

ACROSS

ACROSS

HEIGHT

HEIGHT

Gas & Steam

Electric

 

T330IE3A

TUMBLER

ELECTRICAL SERVICE - GAS & STEAM MODELS

ELECTRICAL SERVICE - ELECTRIC MODELS

MODELS

 

 

 

 

HEIGHT

ACROSS

HEIGHT

ACROSS

 

 

 

 

 

 

30XG/30CG/30EG

65" (1651 mm)

3" (76 mm)

N/A

N/A

 

 

 

 

 

30WE

N/A

N/A

60" (1524 mm)

14" (356 mm)

 

 

 

 

 

30CE

N/A

N/A

60" (1524 mm)

16" (406 mm)

 

 

 

 

 

30CSL/30CSH

65" (1651 mm)

3" (76 mm)

N/A

N/A

 

 

 

 

 

NOTE: These are approximate dimensions only.

M414545

© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT

13